Section 96 (Body Equipment - Repair -- F55)
WARNING: This page is about a different car, the 2019 MINI Cooper, 2018 MINI Cooper, 2017 MINI Cooper, 2016 MINI Cooper, and 2015 MINI Cooper. However, it is still accessible from the selected car via links, so may be relevant.
- General And Safety Information
- (00 Safety information for working on vehicles with automatic engine start-stop function (MSA))
- (Safety at work)
- Information on vehicle protection
- 51 00... Safety instructions for working on vehicles with airbag systems
- Notes on component bonding with adhesive tape
- Notes
- Repair Notes For Bonded Seals
- Handling Rubber Seal Profiles
- REPAIR PART 1 OF 3 - Clean faulty areas
- REPAIR PART 2 OF 3 - Apply adhesive
- REPAIR PART 3 OF 3 - Press in rubber seal
- REPLACEMENT PART 1 OF 6 - Peeling off the faulty rubber seal
- REPLACEMENT PART 2 OF 6 - Clean bonding surface
- REPLACEMENT PART 3 OF 6 - Detach protective film of the bonding surface
- REPLACEMENT PART 4 OF 6 - Apply rubber seal
- REPLACEMENT PART 5 OF 6 - Establish sealing joint
- REPLACEMENT PART 6 OF 6 - Press gasket
- Checking The Rubber Seal
- Notes on film bonding
- Notes on installation of rubber window seals
- Touching up paintwork damage
- Overview of additional work for the removal and installation or replacement of electronic components in the body area/windshield
- Overview of consumables
- 41 00... Replace bolts
- 41 00... Replacing blind rivets
- Bumper, Front
- 51 11 050 Removing and installing/replacing support for front bumper cover
- 51 11 060 Removing and installing/replacing support for front lower bumper cover
- 51 11 152 Remove and install/replace the center spoiler on bumper cover (Cooper & Cooper S)
- 51 11 156 Remove and install front bumper cover
- 51 11 157 Replace bumper cover, front (Cooper S)
- 51 11 158 Replacing base plate for number/license plate
- 51 11 180 Removing and installing/replacing ornamental grille in bumper cover
- 51 11 300 Removing and installing/replacing center trim
- 51 11 760 Remove and install/replace deformation element for front left bumper
- 51 11 761 Remove and install/replace deformation element for front right bumper
- 51 11 780 Replace the front deformation element on the bottom left
- 51 11 781 Replace the front deformation element on the bottom right
- 51 11... Installing/replacing license plate (without number plate baseplate)
- 51 11 Removing and installing/replacing the air inlet frame for the left or right brake ventilation duct (Cooper S)
- 51 11 Removing and mounting/exchanging side cover of front bumper (Cooper S)
- Bumper, Rear
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- 51 12 070 Replace the center spoiler on rear bumper panel
- 51 12 090 Removing and installing/replacing ornamental grille in bumper trim (Cooper S)
- 51 12 156 Removing and installing rear bumper panel
- 51 12 828 Removing and installing/replacing guide for bumper, rear left or right
- Exterior Trim / Covers
- 51 13 000 Removing and installing/replacing front grille center section
- 51 13 005 Removing and installing/replacing ornamental grille frame
- 51 13 015 Removing and installing/replacing trim ring for left or right headlight
- 51 13 022 Removing and installing/replacing front compartment lid air duct (Cooper S)
- 51 13 085 Removing and installing/replacing trim strip on engine compartment lid (cowl panel)
- 51 13 091 Removing and installing/replacing side panel trim strip, left or right
- 51 13 102 Removing and installing/replacing trim on front left or right wheel arch
- 51 13 105 Removing and installing/replacing trim on rear left or right wheel arch
- 51 13 106 Removing and installing/replacing trim (wheel arch) at rear door, left or right
- 51 13 123 Removing and installing/replacing the windshield panel cover, left
- 51 13 124 Removing and installing/replacing the windshield panel cover, right
- 51 13 305 Removing and installing/replacing left or right roof railing
- 51 13 375 Removing and installing/replacing cover on left or right rear roof pillar (D-pillar)
- 51 13 396 Removing and installing/replacing door pillar cover (outside B-pillar)
- 51 13 402 Removing and installing/replacing the trunk lid handle
- 51 13 425 Removing and installing/replacing cover on left or right tail light
