Section 3 (Engine Mechanical - 2.0L (LUZ) Diesel)
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic Wiring Diagrams
- Component Locator
- Diagnostic Information and Procedures
- DTC P06DA-P06DC: Engine Oil Pressure Control Solenoid Valve Control Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Engine Noise Under Load
- Engine Will Not Crank - Crankshaft Will Not Rotate
- Coolant in Combustion Chamber
- Coolant in Engine Oil
- Fuel in Engine Oil
- Turbocharger Whine Noise
- Turbocharger Hissing Noise
- Turbocharger Oil Leak From Compressor Seal
- Turbocharger Oil Leak From Turbine Seal
- Turbocharger Lack of Oil Supply
- Engine Compression Test
- Cylinder Leakage Test
- Engine Oil Level Sensor Diagnosis
- Oil Consumption Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Drive Belt Chirping, Squeal and Whine Diagnosis
- Drive Belt Rumbling and Vibration Diagnosis
- Drive Belt Falls Off and Excessive Wear Diagnosis
- Drive Belt Tensioner Diagnosis
- Dual Mass Flywheel Diagnosis
- DTC P06DA-P06DC: Engine Oil Pressure Control Solenoid Valve Control Circuit
- Repair Instructions - On Vehicle
- Drive Belt Tensioner Replacement
- Engine Sight Shield Replacement
- Powertrain Mount Balancing
- Engine Mount Replacement
- Engine Mount Inspection
- Engine Mount Bracket Replacement
- Belt Idler Pulley Replacement - Pulley Side
- Belt Idler Pulley Replacement - Engine Mount Side
- Belt Idler Pulley Bracket Replacement
- Engine Support Fixture
- Crankshaft Pulley Replacement
- Camshaft Rear Cover Replacement
- Camshaft Housing Replacement
- Camshaft Housing and Cover Gasket Replacement
- Camshaft Front Oil Seal Replacement
- Camshaft Sprocket Replacement
- Exhaust Camshaft Replacement
- Intake Camshaft Replacement
- Valve Rocker Arm Replacement
- Automatic Transmission Flex Plate Replacement
- Timing Belt Front Cover Replacement
- Timing Belt Tensioner Replacement
- Timing Belt Tensioner Bracket Replacement
- Timing Belt Idler Pulley Replacement - Lower
- Generator, Air Conditioning Compressor and Power Steering Pump Belt Replacement
- Positive Crankcase Ventilation Heater Removal and Installation
- Positive Crankcase Ventilation Oil Separator Assembly Replacement
- Intake Manifold Replacement
- Timing Belt Replacement (New Belt)
- Timing Belt Replacement (Used Belt)
- Valve Lifter Replacement
- Turbocharger Wastegate Actuator Vacuum Control Solenoid Valve Hose Replacement
- Turbocharger Replacement
- Turbocharger Oil Feed Pipe Replacement
- Turbocharger Oil Return Pipe Replacement
- Charge Air Cooler Inlet Air Hose Replacement
- Charge Air Cooler Outlet Air Hose Replacement
- Cylinder Head Replacement
- Oil Level Indicator Tube Replacement
- Oil Pan Replacement
- Engine Oil Heater Power Cable Replacement
- Engine Oil Heater Replacement
- Oil Pump Replacement
- Crankshaft Rear Oil Seal Replacement
- Crankshaft Front Oil Seal Replacement
- Crankshaft Sprocket Replacement
- Oil Filter Adapter and Oil Cooler Assembly Replacement
- Engine Oil Pressure Sensor Replacement
- Engine Oil Level Sensor Replacement
- Oil Pump Suction Pipe Replacement
- Engine Replacement
- Engine Oil and Oil Filter Replacement
- Exhaust Gas Recirculation Valve Vacuum Tank Replacement
- Repair Instructions - Off Vehicle
- Engine Oil Cooler Coolant Inlet Hose Installation
- Fuel Return Hose Removal
- Belt Idler Pulley Removal - Pulley Side
