Section 35 (Body Equipment - Repair - E90)
WARNING: This page is about a different variant/trim than selected.
- Safety Information
- General
- 51 00... Notes on component bonding adhesive tape
- 51 00... Notes on fitting window guide seals
- 51 00... Overview of consumables (BMW Electronic Parts Catalogue)
- 51 00.. Overview of front door
- 51 00.. Overview of rear door
- 51 00... Safety instructions for working on cars with airbag systems
- 51 00... Service position of engine compartment lid
- Front Bumper
- 51 11... Installing/replacing number/license plate (without base)
- 51 11.. Overview of front bumper
- 51 11 180 Removing and installing/replacing center grille for bumper trim
- 51 11 185 Removing and installing/replacing side grille for bumper trim
- 51 11 156 Removing and installing front bumper trim
- 51 11... Removing and installing/replacing cover for headlight cleaning system on left
- 51 11 185 Removing and installing/replacing side trim grille in bumper trim (M Technic aerodynamic kit)
- 51 11 050 Removing and installing/replacing support for front bumper panel
- 51 11 157 Replace bumper panel, front
- 51 11 158 Replacing baseplate for license plate
- Rear Bumper
- 51 12.. Overview of rear bumper
- 51 12.. Overview of rear bumper (M Technic aerodynamic kit)
- 51 12... Predrill mounting holes for RDC trigger transmitter (only applicable to construction period from 03/09 to 09/09 with M Technic aerodynamic package)
- 51 12... Remove and install rear bumper panel
- 51 12 156 Removing and installing rear bumper panel
- 51 12... Removing and installing/replacing bottom middle trim on rear bumper (M Technic aerodynamic kit)
- 51 12... Removing and installing/replacing guide for bumper at rear bottom middle
- 51 12 825 Removing and installing/replacing guide for rear center bumper
- 51 12 801 Removing and installing/replacing holder for rear left or right bumper
- 51 12 828 Removing and installing/replacing left or right guide for rear bumper
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- 51 12 821 Replacing both holders for rear bumper
- 51 12 157 Replacing rear bumper trim
- 51 12... Replacing trim on rear bumper (M Technic aerodynamic kit)
- Trim, Covers, Handle Trim
- 51 13 116 Removing and installing cowl panel cover
- 51 13 001 Removing and installing/replacing front radiator grille, middle left or right
- 51 13 025 Removing and installing/replacing left or right trim on engine hood/bonnet
- 51 13 280 Removing and installing/replacing trim strip on roof frame at left or right
- 51 13 316 Removing and installing/replacing trim strip on roof gutter at left or right
- 51 13 286 Replacing bracket for roof luggage rack on left or right
- 51 13 117 Replacing cowl panel cover
- BMW Emblems, Model Emblems
- 51 14... General notes for labelling with adhesive films
- 51 14... Instructions for attaching number/letter designation combination
- 51 14 000 Removing and installing/replacing front BMW badge
- 51 14 010 Removing and installing/replacing rear BMW badge
- 51 14 110 Removing and installing/replacing rear model designation
- 51 14 110 Removing and installing/replacing rear model designation\n (brilliance)
- Mirrors/Covers/Ashtrays/Shelves/Trays
- 51 16... Calibrating compass in interior rearview mirror
- 51 16 992 Disassembling and assembling lock cylinder (lock cylinder removed)
- 51 16... Gluing of mirror base
- 51 16... Overview of storage compartment (center console)
- 51 16 206 Removing and installing/replacing center armrest
- 51 16... Removing and installing drawer in luggage compartment
- 51 16 480 Removing and installing or replacing front grab handle
- 51 16 000 Removing and installing or replacing mirror on left or right front door
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 360 Removing and installing right glove box
- 51 16 366 Removing and installing right glove box (with airbag) with housing
- 51 16 366 Removing and installing right glovebox with housing
- 51 16 200 Removing and installing storage compartment
- 51 16 212 Removing and installing trim for storage compartment
- 51 16 060 Removing and installing/renewing inside mirror (with Japanese inside mirror with electronic toll function)
- 51 16 383 Removing and installing/replacing damper for glovebox
- 51 16 202 Removing and installing/replacing front (inner or outer) cup holder
- 51 16 040 Removing and installing/replacing housing on left or right door mirror
- 51 16 154 Removing and installing/replacing insert for center console
- 51 16 060 Removing and installing/replacing inside mirror (with high-beam assistant)
- 51 16 060 Removing and installing/replacing inside mirror (with mirror arm end caps)
- 51 16 060 Removing and installing/replacing inside mirror (with rain sensor)
- 51 16 060 Removing and installing/replacing interior rearview mirror (overview)
