LEMON Manuals: Even more car manuals for everyone
Home >> Pontiac >> 2008 >> Torrent GXP, AWD >> Repair and Diagnosis >> External Pages >> Different variant/trim >> Section 1 (Automatic Transaxle - AF33-5 - Removal & Installation, Service, Overhaul, Troubleshooting & Diagnosis) >> Repair Instructions - Off Vehicle >> Control Valve Front Body Disassemble

Control Valve Front Body Disassemble

WARNING: This page is about a different variant/trim than selected.
    Fig 1: View Of Front Control Valve Body Spacer Plate
    GM767263Courtesy of GENERAL MOTORS CORP.
    CAUTION: Valve springs can be tightly compressed. Use care when removing retainers and plugs. Personal injury could result.
  1. Remove the gasket (322).
  2. Remove the front control valve body spacer plate (321).
  3. Remove the gasket (320).
    4. Fig 2: Identifying Valves
    GM749760Courtesy of GENERAL MOTORS CORP.
  4. Remove the ball check valve (355).
  5. Remove the fluid strainer (352).
  6. Remove the pressure relief valve (351).
  7. Remove the pressure relief valve spring (350).
  8. Remove the 2 check valves (360).
  9. Remove the 2 check valve compression springs (361).
    10. Fig 3: Exploded View Of Forward Clutch (C1) Control Valve Assembly
    GM767436Courtesy of GENERAL MOTORS CORP.
  10. Remove the sleeve/bore plug retainer (349).
  11. Remove the solenoid modulator valve bore plug (348).
  12. Remove the forward clutch (C1) control valve (354).
    13. Fig 4: Exploded View Of Neutral Relay Valve Assembly
    GM767437Courtesy of GENERAL MOTORS CORP.
  13. Remove the sleeve/bore plug retainer (349).
  14. Remove the solenoid modulator valve bore plug (348).
  15. Remove the neutral relay valve spring (357).
  16. Remove the neutral relay valve (356).
    17. Fig 5: Exploded View Of Second Coast Clutch (B1) Control Valve Assembly
    GM767438Courtesy of GENERAL MOTORS CORP.
  17. Remove the sleeve/bore plug retainer (349).
  18. Remove the solenoid modulator valve bore plug (348).
  19. Remove the second coast clutch (B1) control valve (359).
  20. Remove the second coast clutch (B1) control valve spring (358).
    21. Fig 6: Exploded View Of Solenoid Modulator Valve Assembly
    GM767439Courtesy of GENERAL MOTORS CORP.
  21. Remove the sleeve/bore plug retainer (349).
  22. Remove the solenoid modulator valve bore plug (348).
  23. Remove the solenoid modulator valve spring (347).
  24. Remove the solenoid modulator valve (346).
scientia non olet · About LEMON Manuals