- Belt Idler Pulley Removal - Engine Mount Side
- Drive Belt Tensioner Removal
- Exhaust Temperature Sensor Removal
- Heated Oxygen Sensor Removal
- Turbocharger Wastegate Actuator Vacuum Control Solenoid Valve Splash Shield Removal
- Catalytic Converter Heat Shield Removal
- Catalytic Converter Removal
- Turbocharger Heat Shield Removal
- Engine Lift Bracket Removal
- Turbocharger Oil Feed Pipe Removal
- Turbocharger Removal
- Turbocharger Oil Return Pipe Removal
- Exhaust Manifold Removal
- Oil Level Indicator and Tube Removal
- Air Conditioning (A/C) Compressor Removal
- Belt Idler Pulley Bracket Removal
- Engine Oil Cooler Coolant Inlet Hose Removal
- Engine Oil Cooler Coolant Outlet Hose Removal
- Oil Filter Removal
- Oil Filter Adapter and Oil Cooler Assembly Removal
- Oil Filter Adapter Disassemble
- Generator Removal
- Positive Crankcase Ventilation Oil Separator Assembly Removal
- Exhaust Pressure Sensor Pipe Removal
- Exhaust Pressure Sensor Removal
- Timing Belt Front Cover Removal
- Engine Mount Bracket Removal
- Crankshaft Pulley Removal
- Timing Belt Removal
- Timing Belt Idler Pulley Removal - Lower
- Timing Belt Tensioner Removal
- Crankshaft Sprocket Removal
- Water Pump Removal
- Timing Belt Tensioner Bracket Removal
- Fuel Injection Feed Hose Removal
- Fuel Injection Fuel Return Pipe Removal
- Diesel Fuel Separator Removal
- Fuel Feed Pipe Removal
- Fuel Injection Fuel Feed Pipe Removal
- Fuel Injector Removal
- Fuel Rail Removal
- Fuel Feed Hose Protector Removal
- Fuel Injection Pump Driven Sprocket Removal
- Fuel Injection Pump Removal
- Fuel Injection Pump Bracket Removal
- Exhaust Gas Recirculation Pipe Removal
- Exhaust Gas Recirculation Valve Removal
- Throttle Body Assembly Removal
- Engine Coolant Thermostat Housing Removal
- Engine Coolant Temperature Sensor Removal
- Exhaust Gas Recirculation Valve Cooler Removal
- Exhaust Gas Recirculation Valve Cooler Disassemble
- Power Brake Booster Pump Removal
- Camshaft Rear Cover Removal
- Intake Manifold Removal
- Intake Manifold Disassemble
- Glow Plug Removal
- Automatic Transmission Flex Plate Removal
- Camshaft Sprocket Removal
- Camshaft Front Oil Seal Removal
- Camshaft Position Sensor Removal
- Camshaft Housing Removal
- Exhaust Camshaft Removal
- Intake Camshaft Removal
- Valve Lifter Roller Removal
- Cylinder Head Removal
- Cylinder Head Disassemble
- Engine Oil Heater Removal
- Oil Pan Removal
- Oil Pump Removal
- Oil Pan Disassemble
- Crankshaft Position Sensor Removal
- Piston, Connecting Rod and Bearing Removal
- Piston and Connecting Rod Disassemble
- Crankshaft and Bearing Removal
- Piston Oil Nozzle Removal
- Engine Block Core Hole Plug Removal - Timing Side
- Engine Block Core Hole Plug Removal - Transmission Side
- Engine Block Disassemble
- Engine Block Cleaning and Inspection
- Engine Block Assemble
- Engine Block Core Hole Plug Installation - Transmission Side
- Engine Block Core Hole Plug Installation - Timing Side
- Piston Oil Nozzle Cleaning and Inspection
- Piston Oil Nozzle Installation
- Crankshaft and Bearing Cleaning and Inspection
- Crankshaft and Bearing Installation
- Piston, Connecting Rod and Bearing Cleaning and Inspection
- Piston and Connecting Rod Assemble
- Piston, Connecting Rod and Bearing Installation
- Crankshaft Position Sensor Installation
- Oil Pan Cleaning and Inspection
