LEMON Manuals: Even more car manuals for everyone
Home >> Chevrolet >> 2017 >> Malibu LS >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 9 (Automatic Transmission - 5ET50 (MKE)) >> Repair Instructions - On Vehicle >> Control Valve Body Replacement >> Removal Procedure

Removal Procedure

WARNING: This page is about a different variant/trim than selected.
  1. Control Valve Body Cover Replacement  - Remove
  2. Disconnect the control solenoid valve wiring harness.
    Fig 1: Control Valve Body Bolts, Control Solenoid Valve And Filter Plate
    GM4117450Courtesy of GENERAL MOTORS COMPANY
  3. Control Valve Body Bolt (1) - Remove [4x]
  4. Control Solenoid Valve (2) - Remove
  5. Control Solenoid Valve Filter Plate (3) - Remove
  6. Disconnect the control valve body wiring harness.
    Fig 2: Control Valve Body Components
    GM4117463Courtesy of GENERAL MOTORS COMPANY
  7. Fluid Transfer Pipe Bolt (1) - Remove
  8. Fluid Transfer Pipe (2) - Remove
  9. Control Valve Body Bolt (3) - Remove [13x]
  10. Control Valve Body (4) - Remove
  11. Control Valve Body Spacer Plate Retainer (5) - Remove [2x]
  12. Control Valve Lower Body Spacer Plate (6) - Remove and DISCARD
  13. Variable Low Clutch Fluid Passage Seal (7) - Remove and DISCARD
scientia non olet · About LEMON Manuals