- 51 16 342 Removing and installing/replacing lock barrel for front passenger airbag deactivation
- 51 16 340 Removing and installing/replacing lock for right glovebox
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 045 Removing and installing/replacing retaining ring on left or right exterior mirror
- 51 16 400 Removing and installing/replacing roller sun blind on fixed side window of left or right rear door
- 51 16 405 Removing and installing/replacing roller sun blind on side window of left or right rear door
- 51 16 210 Removing and installing/replacing trim for preselector lever
- 51 16 284 Replace one of the drink holder covers in front (inner or outer)
- 51 16 156 Replacing ashtray insert
- 51 16 026 Replacing mirror glass
- 51 16 361 Replacing right glovebox
- 51 16 201 Replacing storage compartment
- 51 16 213 Replacing trim for storage compartment
- Lids
- Lock Cylinders, Assembly
- Front Door Locks, Handles, Fittings
- 51 21 004 Adjusting front left or right door detent (lock wedge)
- 51 21 150 Blocking, if necessary initializing, car key in immobilizer control module
- 51 21... Overview of front door locks
- 51 21 090 Overview of removing and installing/replacing door lock in left or right front door
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 170 Removing and installing or replacing outside door handle from left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 181 Removing and installing/renewing cover on outside handle with lock cylinder
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 233 Removing and installing/replacing Bowden cable for outside door handle on left or right front door
- 51 21 125 Removing and installing/replacing carrier for left or right outside door handle with lock cylinder
- 51 21 126 Removing and installing/replacing carrier for left or right outside door handle without lock cylinder
- 51 21 140 Removing and installing/replacing complete lock barrel in left or right front door
- 51 21 180 Removing and installing/replacing cover on outside door handle
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 280 Removing and installing/replacing door stop on left or right front door
- 51 21 330 Removing and installing/replacing window cavity cover strip on inner front door
- 51 21... Removing weather strip with special tool 00 9 324 at front or rear
- 51 21 182 Replacing cover on outer handle with lock barrel
- 51 21 003 Replacing door detent (lock striker), front left or right
- 51 21 147 Replacing locks for single key locking system with CAS control unit
- Rear Door Locks, Handles, Fittings
- 51 22 004 Adjusting rear left or right door lock striker
- 51 22... Overview of rear door locks
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 233 Removing and installing/replacing Bowden cable for outside door handle on left or right rear door
- 51 22 126 Removing and installing/replacing carrier for outside door handle on left or right rear door
- 51 22 180 Removing and installing/replacing cover on outside handle, left or right
- 51 22 090 Removing and installing/replacing door lock in left or right rear door
- 51 22 280 Removing and installing/replacing door retainer on rear left or right door
- 51 22 225 Removing and installing/replacing inside door opener of rear left or right door
- 51 22 170 Removing and installing/replacing outer door handle on left or right rear door
- 51 22 330 Removing and installing/replacing window cavity cover strip on inside rear door
- 51 22 300 Removing and installing/replacing window cavity cover strip on rear door on left or right
- 51 22 001 Replacing door detent (lock striker), rear left or right
- 51 22 360 Replacing seal for door seam/roof frame on left or right rear door
- Hood Latch, Locks
- 51 23 004 Adjusting engine compartment lid catch
- 51 23 131 Adjusting left or right striker on engine hood
- 51 23... Adjusting/replacing bump stops
- 51 23 160 Removing and installing/replacing arrester hook on engine hood
- 51 23 155 Removing and installing/replacing bar for retaining hook
- 51 23 211 Removing and installing/replacing cable for front engine hood locks (to passenger compartment)
- 51 23 212 Removing and installing/replacing cable for front hood/bonnet locks (to locks)
- 51 23 110 Removing and installing/replacing left hood/bonnet lock
- 51 23 265 Removing and installing/replacing left or right gas pressure spring for engine compartment lid
- 51 23 100 Removing and installing/replacing right engine hood/bonnet lock
- 51 23... Removing/installing ball sockets with clip
- Trunk Latch, Locks
- 51 24 004 Adjusting rear lid lock (lower section of rear lid lock)
- 51 24 300 Removing and installing or replacing left or right gas strut for rear lid
- 51 24 145 Removing and installing/replacing button for tailgate activation
- 51 24 050 Removing and installing/replacing lock element (lock cylinder) for rear lid
