Section 3 (Engine Mechanical - 2.0L (LHU))
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Fastener Specifications
- Approximate Fluid Capacities
- Engine Mechanical Specifications
- Adhesives, Fluids, Lubricants, and Sealers
- Thread Repair Specifications (LDK, LHU)
- Engine Block- Front View
- Engine Block- Back View
- Engine Block- Right Side View
- Engine Block- Bottom View
- Engine Block- Left Side View
- Engine Block- Top View
- Lower Crankcase- Front View
- Lower Crankcase- Back View
- Lower Crankcase- Bottom View
- Lower Crankcase- Right View
- Lower Crankcase- Left View
- Cylinder Head- Top View
- Cylinder Head- Intake Manifold Deck View
- Cylinder Head- Exhaust Manifold Deck View
- Cylinder Head- Front View
- Cylinder Head- Back View
- Schematic Wiring Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises (LDK, LHU)
- Base Engine Misfire with Abnormal Internal Lower Engine Noises (LDK, LHU)
- Base Engine Misfire with Abnormal Valve Train Noise (LDK, LHU)
- Base Engine Misfire with Coolant Consumption (LDK, LHU)
- Base Engine Misfire with Excessive Oil Consumption (LDK, LHU)
- Engine Noise on Start-Up, but Only Lasting a Few Seconds (LDK, LHU)
- Upper Engine Noise, Regardless of Engine Speed (LDK, LHU)
- Lower Engine Noise, Regardless of Engine Speed (LDK, LHU)
- Engine Noise Under Load (LDK, LHU)
- Engine Will Not Crank - Crankshaft Will Not Rotate (LDK, LHU)
- Coolant in Combustion Chamber (LDK, LHU)
- Coolant in Engine Oil (LDK, LHU)
- Turbocharger Whine Noise (LDK, LHU)
- Turbocharger Hissing Noise (LDK, LHU)
- Turbocharger Oil Leak From Compressor Seal (LDK. LHU)
- Turbocharger Oil Leak From Turbine Seal (LDK, LHU)
- Turbocharger Lack of Oil Supply (LDK. LHU)
- Engine Compression Test
- Cylinder Leakage Test
- Engine Oil Level Sensor Diagnosis
- Oil Consumption Diagnosis
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis (With Turbocharger)
- Drive Belt Chirping, Squeal, and Whine Diagnosis
- Drive Belt Rumbling and Vibration Diagnosis
- Drive Belt Falls Off and Excessive Wear Diagnosis
- Drive Belt Tensioner Diagnosis
- Repair Instructions - On Vehicle
- Belt Idler Pulley Replacement
- Drive Belt Replacement
- Drive Belt Tensioner Replacement
- Engine Oil Pressure Switch Replacement
- Engine Oil Level Sensor Replacement
- Oil Pressure Relief Valve Replacement
- Engine Mount Inspection
- Engine Mount Bracket Replacement
- Engine Support Fixture
- Powertrain Mount Balancing
- Powertrain Mount Balancing - Lower
- Engine Lift Front Bracket Replacement
- Engine Lift Rear Bracket Replacement
- Engine Mount Replacement
- Oil Level Indicator Tube Replacement
- Positive Crankcase Ventilation Hose/Pipe/Tube Replacement (Camshaft Cover to Air Cleaner Outlet Duct Rear)
- Positive Crankcase Ventilation Hose/Pipe/Tube Replacement (Camshaft Cover to Turbocharger)
- Positive Crankcase Ventilation Tube Replacement - Camshaft Cover to Air Cleaner Outlet Duct Rear
- Positive Crankcase Ventilation Tube Replacement - Camshaft Cover to Turbo Charger
- Turbocharger Heat Shield Replacement
- Turbocharger Brace Replacement
- Turbocharger Replacement
- Turbocharger Oil Feed Pipe Replacement
- Turbocharger Oil Return Pipe Replacement
- Turbocharger Coolant Feed Pipe Bracket Replacement
- Engine Sight Shield Replacement
- Engine Sight Bracket Replacement
- Intake Manifold Replacement
- Intake Manifold Brace Replacement
- Timing Chain Crankshaft Sprocket Replacement
- Water Pump and Balance Shaft Chain Crankshaft Sprocket Replacement
- Crankshaft Balancer Replacement
- Crankshaft Front Oil Seal Replacement
- Engine Front Cover Replacement
- Camshaft Timing Chain, Sprocket, and Tensioner Replacement
- Balancer Chain Adjust Guide Replacement
- Balancer Chain Guide Replacement - Lower
- Balancer Chain Guide Replacement - Upper
- Water Pump and Balance Shaft Chain Replacement
- Water Pump and Balance Shaft Chain Tensioner Replacement
- Water Pump Cover Replacement
- Balance Shaft Sprocket Replacement - Exhaust Side
- Balance Shaft Sprocket Replacement - Intake Side
- Automatic Transmission Flex Plate Replacement
- Camshaft Cover Replacement
- Timing Chain Tensioner Replacement
- Adjustable Timing Chain Guide Replacement
- Timing Chain Guide Replacement
- Timing Chain Upper Guide Replacement
- Timing Chain Oil Nozzle Replacement
- Intake Camshaft Replacement
- Exhaust Camshaft Replacement
- Valve Rocker Arm Replacement
