Section 2 (Engine Mechanical - 1.6L (LH7) Diesel)
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic Wiring Diagrams
- Component Locator
- Diagnostic Information and Procedures
- DTC P06DA-P06DE
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P25A9, P25AA, or P25AB
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P25AC or P25AD
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Engine Noise Under Load
- Engine Will Not Crank - Crankshaft Will Not Rotate
- Coolant in Combustion Chamber
- Coolant in Engine Oil
- Fuel in Engine Oil
- Engine Compression Test
- Cylinder Leakage Test
- Oil Consumption Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Drive Belt Chirping, Squeal, and Whine Diagnosis
- Drive Belt Rumbling and Vibration Diagnosis
- Drive Belt Falls Off and Excessive Wear Diagnosis
- Drive Belt Tensioner Diagnosis
- Compressor Air Intake Turbocharger Whine Noise
- Compressor Air Intake Turbocharger Hissing Noise
- Compressor Air Intake Turbocharger Oil Leak From Compressor Seal
- Compressor Air Intake Turbocharger Oil Leak From Turbine Seal
- Compressor Air Intake Turbocharger Lack of Oil Supply
- Dual Mass Flywheel Diagnosis
- DTC P06DA-P06DE
- Repair Instructions - On Vehicle
- Engine Sight Shield Replacement
- Generator and Air Conditioning Compressor Belt Replacement
- Belt Idler Pulley Replacement
- Drive Belt Tensioner Replacement
- Engine Mount Replacement
- Engine Mount Bracket Replacement
- Camshaft Housing Replacement
- Camshaft Timing Chain Replacement
- Camshaft Sprocket Replacement
- Camshaft Replacement
- Intake Camshaft Replacement
- Exhaust Camshaft Replacement
- Timing Chain Idler Sprocket Replacement
- Timing Chain Lower Cover Replacement
- Timing Chain Lower Guide Replacement
- Timing Chain Tensioner Replacement
- Timing Chain Tensioner Shoe Replacement
- Timing Chain Upper Cover Replacement
- Timing Chain Upper Guide Replacement
- Crankshaft Pulley Replacement
- Crankshaft Front Oil Seal Replacement
- Crankshaft Rear Oil Seal Replacement
- Crankshaft Position Sensor Reluctor Ring Replacement (Automatic Transmission)
- Cylinder Head Replacement
- Automatic Transmission Flex Plate Replacement
- Engine Oil Level Indicator Switch Replacement
- Engine Oil Pressure Switch Replacement
- Engine Oil Pressure Sensor Replacement
- Engine Oil and Oil Filter Replacement
- Oil Level Indicator Replacement
- Engine Oil Heater Replacement
- Engine Oil Heater Power Cable Replacement
- Oil Pan Replacement (Automatic Transmission)
- Oil Pump Drive Chain and Sprocket Replacement
- Oil Pump Drive Chain Tensioner Replacement
- Oil and Power Brake Booster Pump Replacement
- Intake Manifold Replacement
- Intake Manifold Brace Replacement
- Turbocharger Oil Feed Pipe Replacement
- Turbocharger Oil Return Pipe Replacement
- Compressor Air Intake Turbocharger Replacement
- Valve Lifter Replacement
- Valve Stem Oil Seal and Valve Spring Replacement
- Engine Support Fixture
- Engine Replacement (Automatic Transmission)
- Camshaft Timing Chain Adjustment
- Camshaft Timing Chain Inspection
- Repair Instructions - Off Vehicle
- Engine Mount Bracket Removal
- Belt Idler Pulley Removal
- Drive Belt Tensioner Removal
- Crankshaft Pulley Removal
- Turbocharger Heat Shield Removal
- Catalytic Converter Heat Shield Removal
- Exhaust Temperature Sensor Removal - Position 1
- Exhaust Temperature Sensor Removal - Position 2
- Exhaust Pressure Differential Sensor Pipe Removal
- Catalytic Converter Removal
- Turbocharger Wastegate Actuator Pipe Removal
- Turbocharger Oil Feed Pipe Removal
- Turbocharger Oil Return Pipe Removal
- Compressor Air Intake Turbocharger Removal
- Exhaust Gas Recirculation Cooler Temperature Sensor Removal - Position 1
- Exhaust Manifold Removal
- Thermostat Bypass Pipe Removal
- Water Pump Removal
- Engine Coolant Outlet Pipe Removal
- Exhaust Gas Recirculation Cooler Temperature Sensor Removal - Position 2
- Exhaust Gas Recirculation Cooler Outlet Pipe Removal
- Intake Manifold Brace Removal
- Exhaust Gas Recirculation Cooler Housing Removal
- Throttle Body Assembly Removal
- Fuel Return Hose Removal
- Fuel Injection Fuel Feed Pipe Removal - Fuel Injection Pump to Fuel Rail
- Diesel Fuel Separator Removal
- Intake Manifold Removal
- Charge Air Bypass Regulator Solenoid Valve Vacuum Tube Removal
- Power Brake Booster Inlet Hose Connector Fitting Removal
- Starter Removal
- Generator Removal
- Engine Oil Cooler Removal
- Fuel Injection Fuel Feed Pipe Removal - Fuel Rail to Fuel Injector
- Fuel Pressure Sensor Removal
- Fuel Rail Removal
- Fuel Injector Removal
- Camshaft Housing Removal
- Timing Chain Upper Cover Removal
