Section 10 (Alarm, Doors And Lids - Removal, Replacement And Installation (644 Body))
WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
- Alarm (2001-2004)
- Glass breakage sensor and cable harness
- Hood catch with and without switch
- Led (VGLA)
- Receiver
- Siren
- Tilt sensor
- Ultrasonic or glass breakage control module
- Ultrasonic sensor and cable harness
- VGLA-control module
- Fuel Tank Filler Cover (2003-2004)
- Fuel Tank Filler Cover (2001)
- Fuel Tank Filler Cover (Ch -850514; 2002)
- Fuel Tank Filler Cover (Ch 850515-999999; 2002)
- Locks And Handles (2001-2004)
- Central locking motor for the front side door
- Central locking motor for the rear side door
- Central locking motor for the trunk lid or tailgate
- Door module switch, front side door
- Door switches
- Lock and handle for the front side door
- The lock for the front side door
- The outer door handle for the front side door
- Removing the outer door handle for the front side door
- Removing the lock switch, driver's door
- Removing the lock cylinder, driver's door
- Removing the lock cylinder, passenger door
- Repair kit for the door lock cylinder
- Installing the lock cylinder, driver's door
- Installing the lock cylinder, passenger door
- Installing the lock switch, driver's door
- Installing the outer door handle for the front side door
- Replacing the door handle
- The lock unit and handle for the rear side door
- The switch for the child-proof lock
- Trunk/tailgate switch
- Power Window Mechanism (2001-2004)
- Replacement Of Components (2000)
- Checking/replacing operating switch
- Control unit, replacing/installing
- Door lock front door
- Door insulation, removal
- Removing the guide rails for the windows
- Inner lock unit front, removing
- Removing the door opener handle
- Lock switch in door lock, driver's door, removing
- Lock cylinder without lock switch, installing/removing
- Lock cylinder with lock switch, installing/removing
- Lock switch driver's door, installing
- Installing the door opening handle
- Inner lock unit front, installing
- Installing the guide rails for the windows
- Front door
- Front door lift mechanisms
- Rear door lock
- Removing rear door panel
- Remove insulation partly
- Removing window guide rail
- Removing handgrip (not for interior lock assembly)
- Removing interior lock assembly
- Installing interior lock assembly
- Installing guide plate
- Adjusting rods
- Installing handgrip
- Installing window guide rail
- Installing insulation
- Installing rear door panel
- Rear door window mechanism
- Removing/installing motor
- Removing/installing slide and tilt roof cassette assembly
- Preparation
- Removing cassette
- Installing cassette
- Install Drainage Hoses & Wiring
- Headlining, installing
- Install the headlining
- Installing loose components
- Installing the rear interior lighting, 5 door models
- Installing the cover for the high-mounted stop lamp, 4 door models
- Installing the C-post panel
- Installing the D-post panel, 5 door models
- Installing the rear reading lamps or lenses
- Installing the rear grab handle
- Installing the front grab handle
- Installing the B-post panel
- Installing the A-post panel
- Installing the sun visor and holder
- Installing the ultrasonic sensor (alarm)
- Installing the interior lighting
- Removing/installing sun shade
- Replacing boot lid components
- Sliding and tilting sun roof
- Possible causes of squeaking, knocking, rattling and rustling
- Seals
- Removing/installing sliding and tilting sun roof (glass panel)
- Removing/installing the glass panel
- Adjusting the glass panel in the roof opening
- Adjusting the glass panel vertically
- Checking the sun roof for wind noise
- Removing/installing the wind deflector
- Replacing the seal
- Removing/installing the weatherstrip for the sun roof
- Tailgate & Doors
- Replacing the tailgate
- Removing entire tailgate
- Installing the tailgate
- Adjusting the tailgate
- Adjusting doors
- Adjusting rear doors
- Adjusting the striker plate
- Installing and removing the door panel from rear doors
- Installing and removing rear door hinges
- Installing and removing rear door stops
- Installing and removing the door assembly
- Tailgate components, changing
- Trunk lid
- Replacement Of Components. Central Locking System (2000)
- Replacement Of Components. VGLA (2000)
- Replacing The Mechanical Emergency Opening Cable For The Tailgate (2002-2004)
- Side Door With Controls (2001-2004)
- Sun Roof (2001-2004)
- Tailgate (2001-2004)