- Emblems / Badges
- Interior Trim / Accessories
- 51 16 000 Removing and installing/replacing the left or right vehicle exterior mirror on the front door
- 51 16 026 Replacing mirror glass
- 51 16 041 Removing and installing/replacing protective cap on left or right outside rearview mirror
- 51 16 063 Removing and installing/replacing interior rearview mirror (as of 07/2011)
- 51 16 063 Removing and installing/replacing interior rearview mirror (overview)
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 085 Removing and installing/replacing sun visor and counter support on driver's side (side)
- 51 16 165 Removing and installing/replacing complete center console
- 51 16 204 Removing and installing/replacing rear cup holder
- 51 16 206 Removing and installing/replacing center armrest
- 51 16 365 Removing and installing/replacing glove compartment cover
- 51 16 366 Removing and installing/replacing right glove compartment with housing
- 51 16 383 Remove and install/replace damper for glove compartment
- 51 16 480 Removing and installing or replacing front grab handle
- 51 16... Calibrating the compass on the inside mirror
- Front Door Locks, Handles, Fittings
- 51 21 003 Replacing front left or right lock striker
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 125 Removing and installing/replacing support for left or right outer door handle with lock cylinder
- 51 21 126 Removing and installing/replacing support for left or right outer door handle without lock cylinder
- 51 21 140 Removing and installing/replacing complete lock cylinder in left or right front door
- 51 21 170 Removing and installing/replacing the outside door handle on the left or right front door
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 235 Remove and install/replace Bowden cable for inner door opener on left or right front door
- 51 21 280 Remove and install/replace door stop of the front left or front right door
- 51 21 300 Removing and installing/replacing the window channel strip on the outside of the front door
- 51 21 330 Removing and installing/replacing window channel strip on inner front door
- 51 21 370 Removing and installing/replacing cover at bottom left or right on front door
- 51 21... Removing window channel strip with special tool 00 9 324 at front or rear
- Rear Door Locks, Handles, Fittings
- 51 22 001 Replacing door detent (lock striker), rear left or right
- 51 22 004 Adjusting rear left or right door lock striker
- 51 22 090 Removing and installing/replacing the door lock in the left or right rear door
- 51 22 126 Removing and installing/replacing support for outer door handle in left or right rear door
- 51 22 225 Removing and installing/replacing inside door opener of rear left or right door
- 51 22 233 Removing and installing/replacing Bowden cable for outer door handle in left or right rear door
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 280 Removing and installing/replacing the door check on the left or right rear door
- 51 22 300 Removing and installing/replacing window channel strip on outside of rear door
- 51 22 330 Removing and installing/replacing the window channel strip on the inside of the rear door
- 51 22 370 Removing and installing/replacing cover (gasket) on rear door at bottom left or right
- Hood Latch, Locks
- 51 23 004 Adjusting engine compartment lid catch
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 131 Removing and installing/replacing striker on engine compartment lid
- 51 23 211 Removing and installing/replacing cable for front engine compartment locks (in engine compartment)
- 51 23 212 Removing and installing/replacing cable for engine compartment lock, front (in passenger compartment)
- 51 23 265 Removing and installing/replacing left or right gas spring for engine compartment lid
- 51 23 400 Removing and installing/replacing left or right actuator (active pedestrian protection)
- 51 23... Adjusting/replacing bump stops
- 51 23... Removing/installing ball sockets with clip
- Tailgate Latch, Locks
- Windscreen And Rear Window
- General procedure for the disassembly and installation of bonded window glass
- 51 31 011 Replace windshield
- 51 31 015 Repairing damage to windshield caused by stone chips (clear and tinted laminated safety glass)
