Removing/installing the weatherstrip for the sun roof
WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
Remove:
- Remove the glass panel. See Removing/installing the glass panel
- Mark out the positions of the corner sections
- Remove the rubber seal (pull it off)
- Clean the glass panel.
Install:
- Install the new rubber seal; use a plastic mallet
- Install the corner sections according to the markings
- Install the glass panel and adjust it. See Adjusting the glass panel in the roof opening .
NOTE:
Check for any wind noise. See Checking the sun roof for wind noise .