- Camshaft Position Intake Actuator Replacement
- Camshaft Position Exhaust Actuator Replacement
- Hydraulic Valve Lash Adjuster Replacement
- Valve Stem Oil Seal and Valve Spring Replacement
- Cylinder Head Replacement
- Engine Oil Cooler Replacement (Manual Transmission)
- Engine Oil Cooler Replacement (Automatic Transmission)
- Oil Pan Replacement (Manual Transmission)
- Oil Pan Replacement (Automatic Transmission)
- Crankshaft Rear Oil Seal Replacement (Manual Transmission)
- Crankshaft Rear Oil Seal Replacement (Automatic Transmission)
- Engine Flywheel Replacement
- Engine Replacement (Manual Transmission)
- Engine Replacement (Automatic Transmission)
- Engine Oil and Oil Filter Replacement
- Repair Instructions - Off Vehicle
- Engine Mounting to Stand
- Engine Oil Cooler Removal (LDK, LHU)
- Draining Fluids and Oil Filter Removal
- Crankshaft Balancer Removal
- Engine Flywheel Removal (Automatic Transmission)
- Engine Flywheel Removal (Manual Transmission)
- Oil Level Indicator and Tube Removal (LDK, LHU)
- Starter Removal
- Intake Manifold Removal
- Fuel Rail and Injectors Removal (LDK, LHU)
- Turbocharger Removal (LDK, LHU)
- Exhaust Manifold Removal (LDK, LHU)
- Camshaft Cover Removal (LDK, LHU)
- Engine Front Cover and Oil Pump Removal
- Camshaft Timing Chain and Tensioner Removal (LDK, LHU)
- Intake and Exhaust Camshaft, Bearing Cap, and Lash Adjuster Removal (LDK, LHU)
- Water Pump and Balance Shaft Chain and Tensioner Removal
- Water Pump Removal (LDK, LHU)
- Cylinder Head Removal (LDK, LHU)
- Oil Pan Removal (LDK, LHU)
- Piston, Connecting Rod, and Bearing Removal (LDK, LHU)
- Lower Crankcase Removal
- Crankshaft and Bearing Removal
- Engine Block Disassemble
- Engine Block Cleaning and Inspection
- Cylinder Honing
- Crankshaft Balancer Cleaning and Inspection
- Engine Flywheel Cleaning and Inspection
- Crankshaft and Bearing Cleaning and Inspection
- Piston and Connecting Rod Disassemble (LDK, LHU)
- Piston, Connecting Rod, and Bearing Cleaning and Inspection (LDK, LHU)
- Piston and Connecting Rod Assemble (LDK, LHU)
- Camshaft Cleaning and Inspection (LDK, LHU)
- Camshaft Timing Chain and Sprocket Cleaning and Inspection (LDK, LHU)
- Balance Shaft Cleaning and Inspection
- Water Pump and Balance Shaft Chain and Sprocket Cleaning and Inspection (LDK, LHU)
- Cylinder Head Disassemble (LDK, LHU)
- Cylinder Head Cleaning and Inspection (LDK, LHU)
- Valve and Seat Grinding
- Valve Measurement and Reconditioning Overview
- Valve Seat Width Measurement Procedure
- Valve Seat Roundness Measurement Procedure
- Valve Head O.D. and Chamfer Measurement Procedure
- Valve-to-Seat Concentricity Measurement Procedure
- Valve and Seat Reconditioning Procedure
- Valve Stem Height Measurement Procedure
- Cylinder Head Assemble (LDK, LHU)
- Oil Pump Disassemble
- Oil Pump Assemble
- Turbocharger Cleaning and Inspection (LDK, LHU)
- Fuel Rail and Injectors Cleaning and Inspection (LDK, LHU)
- Intake Manifold Cleaning and Inspection (LDK, LHU)
- Exhaust Manifold Cleaning and Inspection (LDK, LHU)
- Oil Pan Cleaning and Inspection (LDK, LHU)
- Service Prior to Assembly
- Engine Block Assemble
- Crankshaft and Bearing Installation
- Lower Crankcase Installation (LDK, LHU)
- Crankshaft Rear Oil Seal Installation
- Piston, Connecting Rod, and Bearing Installation (LDK, LHU)
- Cylinder Head Installation (LDK, LHU)
- Intake and Exhaust Camshaft, Bearing Cap, and Lash Adjuster Installation (LDK, LHU)
- Water Pump Installation (LDK, LHU)
- Balance Shaft to Engine Timing (LDK, LHU)
- Water Pump and Balance Shaft Chain and Tensioner Installation
- Camshaft Timing Chain, Sprocket, and Tensioner Installation (LDK, LHU)
- Crankshaft Front Oil Seal Installation (LDK, LHU)
- Engine Front Cover and Oil Pump Installation
- Oil Pan Installation (LDK, LHU)
- Engine Oil Cooler Installation (LDK, LHU)
- Engine Flywheel Installation (Automatic Transmission)
- Engine Flywheel Installation (Manual Transmission)
- Crankshaft Balancer Installation (LDK, LHU)
- Camshaft Cover Installation (LDK, LHU)
- Oil Filter with Cap and Seal Installation
- Fuel Rail and Injectors Installation (LDK, LHU)
- Intake Manifold Installation
- Oil Level Indicator and Tube Installation (LDK, LHU)
- Exhaust Manifold Installation (LDK, LHU)
- Turbocharger Installation (LDK, LHU)
- Starter Installation
- Description and Operation
- Special Tools and Equipment