Section 3785 (Body Equipment - Repair - F12)
WARNING: This page does not describe the selected car, but rather 33 other vehicles, including the 2018 BMW M6, 2018 BMW 650i xDrive, 2018 BMW 650i, 2018 BMW 640i xDrive, and 2018 BMW 640i. However, it is still accessible from the selected car via links, so may be relevant.
- General
- 51 00... Engine compartment lid service position (active from 09/2011)
- 51 00... Notes on component bonding adhesive tape
- 51 00... Notes on fitting window guide seals
- 51 00... Overview of consumables
- 41 00... Replacing blind rivets
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 51 00... Safety instructions for working on cars with airbag systems
- 51 00... Service position of engine compartment lid
- 51 00... Service position of engine compartment lid (active up to 09/2011)
- 51 00... Service position of soft top compartment lid
- Front Bumper
- 51 11 156 Removing and installing (replacing) front bumper panel
- 51 11 183 Removing and installing (replacing) ornamental grille for bumper panel (side)
- 51 11... Removing and installing/replacing chrome strip in bumper panel (side)
- 51 11 770 Removing and installing/replacing front left or right deformation element for bumper
- 51 11 180 Removing and installing/replacing ornamental grille (middle) in bumper panel
- 51 11 055 Removing and installing/replacing support for front bottom bumper panel
- 51 11 050 Removing and installing/replacing support for front bumper panel
- 51 11... Repair of front bumper panels on front version with active pedestrian protection
- 51 71 100 Replacing all cooling air routings for radiator
- 51 11 158 Replacing base plate for number/license plate
- 51 11 773 Replacing front lower left or right deformation element
- Rear Bumper
- 51 00... Overview of consumables
- 51 12 156 Removing and installing (replacing) rear bumper panel
- 51 12 825 Removing and installing/replacing guide for rear center bumper panel
- 51 12 828 Removing and installing/replacing guide for the bumper panel, rear left or right
- 51 12... Removing and installing/replacing lower cover (middle)
- 51 12 315 Removing and installing/replacing rear diffuser
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- Trim, Covers, Handle Trim
- 51 13 316 Removing and installing or replacing trim strip on gutter strip at left or right
- 51 13 116 Removing and installing/replacing cowl panel cover
- 51 13 001 Removing and installing/replacing front radiator grille, middle left or right
- 51 13 061 Replacing wheel arch trim on front left or right side panel (Japanese national-market version)
- BMW Emblems, Model Emblems
- Mirrors/Covers/Ashtrays/Shelves/Trays
- 51 16 992 Disassembling and assembling lock barrel (lock barrel removed)
- 51 16 167 Removing and installing (replacing) center armrest cover
- 51 16 165 Removing and installing (replacing) center console overview
- 51 16 180 Removing and installing (replacing) center console support
- 51 16 178 Removing and installing (replacing) side clip at center console
- 51 16... Removing and installing/replacing cup holder decorative trim
- 51 16 190 Removing and installing/replacing lock cylinder in center armrest
- 51 16 000 Removing and installing or replacing mirror on left or right front door
- 51 16 045 Removing and installing or replacing retaining ring on left or right exterior mirror
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 366 Removing and installing right glove box with housing
- 51 16 172 Removing and installing/replacing center armrest storage compartment
- 51 16 160 Removing and installing/replacing center console cover
- 51 16 041 Removing and installing/replacing cover cap on left or right exterior mirror
- 51 16 383 Removing and installing/replacing damper for glove box
- 51 16 273 Removing and installing/replacing fastener for center armrest
- 51 16 202 Removing and installing/replacing front cupholder
- 51 16 365 Removing and installing/replacing glove box cover
- 61 31 334 Removing and installing/replacing grip trim for gear selector switch
- 51 16 040 Removing and installing/replacing housing on left or right exterior mirror
- 51 16 040 Removing and installing/replacing housing on left or right exterior mirror (with turn indicator)
- 51 16 063 Removing and installing/replacing interior mirror (as of 07/2011)
- 51 16 063 Removing and installing/replacing interior mirror (overview)
- 51 16... Removing and installing/replacing oddments tray/ashtray in center console
- 51 16 163 Removing and installing/replacing rear center console cover
- 51 16... Removing and installing/replacing side trim panels (carpet) on center console on left or right
- 61 31 172 Removing and installing/replacing switch for electromechanical parking brake
- 61 31 172 Removing and installing/replacing switch for electromechanical parking brake (M6 with twin-clutch gearbox)
- 61 31 172 Removing and installing/replacing switch for electromechanical parking brake (manual transmission)
- 51 16 227 Removing and installing/replacing trim on center console at side left or right
- 51 16 026 Replacing mirror glass
- 51 16 368 Replacing right glove box with housing
- Lids
- 51 17 001 Removing (replacing) and installing cover on soft top compartment lid
- 51 17 010 Removing and installing/replacing sealing on soft top compartment lid on front left or right
- 41 63 000 Removing and installing flap for fuel filler neck
- 51 17 101 Removing and installing/replacing left and right trim strip on cover for soft top compartment lid
- 51 17 005 Removing and installing/replacing sealing on soft top compartment lid, center (sealing strip at top)
- 51 17 100 Removing and installing/replacing trim strip on cover for soft top compartment lid center
