Section 9 (Automatic Transmission - 5ET50 (MKE))
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Temperature Versus Resistance (Transmission Fluid Temperature Sensor)
- Fastener Specifications (Off Vehicle)
- Fastener Specifications (On Vehicle)
- Approximate Fluid Capacities
- Transmission General Specifications
- Adhesives, Fluids, Lubricants and Sealers
- Clutch Backing Plate Retaining Ring Specifications
- Automatic Transmission Torque Dampener Thrust Washer Specifications
- Range Reference
- Transmission Internal Mode Switch Logic
- Schematic Wiring Diagrams
- Component Locator
- Disassembled Views
- Case and Associated Parts (1 of 2)
- Case and Associated Parts (2 of 2)
- Transmission Case Assembly (1 of 2)
- Transmission Case Assembly (2 of 2)
- Torque Dampener and Differential Housing Assembly
- Control Valve Body Assembly
- Drive Motor Assembly (1st Position)
- Drive Motor Assembly (2nd Position)
- Output Carrier Internal Gear Assembly
- Variable Low Clutch Assembly
- Variable High Clutch Assembly
- Torque Limiting Clutch Assembly
- Park System Components
- Component Location
- Bushing, Bearing and Washer Locations
- Seal Locations
- Disassembled Views
- Diagnostic Information and Procedures
- DTC P0658 or P0659: Actuator High Control Circuit Group 1 Voltage
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0711-P0713: Transmission Fluid Temperature Sensor
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0721: Output Speed Sensor Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P077B-P077D: Output Speed Sensor Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P079A: Transmission Clutch 1 Slip Detected
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Component Testing
- Repair Instructions
- DTC P079B: Transmission Clutch 2 Slip Detected
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Component Testing
- Repair Instructions
- DTC P07A3: Transmission Clutch 1 Stuck On
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Component Testing
- Repair Instructions
- DTC P07A5: Transmission Clutch 2 Stuck On
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Component Testing
- Repair Instructions
- DTC P0815, P0816 or P0826: Shift Switch Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0960, P0962 or P0963: Transmission Control Solenoid Valve 1 Control Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0964, P0966-P0968, P0970, P0971, P2718, P2720, P2721, P2727, P2729 or P2730: Transmission Control Solenoid Valve Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P16F7: Control Module Pressure Control Solenoid Command Incorrect
- DTC P1761: Up and Down Shift Switch Signal Message Counter Incorrect
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Repair Instructions
- DTC P179C: Transmission Clutch 1 Minor Slip Detected
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Component Testing
- Repair Instructions
- DTC P179D: Transmission Clutch 2 Minor Slip Detected
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Component Testing
- Repair Instructions
- DTC P1824, P182A-P182F, P1838-P1841, P18B5-P18BA, P18BC, P18BF, P18C0, P18C2 or P18C3: Internal Mode Switch
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Transmission Internal Mode Switch Logic
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P215B: Vehicle Speed - Output Shaft Speed Not Plausible
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P215C: Output Shaft Speed - Wheel Speed Not Plausible
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P2670 or P2671: Actuator High Control Circuit Group 2 Voltage
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P27A7: Transmission Control Solenoid Valve 1 Calibration Incorrect
- Solenoid Valve Characterization Reprogramming
- Symptoms - Automatic Transmission
- Hybrid Low Mode Malfunction
- Control Solenoid Valve Inspection
- Output Shaft Speed Input Test
- Control Solenoid Valve Performance Test
- Reset Transmission Adapts
- Control Valve Body Diagnostic Inspection
- Transmission Fluid Level and Condition Check
- Line Pressure Check
- Drive Motor Power Inverter Module Fluid Seal Pressure Test
- Road Test
- Clutch Plate Diagnosis
- Engine Coolant/Water in Transmission
- Case Porosity Repair
- Bushing and Mating Shaft Inspection
- Automatic Transmission Fluid Pump Pressure High or Low
- Automatic Transmission Fluid Leaks
- Fluid Leak Diagnosis
- Whine/Growl Noise That Changes with Vehicle Speed
- Noise in Drive or Reverse Gear
- Vibration
- Noise and Vibration Analysis
- No Park or Drive
- No Drive in All Ranges
- No Reverse Gear
- No Drive or Reverse Gear
- Harsh, Soft, Delayed or Slipping Drive or Reverse Gear
- Stuck in Drive or Reverse Gear
- Harsh Garage Shift
- Seized Engine or Transmission Separation
- DTC P0658 or P0659: Actuator High Control Circuit Group 1 Voltage
- Repair Instructions - On Vehicle
