Section 1 (Automatic Transaxle - AF33-5 - Removal & Installation, Service, Overhaul, Troubleshooting & Diagnosis)
WARNING: This page is about a different variant/trim than selected.
- Diagnostic Information and Procedures
- Symptoms - Automatic Transmission
- Transmission Fluid Check
- Line Pressure Check
- Transmission Adaptive Learn and Transmission Neutral Learn
- Road Test
- Torque Converter Diagnosis
- Flexplate/Torque Converter Vibration Test
- Stall Speed Test
- Engagement Delay Test
- Noise and Vibration Analysis
- Clutch Plate Diagnosis
- Engine Coolant/Water in Transmission
- Fluid Leak Diagnosis
- Case Porosity Repair
- Transmission Fluid Cooler Flushing and Flow Test
- Bushing and Mating Shaft Inspection
- Transmission Overheats
- No Forward and Reverse
- Slips in Drive or No Drive
- Slips in Reverse or No Reverse
- Engagement Time From Park or Neutral to Drive is Not Within Specifications
- Engagement Time From Park or Neutral to Reverse is Not Within Specifications
- Engine Stalls During Reverse or Drive Engagement
- Slips on Acceleration
- Harsh Feel at Light Acceleration or Deceleration Without Causing an Upshift or Downshift
- No 1-2 Upshift
- No 2-3 Upshift
- No 3-4 Upshift
- No 4-5 Upshift
- No 5-4 Downshift
- No 4-3 Downshift
- No 3-2 Downshift
- No 2-1 Downshift
- Torque Converter Clutch Stuck On or Off
- No Engine Braking in Fourth Gear
- No Engine Braking in Third Gear
- No Engine Braking in Second Gear
- No Response to Movement of Shift Lever
- Transmission Attempts to Move but Appears Locked Up
- Vibration at Idle
- Vibration While Driving
- Hum or Rattle Noise at Idle
- Whine/Growl Noise That Changes with Vehicle Speed
- Automatic Transmission Fluid Leaks
- Harsh Park or Neutral to Drive Engagement
- Harsh Park or Neutral to Reverse Engagement
- Harsh Upshift
- Harsh Shift on Coastdown
- Harsh Forced Downshift
- Repair Instructions - On Vehicle
- Transmission Fluid Replacement
- Transmission Control Lever Knob Replacement
- Automatic Transmission Control Indicator Replacement
- Transmission Control Replacement
- Transmission Control Bracket Replacement
- Shift Control Cable Replacement
- Shift Control Cable Adjustment
- Shift Control Cable Bracket Replacement
- Automatic Transmission Range Selector Lever Replacement
- Transmission Control Module Replacement
- Transmission Brace Replacement
- Transmission Mount Inspection
- Transmission Rear Mount Replacement
- Transmission Mount Replacement - Left Side
- Transmission Rear Mount Bracket Replacement
- Transmission Fluid Level Indicator Replacement
- Input Speed Sensor Replacement
- Output Speed Sensor Replacement
- Control Valve Body Cover Replacement
- Control Valve Body Replacement
- Transmission Fluid Cooler Hose/Pipe Quick-Connect Fitting Disconnection and Connection
- Transmission Fluid Cooler Pipe Connector Replacement - Radiator
- Oil Cooler Hose/Pipe Replacement
- Fluid Cooler Pipe Seal Replacement
- Front Axle Shaft Seal Replacement (Right)
- Front Axle Shaft Seal Replacement (Left)
- Transmission Replacement
- Automatic Transmission Wiring Harness Replacement
- Repair Instructions - Off Vehicle
- Torque Converter Assembly Removal
- Holding Fixture Installation
- Transmission Fluid Draining
- Input and Output Speed Sensor Removal
- Transmission Control Module Removal
- Control Valve Body Cover Removal
- Wiring Harness Removal
- Control Valve Body Assembly Removal
- Transmission Fluid Pump Removal
- Second Coast, Second Clutch Hub and Second Clutch Sprag Assembly Removal
- Torque Converter Housing Removal
- Front Differential Assembly Removal
- Fluid Filter Removal
- Transmission Fluid Baffle Removal
- Third Gear Band Apply Tube Removal
- Manual Shift Detent Lever and Park Pawl Removal
- Front Differential Transfer Drive Gear Assembly Removal
- Third Gear Band Servo Piston Pin Measurement
- 4-5 Clutch Assembly Removal
- Third Gear Band Assembly Removal
- 1-2-Reverse Carrier Gear Assembly Removal
- 3rd Gear Band Servo Piston Assembly Removal
- Case Cover and 1-2 Reverse Clutch Assembly Removal
- Forward and Direct Clutch Assembly Removal
- Rear Internal Gear and Front Carrier Removal
- Front Internal Gear and Low and Reverse Clutch Assembly Removal
- Low and Reverse Clutch Piston Removal
- Output Gear Assembly Removal
- Transmission Cooler Line Seals Removal
- Transmission Case Inspection
- Transmission Cooler Line Seals Installation
- Rotational Torque Measurement
- Front Differential Bearing Race and Selective Shim Removal