- 51 31 021 Removing and installing/replacing windshield rubber frame
- 51 31 045 Removing and installing/replacing trim for left or right A-pillar
- 51 31 200 Removing and installing/replacing rear window
- 51 31 284 Removing and installing/replacing lower cover on rear window
- Instructions for repairing stone chip damage on laminated safety glass (clear and tinted)
- Materials for bonding window
- Notes on window bonding repair kit
- Overview, rain sensor (additional work when replacing the windshield/sensor replacement)
- 51 31... Remove windshield with "Roll Out 2000"
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31... Window glass removal with wire pull handle
- Front Side Windows
- Front Power Window Regulator
- Rear Side Windows
- Rear Power Window Regulator
- Hinged Side Window
- Front Door Interior Trim / Panels
- Rear Door Interior Trim / Panels
- Interior Side Trim Panels
- 51 43 000 Removing and installing/replacing rear left or right side trim panel
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- 51 43 148 Removing and installing or replacing trim panel on left or right door pillar (top)
- 51 43 150 Removing and installing or replacing trim for left or right door pillar (bottom)
- 51 43 201 Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- 51 43 251 Removing and installing or replacing trim panel for left or right rear roof pillar (C-pillar)
- 51 43 320 Removing and installing/replacing trim panel for rear roof pillar (D-pillar), left (right)
- Headlining
- 51 44 001 Removing and installing/replacing headlining (without sliding/tilting sunroof)
- 51 44 011 Removing and installing or replacing headlining (with sliding/tilting sunroof)
- 51 44 152 Removing and installing/replacing front roofliner cover
- 51 44 156 Removing and installing/replacing rear roofliner trim
- Trim Panels, Dashboard / Instrument Panel
- 51 45 030 Removing and installing instrument panel trim
- 51 45 031 Replacing instrument panel trim
- 51 45 075 Removing and installing/replacing carrier for dashboard
- 51 45 080 Replace decorative strip of right storage compartment
- 51 45 106 Removing and installing (replacing) function carrier on instrument panel trim
- 51 45 180 Removing and installing (replacing) lower left instrument panel trim
- 51 45 195 Removing and installing/replacing instrument panel trim, bottom right
- 51 45 370 Removing and installing (replacing) left decorative strip on dashboard
- 51 45 380 Removing and installing (replacing) right decorative strip on dashboard
- 51 45 435 Removing and installing/replacing cover for instruments
- 51 45 460 Remove and install/replace top dashboard storage compartment
- 51 45... Removing and installing/replacing side panel on dashboard on left or right
- 51 45... Removing and installing (replacing) side center console trim panel
- Trim Panels, Rear Interior
- Floor / Luggage Compartment / Engine Compartment Trim Panels, Floor Mats
- 51 47 000 Removing and installing/replacing front left or right door sill cover strip
- 51 47 030 Removing and installing/replacing (inside) rear left or right entrance cover strip
- 51 47 101 Removing and installing/replacing luggage compartment floor covering
- 51 47 151 Removing and installing/replacing left/right trunk wheel arch trim
- 51 47 312 Replacing footrest for front vehicle interior
- 51 47 314 Removing and installing/replacing carpet for passenger compartment
- 51 47 490 Removing and installing/replacing underbody protection (front)
- 51 47 491 Removing refitting/replacing rear engine undercover
- Sound Insulation
- Trim Panel, Rear Lid / Window Frame
- Exterior Body Trim
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing the rear left or right wheel arch cover
- 51 71 360 Remove and install/replace seal for trunk lid
- 51 71 412 Removing and installing/replacing rear spoiler
- 51 71 418 Replacing cover on trim panel for cover on side member, left or right
- 51 71 447 Detaching and attaching/replacing trim panel for left or right door sill
- 51 71 096 Removing and installing/replacing the automatic air flap control
- 51 71... Remove and install/replace left or right lower front brake air duct
- Seals / Door Edge Protection
- Underbody Panels