- Oil Pan Assemble
- Oil Pump Installation
- Oil Pan Installation
- Engine Oil Heater Installation
- Cylinder Head Cleaning and Inspection
- Cylinder Head Assemble
- Cylinder Head Installation
- Valve Rocker Arm Cleaning and Inspection
- Valve Lifter Roller Installation
- Camshaft Cover Cleaning and Inspection
- Camshaft Cleaning and Inspection
- Exhaust Gas Recirculation Valve Cooler Installation
- Intake Camshaft Installation
- Exhaust Camshaft Installation
- Camshaft Housing Installation
- Camshaft Position Sensor Installation
- Camshaft Front Oil Seal Installation
- Camshaft Sprocket Installation
- Automatic Transmission Flex Plate Installation
- Glow Plug Installation
- Intake Manifold Cleaning and Inspection
- Intake Manifold Assemble
- Intake Manifold Installation
- Camshaft Rear Cover Installation
- Power Brake Booster Pump Installation
- Exhaust Gas Recirculation Valve Cooler Cleaning and Inspection
- Exhaust Gas Recirculation Valve Cooler Assemble
- Engine Coolant Temperature Sensor Installation
- Engine Coolant Thermostat Housing Installation
- Throttle Body Assembly Installation
- Exhaust Gas Recirculation Valve Installation
- Exhaust Gas Recirculation Pipe Installation
- Fuel Injection Pump Bracket Installation
- Fuel Injection Pump Installation
- Fuel Injection Pump Driven Sprocket Installation
- Fuel Feed Hose Protector Installation
- Fuel Rail Installation
- Fuel Injector Installation
- Fuel Injection Fuel Feed Pipe Installation
- Fuel Feed Pipe Installation
- Diesel Fuel Separator Installation
- Fuel Injection Fuel Return Pipe Installation
- Fuel Injection Feed Hose Installation
- Fuel Return Hose Installation
- Timing Belt Tensioner Bracket Installation
- Water Pump Cleaning and Inspection
- Water Pump Installation
- Crankshaft Sprocket Installation
- Timing Belt Tensioner Installation
- Timing Belt Idler Pulley Installation - Lower
- Timing Belt Installation (New Belt)
- Timing Belt Installation (Used Belt)
- Crankshaft Pulley Installation
- Engine Mount Bracket Installation
- Timing Belt Front Cover Installation
- Exhaust Pressure Sensor Installation
- Exhaust Pressure Sensor Pipe Installation
- Positive Crankcase Ventilation Oil Separator Assembly Installation
- Generator Installation
- Oil Filter Adapter Cleaning and Inspection
- Oil Filter Adapter Assemble
- Oil Filter Adapter and Oil Cooler Assembly Installation
- Oil Filter Installation
- Engine Oil Cooler Coolant Outlet Hose Installation
- Belt Idler Pulley Bracket Installation
- Air Conditioning (A/C) Compressor Installation
- Oil Level Indicator and Tube Installation
- Exhaust Manifold Cleaning and Inspection
- Exhaust Manifold Installation
- Turbocharger Oil Return Pipe Installation
- Turbocharger Cleaning and Inspection
- Turbocharger Installation
- Turbocharger Oil Feed Pipe Installation
- Engine Lift Bracket Installation
- Turbocharger Heat Shield Installation
- Catalytic Converter Installation
- Catalytic Converter Heat Shield Installation
- Turbocharger Wastegate Actuator Vacuum Control Solenoid Valve Splash Shield Installation
- Heated Oxygen Sensor Installation
- Exhaust Temperature Sensor Installation
- Drive Belt Tensioner Installation
- Belt Idler Pulley Installation - Engine Mount Side
- Belt Idler Pulley Installation - Pulley Side
- Description and Operation
- Special Tools and Equipment