- Front Door Locks, Handles, Fittings
- 51 21 004 Adjusting front left or right lock striker
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 170 Removing and installing or replacing outer door handle from left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 330 Removing and installing/renewing weather strip on inner front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 233 Removing and installing/replacing Bowden cable for outer door handle on left or right front door
- 51 21 140 Removing and installing/replacing complete lock barrel in left or right front door
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 280 Removing and installing/replacing door stop on left or right front door
- 51 21 125 Removing and installing/replacing support for left or right outer door handle with lock barrel
- 51 21 126 Removing and installing/replacing support for left or right outer door handle without lock barrel
- 51 21 301 Removing and installing/replacing weather strip on outside of front door
- 51 21... Removing weather strip with special tool 00 9 324 at front or rear
- 51 21 003 Replacing door detent (lock striker), front left or right
- Rear Door Locks, Handles, Fittings
- Hood Latch, Locks
- 51 23 004 Adjusting engine compartment lid catch
- 51 23 131 Adjusting left or right striker on engine compartment lid
- 51 23... Adjusting/replacing bump stops (apply to relevant vehicle type)
- 51 23... Check actuator
- 51 23... Checking hood/bonnet locks
- 51 23 101 Removing and installing/replacing left active engine compartment lid lock
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 400 Removing and installing/replacing left or right actuator (active pedestrian protection), vehicles from 09/2011
- 51 23 265 Removing and installing/replacing left or right gas pressure spring for engine compartment lid
- 51 23 211 Removing and installing/replacing pull cable for hood/bonnet locks at front
- 51 23 201 Removing and installing/replacing release mechanism for retaining hook on engine compartment lid
- 51 23 111 Removing and installing/replacing right active engine compartment lid lock
- 51 23... Removing/installing ball sockets with clip
- Trunk Latch, Locks
- 51 24 004 Adjusting rear lid lock
- 51 23... Adjusting/replacing bump stops
- 51 24 300 Removing and installing or replacing left or right gas pressure spring for tailgate
- 51 24 146 Removing and installing/replacing button for rear lid actuation
- 51 24 130 Removing and installing/replacing striker for tailgate lock
- 51 24 100 Removing and installing/replacing tailgate lock
- 51 23... Removing/installing ball sockets with clip
- 67 10 522 Replacing (removing and installing) the drive unit for rear view camera
- Front And Rear Window
- 62 30... General notes on the Head-Up Display
- 51 31... General procedure when dismantling/installing bonded window glass
- 51 31... Instructions for repairing stone chip damage on laminated safety glass (clear and tinted)
- 51 31... Repair instructions for laminated safety glass
- 51 31... Materials for bonding window
- 51 31... Notes on window bonding repair kit
- 61 35... Overview, rain sensor (additional work when replacing the windscreen/sensor replacement)
- 51 31... Remove windscreen with "Roll Out 2000"
- 51 31 000 Removing and installing windscreen
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31 015 Repairing damage to windscreen caused by stone chips (clear and tinted laminated safety glass)
- 51 31 011 Replace windscreen
- 51 45... Replacing resilient sealing tape for inspection glass in windscreen (additional work)
- 51 31... Window glass removal with wire pull handle
- Front Manually Operated Windows
- Front Electrically Operated Windows
- Rear Electrically Operated Windows
- 51 37 154 Adjusting rear left or right side window
- 51 37... Adjusting the rear left and right window cavity gap
- 51 37 000 Removing and installing complete rear left or right power window regulator
- 51 37 240 Removing and installing or replacing outer window cavity cover strip for door window, rear left or right
- 51 37 265 Removing and installing/replacing inner window cavity cover strip for door window, rear left or right
- 51 37 003 Replacing rear left or right power window regulator
- 51 37 171 Replacing rear left or right side window
- Electrical Power Windows, Body
- 51 37 154 Adjusting rear left or right side window
- 51 37... Adjusting the rear left and right window cavity gap
- 51 37 000 Removing and installing complete rear left or right power window regulator
- 51 37 240 Removing and installing or replacing outer window cavity cover strip for door window, rear left or right
- 67 62 020 Removing and installing/replacing flat motor for rear left or right power window regulator
- 51 37 265 Removing and installing/replacing inner window cavity cover strip for door window, rear left or right
- 51 37 003 Replacing rear left or right power window regulator
- 51 37 171 Replacing rear left or right side window
- Front Door Trim Panel With Arm Rest
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 41 000 Removing and installing left or right front door trim panel
- 51 41 030 Removing and installing/replacing decorative strip on front left or right door trim panel
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 41... Removing and installing/replacing speaker cover (tweeter) on front left or right door trim panel
- 51 41... Removing and installing/replacing switch cover on front (driver's side) left or right door trim panel
- 51 41 001 Replacing left or right front door trim panel
- 51 41... Replacing speaker trim (mid-range speaker) on left or right front door trim panel
- Rear Door Trim Panel With Arm Rest
- Side Covering With Armrests