- Front Differential Bearing Race and Selective Shim Installation
- Manual Shift Shaft Seal and Bearing Removal
- Manual Shift Shaft Seal and Bearing Installation
- Front Wheel Drive Shaft Oil Seal Removal
- Front Wheel Drive Shaft Oil Seal Installation
- Front Differential Carrier Seal Removal
- Front Differential Carrier Seal Installation
- 4-5 Clutch Drum Assembly Disassemble
- 4-5 Clutch Drum Assembly Assemble
- 4-5 Clutch Piston Travel Measurement
- Output Gear Assembly Installation
- Low and Reverse Clutch Piston Installation
- Front Internal Gear and Overrun Clutch Disassemble
- Front Internal Gear Cleaning and Inspection
- Front Internal Gear and Overrun Clutch Assemble
- Front Internal Gear and Low and Reverse Clutch Installation
- Low and Reverse Clutch Piston Travel Measurement
- Rear Internal Gear and Front Carrier Installation
- Forward and Direct Clutch Assembly Disassemble
- Forward and Direct Clutch Assembly Assemble
- Direct Clutch Piston Travel Check
- Forward Clutch Piston Travel Check
- Forward and Direct Clutch Assembly Installation
- Case Cover Assembly Disassemble
- 1-2 Reverse Clutch Disassemble
- Case Cover Cleaning and Inspection
- 1-2 Reverse Clutch Assemble
- Case Cover Assembly Assemble
- 1-2-Reverse Clutch Piston Travel Measurement
- Forward and Direct Clutch End Play Measurement
- Transmission Case Cover and 1-2 Reverse Clutch Assembly Installation
- 3rd Gear Band Servo Piston Disassemble
- 3rd Gear Band Servo Piston Assemble
- 3rd Gear Band Servo Piston Installation
- 1-2-Reverse Carrier Gear Assembly Installation
- Third Gear Band Assembly Installation
- 4-5 Clutch Assembly Installation
- Front Differential Transfer Drive Gear Assembly Installation
- Manual Shift Detent Lever and Park Pawl Installation
- Third Gear Band Apply Tube Installation
- Transmission Fluid Baffle Installation
- Fluid Filter Installation
- Front Differential Assembly Cleaning and Inspection
- Front Differential Assembly Installation
- Torque Converter Housing Cleaning and Inspection
- Torque Converter Housing Installation
- Second Coast Clutch Disassemble
- 2nd Clutch Disassemble
- Transmission Fluid Pump Disassemble
- Fluid Pump Cleaning and Inspection
- Transmission Fluid Pump Assemble
- 2nd Clutch Assemble
- Second Coast Clutch Assemble
- 2nd Clutch Piston Travel Measurement
- 2nd Coast Clutch Piston Travel Measurement
- Second Coast, Second Clutch Hub and Second Clutch Sprag Disassemble
- Second Coast, Second Clutch Hub and Second Clutch Sprag Assemble
- Transmission Fluid Pump Assembly Installation
- Control Valve Body Assembly Disassemble
- Control Valve Body Disassemble - Middle
- Control Valve Body Assemble - Middle
- Control Valve Rear Body Disassemble
- Control Valve Rear Body Assemble
- No. 2 Rear Control Valve Body Disassemble
- No. 2 Rear Control Valve Body Assemble
- Control Valve Front Body Disassemble
- Control Valve Front Body Assemble
- Control Valve Body Assembly Assemble
- Control Valve Body Assembly Installation
- Wiring Harness Installation
- Control Valve Body Cover Installation
- Transmission Control Module Installation
- Input and Output Speed Sensor Installation
- Drain Plug Installation
- Holding Fixture Removal
- Torque Converter Assembly Installation
- Description and Operation
- Transmission General Information
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission General Description
- Transmission Component and System Description
- Transmission Adaptive Functions
- Transmission Oil Life Monitor
- Transmission Indicators and Messages
- Electronic Component Description
- Transmission Control Module (TCM) (75)
- Automatic Transmission Input Speed (A/T ISS) Sensor Assembly (73)
- Shift Solenoid Valves
- Line Pressure Control Solenoid Valve (SLT) (316)
- TCC Lock Up Pressure Control Solenoid Valve (SLU) (339)
- Shift Pressure Control Solenoid Valve (SLS) (340)
- Automatic Transmission Fluid Temperature (TFT) Sensor (36)
- Transmission Range (TR) Switch (75)
- Automatic Transmission Hydraulic Diagrams
- Park - Engine Running
- Reverse
- Reverse Inhibit
- Neutral - Engine Running
- Drive and Intermediate Range - First Gear
- Low Range - First Gear, Engine Braking
- Drive, Intermediate and Low Range - Second Gear
- Drive and Intermediate Range - Third Gear
- Drive Range - Fourth Gear
- Drive Range Fifth Gear - Torque Converter Clutch Released
- Drive Range Fifth Gear - Torque Converter Clutch Applied
- Drive Range - Emergency Fifth Gear
- Fluid Passages
- Special Tools