Section 24 (Climate Units - Removal, Replacement And Installation (644 Body))
WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
- Air Distribution (2001-2004)
- Climate Control Module (2000)
- Climate Control Unit (2000)
- Components For Climate Unit (2001-2004)
- Climate Control System
- Comfort Module
- Damper Motor For Air Distribution
- Engine Coolant Temperature (ECT) Sensor (A/C)
- Evaporator
- Expansion Valve
- Fan Motor
- General Information About Temperature Sensors
- Heat Exchanger
- Interior Temperature Sensor (ECC)
- Outside Temperature Sensor
- Passenger Compartment Fan Housing
- Power Unit Blower Fan
- Recirculation
- Replacing the Blower Fan Relay
- Sun Sensor
- Temperature Damper Motor
- Temperature Sensor Evaporator
- Compressor (2000)
- Control (2001-2004)
- Control Panel (MCC) (2000)
- Damper Motors (2000)
- Performance Test (2000)
- Pipes And Hoses (2000)
- Pipes And Hoses
- Replacing Pipes And Hoses
- Notes
- Pipes And Hoses, Overview
- Preparations
- The Hose/Pipe Between the Compressor And the Evaporator
- The Pipe Between the Evaporator And the Swivel Connection On the Firewall
- The Pipe Between the Swivel Connection And the Receiver Drier On the Firewall
- The Pipe Between the Receiver Drier And the Condenser
- The Hose Between the Compressor And the Compressor
- Installation
- Filling With Refrigerant
- Replacing Pipes And Hoses
- Pipes And Hoses
- Receiver/Drier (2000)
- Replacing Components. Additional Heater (2000-2004)
- Coolant Hose Between Engine And Heater, Replace
- Coolant Hose Between Heater And Coolant Pump, Replace
- Outside Temperature Sensor And Glow Plugs, Replace
- Overheating Protection Thermostat, Flame Sensor And Coolant Temperature Sensor, Replace
- Replacing Fuel Injection Nozzle, Fan Motor And Nozzle Pipe
- Replacing Fuel Line
- Replacing Heat Exchanger
- Replacing the Control Module
- Replacing the Fuel Pump
- Replacing the Water Pump
- Replacing Components. Parking Heater (2000-2004)
- Sensors (2000)
- Ventilation Vents (2000)
- Air Conditioning (2001-2004)
- Compressor
- Condenser
- Condenser Fan
- Electromagnetic Clutch
- Pipes And Hoses
- Notes
- General
- Pipes And Hoses, Overview
- A1: Left-Hand Drive: Remove Hose/Pipe Between Compressor And Evaporator
- A2: Right-Hand Drive And Diesel: Remove the Hose From the Compressor
- A3: Right-Hand Drive And Diesel: Remove the Pipe Between Connector And Evaporator
- B1: Left-Hand Drive: Remove the Pipe Between the Evaporator And the Swivel Connection On the Bulkhead
- B2: Left-Hand Drive: Remove the Pipe Between the Swivel Connection And the Dryer On the Bulkhead
- B3: Right-Hand Drive: Remove the Pipe Between Evaporator And Dryer
- C: Remove the Pipe Between Dryer And Condenser
- D: Remove the Hose Between Compressor And Condenser
- Install Pipe
- Tightening Torques For Pipes And Hoses
- Cooling System, Draining/Refilling
- Draining And Filling the Cooling System
- Replacing Coolant
- Receiver Drier