- 51 46 026 Removing and installing or replacing front air outlet trim grille
- 51 43 201 Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- 51 43 002 Removing and installing rear left or right side trim panel
- 51 43 004 Removing and installing/replacing decorative strip on left or right side trim panel
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- 51 43... Removing and installing/replacing speaker cover on left or right side trim panel
- 51 43 005 Replacing rear left or right side trim panel
- Roof Trim Panel
- Instrument Cluster Trim Panel
- 51 45 370 Removing and installing (replacing) left decorative strip on dashboard
- 51 45 184 Removing and installing (replacing) trim panel for pedal mechanism (ECE only)
- 51 45 184 Removing and installing (replacing) trim panel for pedal mechanism (US only)
- 51 45 030 Removing and installing instrument panel trim
- 51 45 115 Removing and installing speaker frame on panel for instrument panel at top
- 51 45 195 Removing and installing/replacing bottom right instrument panel trim (US version only)
- 51 45 385 Removing and installing/replacing middle decorative strip on dashboard
- 51 45... Removing and installing/replacing side panel on dashboard (with switch for front passenger airbag deactivation) on the left and right
- 51 45... Removing and installing/replacing side panel on dashboard on left or right
- 51 45 075 Removing and installing/replacing support for dashboard
- 51 45 195 Removing and installing/replacing trim for lower right instrument panel (ECE only)
- 51 45 031 Replacing instrument panel trim
- 51 45... Replacing resilient sealing tape for inspection glass in windscreen (additional work)
- Parcel Shelf Trim Pan, Roller Sun Blind
- Floor, Luggage, Engine Compartment Trim Panels
- 51 47 165 Remove and install/replace top luggage compartment trim panel
- 51 47 315 Removing and installing/replacing front carpet for passenger compartment
- 51 47 490 Removing and installing/replacing front underbody protection
- 51 46 026 Removing and installing or replacing front air outlet trim grille
- 51 47 316 Removing and installing/replacing carpet for rear passenger compartment
- 51 47 000 Removing and installing/replacing front (inside) left or right entrance cover strip
- 51 47 066 Removing and installing/replacing illuminated rocker panel trim on front left or right entrance (outer)
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 71 015 Removing and installing/replacing left or right underbody panelling
- 51 12... Removing and installing/replacing lower cover (middle)
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47... Removing and installing/replacing luggage compartment storage compartment
- 51 47 140 Removing and installing/replacing panel for luggage compartment partition wall
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch panel
- 51 47 065 Removing and installing/replacing rocker panel trim on front left or right entrance (outer)
- 51 71... Removing and installing/replacing sound insulation for bulkhead upper part
- 51 47... Removing and installing/replacing storage net at front footwell
- 51 47 491 Removing refitting/replacing rear engine undercover
- 51 47 312 Replacing footrest for front passenger compartment
- Front Lid Insulation Lining
- Rear Lid Trim Panel
- Reinforcement, Body
- Front Panel, Front End
- Gaskets/Seals, Loose Body Components
- 51 71... Installing and removing/replacing vehicle hoist mounting
- 51 71 345 Removing and installing/replacing left (rear) suspension cross-brace
- 51 71 346 Removing and installing/replacing right (rear) suspension cross-brace
- 51 71... Removing and installing or replacing service flap of left or right cover (from 09/2008)
- 51 71 447 Removing and installing or replacing trim panel for cover on left or right side member
- 51 71 387 Removing and installing/renewing rear water channel cover (rear lid) on left or right
- 51 71... Removing and installing/replacing (front) left or right suspension cross-brace
- 51 13 116 Removing and installing/replacing cowl panel cover
- 51 71 120 Removing and installing/replacing cowl panel seal
- 51 71 480 Removing and installing/replacing cross reinforcement (on rear axle) (N55, N63)
- 51 71 480 Removing and installing/replacing cross reinforcement (on rear axle)
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover (front and rear sections)
- 51 71 038 Removing and installing/replacing front left or right wheel arch cover (front section)
- 51 71 039 Removing and installing/replacing front left or right wheel arch cover (rear section)
- 51 64 010 Removing and installing/replacing left or right V-support
- 51 76 035 Removing and installing/replacing left or right engine compartment lid seal locator
- 51 75 010 Removing and installing/replacing left or right steering assembly cover
- 51 71 482 Removing and installing/replacing left or right tension strut (on rear axle) (N55, N63)
- 51 71 482 Removing and installing/replacing left or right tension strut (on rear axle)
- 51 71 015 Removing and installing/replacing left or right underbody panelling
- 51 76 030 Removing and installing/replacing rear engine hood/bonnet seal
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 385 Removing and installing/replacing rear middle water gutter trim (rear lid)
- 51 71... Removing and installing/replacing sound insulation for bulkhead upper part
- 51 64 020 Removing and installing/replacing the top rear connection (connection of both wheel arches at front)
- 51 64 025 Removing and installing/replacing upper front connection
- 51 71 100 Replacing all cooling air routings for radiator
- 51 71 115 Replacing seal on left or right front door
- 51 72... Sealing installation
- MUCKET For Doors
- Underbody Panelling