- Crankshaft Position Sensor Removal
- Crankshaft Position Sensor Reluctor Ring Removal
- Crankshaft Rear Oil Seal Removal
- Automatic Transmission Flex Plate Removal
- Oil Pan Removal
- Timing Chain Lower Cover Removal
- Oil Pump Drive Chain Tensioner Removal
- Oil Pump Drive Chain and Sprocket Removal
- Oil and Power Brake Booster Pump Removal
- Camshaft Timing Chain Removal
- Timing Chain Tensioner Removal
- Timing Chain Tensioner Shoe Removal
- Timing Chain Lower Guide Removal
- Timing Chain Upper Guide Removal
- Timing Chain Idler Sprocket Removal
- Fuel Injection Pump Driven Sprocket Removal
- Fuel Injection Pump Removal
- Camshaft Sprocket Removal
- Intake Camshaft Removal
- Exhaust Camshaft Removal
- Valve Lifter Removal
- Camshaft Position Sensor Removal
- Glow Plug Removal
- Cylinder Head Removal
- Piston, Connecting Rod, and Bearing Removal
- Crankshaft Front Oil Seal Removal
- Crankshaft and Bearing Removal
- Water Pump Disassemble
- Water Pump Cleaning and Inspection
- Water Pump Assemble
- Exhaust Gas Recirculation Cooler Housing Disassemble
- Exhaust Gas Recirculation Cooler Housing Assemble
- Intake Manifold Disassemble
- Intake Manifold Cleaning and Inspection
- Intake Manifold Assemble
- Oil Pan Disassemble
- Oil Pan Cleaning and Inspection
- Oil Pan Assemble
- Camshaft Housing Disassemble
- Camshaft and Housing Cleaning and Inspection
- Camshaft Housing Assemble
- Piston and Connecting Rod Disassemble
- Piston, Connecting Rod, and Bearing Cleaning and Inspection
- Piston and Connecting Rod Assemble
- Crankshaft and Bearing Cleaning and Inspection
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Cylinder Head Assemble
- Engine Block Disassemble
- Engine Block Cleaning and Inspection
- Engine Block Assemble
- Crankshaft and Bearing Installation
- Crankshaft Front Oil Seal Installation
- Piston, Connecting Rod, and Bearing Installation
- Cylinder Head Installation
- Camshaft Position Sensor Installation
- Glow Plug Installation
- Valve Lifter Installation
- Exhaust Camshaft Installation
- Intake Camshaft Installation
- Camshaft Sprocket Installation
- Fuel Injection Pump Installation
- Fuel Injection Pump Driven Sprocket Installation
- Timing Chain Idler Sprocket Installation
- Timing Chain Upper Guide Installation
- Timing Chain Lower Guide Installation
- Timing Chain Tensioner Shoe Installation
- Timing Chain Tensioner Installation
- Camshaft Timing Chain Installation
- Oil and Power Brake Booster Pump Installation
- Oil Pump Drive Chain and Sprocket Installation
- Oil Pump Drive Chain Tensioner Installation
- Timing Chain Lower Cover Installation
- Oil Pan Installation
- Crankshaft Position Sensor Reluctor Ring Installation
- Crankshaft Rear Oil Seal Installation
- Automatic Transmission Flex Plate Installation
- Crankshaft Position Sensor Installation
- Timing Chain Upper Cover Installation
- Camshaft Housing Installation
- Fuel Injector Installation
- Fuel Rail Installation
- Fuel Pressure Sensor Installation
- Fuel Injection Fuel Feed Pipe Installation - Fuel Rail to Fuel Injector
- Engine Oil Cooler Installation
- Generator Installation
- Starter Installation
- Power Brake Booster Inlet Hose Connector Fitting Installation
- Charge Air Bypass Regulator Solenoid Valve Vacuum Tube Installation
- Intake Manifold Installation
- Diesel Fuel Separator Installation
- Fuel Injection Fuel Feed Pipe Installation - Fuel Injection Pump to Fuel Rail
- Fuel Return Hose Installation
- Throttle Body Assembly Installation
- Exhaust Gas Recirculation Cooler Housing Installation
- Intake Manifold Brace Installation
- Exhaust Gas Recirculation Cooler Outlet Pipe Installation
- Exhaust Gas Recirculation Cooler Temperature Sensor Installation - Position 2
- Engine Coolant Outlet Pipe Installation
- Water Pump Installation
- Thermostat Bypass Pipe Installation
- Exhaust Manifold Installation
- Exhaust Gas Recirculation Cooler Temperature Sensor Installation - Position 1
- Compressor Air Intake Turbocharger Installation
- Turbocharger Oil Return Pipe Installation
- Turbocharger Oil Feed Pipe Installation
- Turbocharger Wastegate Actuator Pipe Installation
- Catalytic Converter Installation
- Exhaust Pressure Differential Sensor Pipe Installation
- Exhaust Temperature Sensor Installation - Position 2
- Exhaust Temperature Sensor Installation - Position 1
- Catalytic Converter Heat Shield Installation
- Turbocharger Heat Shield Installation
- Crankshaft Pulley Installation
- Drive Belt Tensioner Installation
- Belt Idler Pulley Installation
- Engine Mount Bracket Installation
- Description and Operation
- Special Tools and Equipment