- 51 24 100 Removing and installing/replacing rear lid lock (upper section)
- 51 24 130 Removing and installing/replacing striker for rear lid lock
- Front And Rear Window
- 51 31... General procedure when dismantling/installing bonded window glass
- 1 General information
- 2 Disassembly
- 3 Installation
- 3.1 Preparation
- 3.2 Pre-treatment of bonding surfaces
- 3.3 Remove adhesive residue from the body and window glass
- 3.4 Installation of spacer (spacer buffer/dual-lock tapes)
- 3.5 Add-on part
- 3.6 Pre-treatment of new window glass
- 3.7 Version with inspection glass for vehicle identification number in windscreen
- 3.8 Nozzle preparation
- 3.9 Apply adhesive
- 3.10 Mounting the window glass
- 3.11 Adjusting the window glass
- 3.12 Fixing the window glass
- 3.13 Label
- 51 31... Materials for bonding window
- 51 31... Notes on window bonding
- 51 31... Notes on window bonding repair kit
- 51 31... Remove windscreen with "Roll Out 2000"
- Notes
- Windscreen removal system "Roll Out 2000"
- Mounting suction cup lifters on windscreen or rear window
- Preparatory work
- Pulling cutting wire into vehicle
- Using wire starter
- Laying cutting wire around window glass
- Protect the passenger compartment
- Attaching wire in hoisting winch with double coil
- Starting the dismantling
- 51 31 021 Removing and installing/replacing rubber frame for windscreen (top)
- 51 31 023 Removing and installing or replacing left or right gutter strip along windscreen
- 51 31 000 Removing and installing/renewing windscreen
- 51 31 200 Removing and installing/replacing rear window
- 51 31... Removing and installing/replacing retaining strip for cowl panel cover
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31 015 Repairing damage to windscreens caused by stone chips (clear and tinted laminated safety glass)
- 51 31 025 Replacing left or right gutter strip along windscreen
- 51 31 242 Replacing rubber frame (bottom) for rear window
- 51 31 241 Replacing rubber frame (top/side) for rear window
- 51 31... Window glass removal with wire pull handle
- 51 31... General procedure when dismantling/installing bonded window glass
- Front Manually Operated Windows
- 51 32 160 Remove and install/replace housing cover on inner left or right side window frame
- 51 32 170 Removing and installing/replacing door window glass, front left or right
- 51 32 420 Removing and installing/replacing trim on front door window frame, left or right
- 51 32 211 Replacing front left or right rubber guide for left or right door window
- Front Electrically Operated Windows
- Rear Manually Operated Windows
- 51 34 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 34 420 Removing and installing/replacing trim on window frame of rear door (front), left or right
- 51 34 191 Replacing left or right fixed door window in rear window frame
- 51 34 171 Replacing rear left or right door window
- 51 34 211 Replacing rubber guide for rear left or right door window
- 51 34... Replacing the left or right window guide rail cover
- Electrical Power Windows, Body
- Front Door Trim Panel With Arm Rest
- 51 41 000 Removing and installing left or right front door trim panel
- 51 41 017 Removing and installing/replacing cover on front door handle (passenger side)
- 51 41 030 Removing and installing/replacing decorative strip on front left or right door trim panel
- 51 41 019 Removing and installing/replacing door handle on door trim panel at front (passenger side) left or right
- 51 41 081 Replacing armrest on front left or right door trim panel (driver's side)
- 51 41 001 Replacing front left or right door trim panel
- 51 41 018 Replacing speaker trim on front left or right door trim panel
- Rear Door Trim Panel With Arm Rest
- 51 42 000 Removing and installing left or right rear door trim panel
- 51 42 017 Removing and installing/replacing cover on door handle, rear left or right
- 51 42 030 Removing and installing/replacing decorative strip (light strip) on rear left or right door trim panel
- 51 42 001 Replacing left or right rear door trim panel
- 51 42 018 Replacing speaker trim on rear left or right door trim panel
- Side Covering With Armrests
- 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- 51 43 150 Removing and installing or replacing trim for left or right door pillar (bottom)
- 51 43 201 Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- 51 43 148 Removing and installing or replacing trim on left or right door pillar (top)
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left (driver side)
- 51 43 251 Removing and installing/replacing trim panel for left or right rear roof pillar (C-pillar)
- Roof Trim Panel
- Instrument Cluster Trim Panel
- 51 45... Overview of instrument panel
- 51 45 370 Removing and installing (replacing) left decorative strip on instrument panel
