Section 21 (Heating, Ventilation, And Air Conditioning)
WARNING: This page is about a different car, the 2019 Chevrolet Malibu. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Visual Identification
- Diagnostic Information and Procedures
- Handling of Refrigerant Lines and Fittings
- Symptoms - Heating, Ventilation, and Air Conditioning
- Leak Testing (R-1234yf)
- Air Conditioning (A/C) System Performance Test
- A/C Diagnostics Chart
- Heating Performance Diagnostic
- Defrosting Insufficient
- Noise Diagnosis - Blower Motor
- Air Conditioning Compressor Oil Diagnosis
- Noise Diagnosis - Air Conditioning (A/C) System
- Noise Diagnosis - HVAC Module
- Odor Diagnosis
- Repair Instructions
- Odor Correction
- Refrigerant Recovery and Recharging (R-1234yf)
- Flushing (LKN)
- Flushing (R-1234yf)
- Air Conditioning Compressor Oil Balancing
- Air Conditioning Compressor Replacement (LFV)
- Air Conditioning Compressor Replacement (LTG)
- Air Conditioning with Motor Compressor Replacement (LKN)
- Compressor Clutch Plate and Hub Assembly Removal (LFV)
- Compressor Clutch Plate and Hub Assembly Removal (LTG)
- Air Conditioning Clutch Drive Plate Adjustment
- Air Conditioning Compressor Bracket Replacement (LFV)
- Air Conditioning Compressor Bracket Replacement (LKN)
- Air Conditioning System Seal Replacement
- Air Conditioning O-Ring Seal Replacement
- Air Conditioning Compressor Hose Replacement (LFV)
- Air Conditioning Compressor Hose Replacement (LTG)
- Air Conditioning Compressor and Condenser Hose Replacement (LKN)
- Air Conditioning Evaporator Tube Replacement (LFV, LTG)
- Air Conditioning Evaporator Tube Replacement (LKN)
- Receiver and Dehydrator Replacement
- Air Conditioning Evaporator Thermal Expansion Valve Replacement
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement (LFV)
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement (LKN)
- Air Conditioning Condenser Replacement (LKN)
- Air Conditioning Condenser Replacement (LTG)
- Air Conditioning Condenser Replacement (LFV)
- Air Conditioning Condenser Bracket Replacement (LKN)
- Air Conditioning Condenser Bracket Replacement (LTG)
- Air Conditioning Condenser Bracket Replacement (LFV)
- Heater and Air Conditioning Evaporator and Blower Module Removal and Installation
- Heater and Air Conditioning Evaporator and Blower Upper Case Replacement
- Heater and Air Conditioning Evaporator and Blower Lower Case Replacement
- Heater and Air Conditioning Evaporator Case Replacement
- Air Conditioning Evaporator Lower Case Replacement
- Air Conditioning Evaporator Upper Case Replacement
- Air Conditioning Evaporator Replacement (R-1234yf)
- Air Conditioning Evaporator and Blower Module Drain Hose Replacement
- Heater Inlet Hose Replacement (LTG)
- Heater Inlet Hose Replacement (LKN)
- Heater Inlet Hose Replacement (LFV)
- Heater Outlet Hose Replacement (LFV)
- Heater Outlet Hose Replacement (LTG)
- Heater Outlet Hose Replacement (LKN)
- Heater Coolant Pump Replacement (LFV)
- Heater Coolant Pump Replacement (LKN)
- Heater Coolant Pump Replacement (LFV with MRG)
- Heater Coolant Pump Hose Replacement (Inlet)
- Heater Coolant Pump Hose Replacement (Outlet)
- Heater Coolant Pump Hose Replacement (Pump Inlet LKN)
- Heater Coolant Pump Hose Replacement (Pump Outlet LKN)
- Passenger Compartment Air Filter Replacement
- Air Inlet Housing Replacement
- Blower Motor Replacement
- Side Window Defogger Outlet Grille Replacement
- Instrument Panel Outer Air Outlet Replacement - Left Side
- Instrument Panel Center Air Outlet Replacement - Left Side
- Instrument Panel Center Air Outlet Replacement - Right Side
- Instrument Panel Outer Air Outlet Replacement - Right Side
- Instrument Panel Compartment Air Duct Replacement (K4C)
- Floor Front Air Outlet Duct Replacement - Right Side
- Floor Front Air Outlet Duct Replacement - Left Side
- Front Floor Console Rear Air Duct Replacement (Accessory AC and DC Power Control Module Cooler Duct)
- Front Floor Console Rear Air Duct Replacement (With KI6 To Outlet)
- Front Floor Console Rear Air Duct Replacement (Without KI6 To Outlet)
- Front Floor Console Rear Air Front Duct Replacement (Front Adapter)
- Floor Rear Air Outlet Duct Adapter Replacement (Left Side)
- Floor Rear Air Outlet Duct Adapter Replacement (Right Side)
- Front Floor Console Rear Air Outlet Replacement
- Instrument Panel Center Air Outlet Duct Replacement
- Windshield Defroster Outlet Duct Replacement
- Side Window Defogger Outlet Duct Replacement - Left Side
- Side Window Defogger Outlet Duct Replacement - Right Side
- Floor Rear Air Outlet Duct Replacement - Left Side
- Floor Rear Air Outlet Duct Replacement - Right Side
- Heater and Air Conditioning Remote Control Bracket Replacement
- Heater Core Replacement
- Fuel Heater Inlet Hose Replacement (LKN)
- Fuel Heater Outlet Hose Replacement (LKN)
- Auxiliary Heater Core Replacement (C32)
- Air Conditioning Evaporator Connector Hose/Tube and Compressor Hose Replacement (LKN)
- Description and Operation
- Special Tools and Equipment