- Transmission Control Lever Knob Replacement
- Transmission Control Replacement
- Drive Motor Generator Power Inverter Module Replacement
- Drive Motor Power Inverter Module Cover Replacement
- Automatic Transmission Range Selector Lever Replacement
- Range Selector Lever Cable Replacement
- Range Selector Lever Cable Adjustment
- Range Selector Lever Cable Bracket Replacement
- Transmission Fluid Drain and Fill
- Automatic Transmission Fluid Pressure Test Hole Plug Replacement
- Front Wheel Drive Shaft Seal Replacement - Left Side
- Front Wheel Drive Shaft Seal Replacement - Right Side
- Manual Shift Shaft Seal Replacement
- Manual Shift Detent Lever Shaft Replacement
- Manual Shift Shaft and Manual Shift Detent Lever Replacement
- Control Valve Body Cover Replacement
- Control Valve Body Replacement
- Line Pressure Control Solenoid Valve Replacement
- Control Solenoid Valve Replacement
- Automatic Transmission Wiring Harness Replacement
- Transmission Mount Strut Bracket Replacement
- Transmission Mount Transmission-Side Bracket Replacement
- Transmission Mount Replacement
- Transmission Rear Mount Replacement
- Transmission Replacement
- Repair Instructions - Off Vehicle
- Holding Fixture Installation
- Drive Motor Power Inverter Module Cover Removal
- Drive Motor Power Inverter Module Removal
- Control Valve Body Cover Removal
- Control Valve Assembly and Transmission Wiring Harness Removal
- Automatic Transmission Torque Dampener and Differential Housing Removal
- Front Differential Carrier Removal
- Input Sun Gear Shaft Removal
- Front Differential Carrier Baffle Removal
- Drive Sprocket, Driven Sprocket and Drive Link Removal
- Drive Link Snubber Removal
- Automatic Transmission Fluid Pump and Fluid Filter Removal
- Manual Shift Detent Lever with Shaft Position Switch Assembly and Park Pawl Actuator Removal
- Drive Motor Removal - 2nd Position
- Output Carrier and Output Carrier Internal Gear Removal
- Drive Motor Removal - 1st Position
- Variable High Clutch Fluid Transfer Support Seal Overhaul
- Front Wheel Drive Shaft Oil Seal Removal - Left Side
- Transmission Case Cleaning and Inspection
- Front Wheel Drive Shaft Oil Seal Installation - Left Side
- Manual Shift Shaft Seal Removal
- Variable Low Clutch Plate Removal
- Variable High Clutch Removal
- Drive Motor Disassemble - 1st Position
- Drive Motor Assemble - 1st Position
- Variable High Clutch Disassemble
- Variable High Clutch Assemble
- Variable High Clutch Backing Plate Retaining Ring Measurement
- Variable High Clutch Installation
- Variable Low Clutch Plate Installation
- Variable Low Clutch Backing Plate Retaining Ring Measurement
- Drive Motor Installation - 1st Position
- Output Carrier Internal Gear Overhaul
- Output Carrier and Output Carrier Internal Gear Installation
- Drive Motor Disassemble - 2nd Position
- Drive Motor Assemble - 2nd Position
- Drive Motor Installation - 2nd Position
- Manual Shift Detent Lever with Shaft Position Switch Assembly and Park Pawl Actuator Installation
- Automatic Transmission Fluid Pump and Fluid Filter Installation
- Drive Link Snubber Installation
- Front Differential Carrier Baffle Installation
- Drive Sprocket, Driven Sprocket and Drive Link Installation
- Input Sun Gear Shaft Installation
- Front Differential Carrier Installation
- Automatic Transmission Torque Dampener and Differential Housing Disassemble
- Front Wheel Drive Shaft Oil Seal Removal - Right Side
- Input Shaft Seal Removal
- Input Shaft Bearing Removal
- Automatic Transmission Torque Dampener and Differential Housing Cleaning and Inspection
- Input Shaft Bearing Installation
- Input Shaft Seal Installation
- Front Wheel Drive Shaft Oil Seal Installation - Right Side
- Input Internal Gear Assembly Overhaul
- Automatic Transmission Torque Dampener and Differential Housing Assemble
- Automatic Transmission Torque Dampener Thrust Washer Measurement
- Automatic Transmission Torque Dampener and Differential Housing Installation
- Control Valve Assembly Disassemble
- Control Valve Assembly Assemble
- Control Valve Assembly and Transmission Wiring Harness Installation
- Control Valve Body Cover Installation
- Drive Motor Power Inverter Module Installation
- Drive Motor Power Inverter Module Cover Installation
- Front Differential Carrier Final Rotational Torque Measurement
- Holding Fixture Removal
- Description and Operation
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission General Description
- Transmission Component and System Description
- Hybrid Transmission Modes of Operation
- Transmission Indicators and Messages
- Electronic Component Description
- Park Engine Off
- Park Engine On
- Neutral Engine Off
- Reverse EV Mode Engine Off
- Drive Single Motor EV Engine Off
- Drive Low Mode Engine On
- Drive High Mode Engine On
- Drive Fixed Ratio Mode Engine On
- Special Tools and Equipment