- 51 45 380 Removing and installing (replacing) right decorative strip on dashboard
- 51 45... Removing and installing carrier for instrument panel
- 51 45 030 Removing and installing instrument panel trim
- 51 45 181 Removing and installing/replacing bottom right trim for instrument panel
- 51 45 263 Removing and installing/replacing instrument panel trim on right
- 51 45 185 Removing and installing/replacing panel for pedals
- 51 45 031 Replacing instrument panel trim
- 51 45... Replacing side cover on instrument panel
- Parcel Shelf Trim Pan./Roller Sun Blind
- 51 46 001 Removing and installing panel for rear window shelf (parcel shelf)
- 51 46 005 Removing and installing trim for oddments tray (back shelf with rear window roller blind and through-loading system)
- 51 46 013 Removing and installing/replacing rear window roller blind
- 51 46 050 Removing and installing/replacing top trim on rear apron
- 51 46... Removing and installing/replacing trim on rear window shelf (parcel shelf)
- 51 46 007 Replacing panel for rear window shelf (parcel shelf)
- 51 46 004 Replacing trim for oddments tray (back shelf with rear window roller blind and through-loading system)
- 51 46 002 Replacing trim panel for rear window storage shelf (parcel shelf)
- Floor / Luggage Compartment / Engine Compartment Trim Panels
- 51 47 065 Removing and installing/replacing finishing strip at front left or right entrance
- 51 47 315 Removing and installing/replacing front carpet for passenger compartment
- 51 47 490 Removing and installing/replacing front underbody protection
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch trim
- 51 47... Removing and installing storage tray in luggage compartment on left
- 51 47 072 Removing and installing/replacing finishing strip at rear left or right entrance
- 51 47 171 Removing and installing/replacing flap in luggage compartment trim on right
- 51 47 000 Removing and installing/replacing front (inside) left or right door sill cover strip
- 51 47 490 Removing and installing/replacing front underbody protection (AWD)
- 51 47... Removing and installing/replacing left or right underbody panelling
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 030 Removing and installing/replacing rear (inside) left or right entrance cover strip
- 51 47 440 Removing and installing/replacing rear carpet on seat pan
- 51 47 491 Removing and installing/replacing rear underbody protection
- 51 47 312 Replacing footrest for front passenger compartment
- Front Lid Insulation Lining
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 48 001 Removing and installing/replacing insulation lining on hood/bonnet
- 51 48... Removing and installing/replacing sound insulation on cowl panel/windscreen
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 48 070 Removing and installing/replacing sound insulation on left or right rear door
- Rear Lid Trim Panel
- Gaskets/Seals, Loose Body Components
- 51 71... Notes on fitting covers in front wheel arch
- 51 71 000 Removing and installing/replacing seal on front door, left or right
- 51 71 200 Removing and installing/replacing seal on rear door, left or right
- Notes
- Position of sealing (3) on rear door
- Positioning aid "C2" for rear door, left ("D2" right)
- Positioning aid "C1" for rear door, left ("D1" right)
- Positioning aid "C3" for rear door, left ("D3" right)
- Only E90, positioning aid "C6" for rear door, left ("D6" right)
- Only E91, positioning aid "C7" for rear door, left ("D7" right)
- Positioning aid "C5" for rear door, left ("D5" right)
- Positioning aid "C4" for rear door, left ("D4" right)
- 51 13 116 Removing and installing cowl panel cover
- 51 71... Removing and installing/replacing cover for carbon canister
- 51 71 038 Removing and installing/replacing front left or right wheel arch cover (front section)
- 51 71 039 Removing and installing/replacing front left or right wheel arch cover (rear section)
- 51 71... Removing and installing/replacing left or right reinforcement cover
- 51 71... Removing and installing/replacing left or right reinforcement cover (all-wheel drive vehicle)
- 51 71... Removing and installing/replacing left or right steering box cover
- 51 71... Removing and installing/replacing left spring support passage cover
- 51 71... Removing and installing/replacing multifunction pan
- 51 71... Removing and installing/replacing radiator seal
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71... Removing and installing/replacing right spring support passage cover
- 51 71 103 Removing and installing/replacing top cooling air guide
- 51 71 371 Removing and installing/replacing trailing link on left or right spring strut dome
- 51 71 447 Removing and installing/replacing trim for cover on left or right side member (from 09/08)
- 51 71 407 Replacing rear spoiler (M)
- MUCKET For Doors