Section 9 (Engine Mechanical - 2.8L (LWN) Diesel)
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic Wiring Diagrams
- Visual Identification
- Diagnostic Information and Procedures
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Engine Noise Under Load
- Engine Will Not Crank - Crankshaft Will Not Rotate
- Coolant in Combustion Chamber
- Coolant in Engine Oil
- Fuel in Engine Oil
- Compressor Air Intake Turbocharger Whine Noise
- Compressor Air Intake Turbocharger Hissing Noise
- Compressor Air Intake Turbocharger Oil Leak From Compressor Seal
- Compressor Air Intake Turbocharger Oil Leak From Turbine Seal
- Engine Compression Test
- Cylinder Leakage Test
- Oil Consumption Diagnosis
- Oil Pressure Diagnosis and Testing
- Oil Leak Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Drive Belt Chirping, Squeal, and Whine Diagnosis
- Drive Belt Rumbling and Vibration Diagnosis
- Drive Belt Falls Off and Excessive Wear Diagnosis
- Drive Belt Tensioner Diagnosis
- Repair Instructions
- Drive Belt Replacement
- Drive Belt Tensioner Replacement
- Drive Belt Idler Pulley Replacement - Left Side
- Drive Belt Idler Pulley Replacement - Right Side
- Engine Cooling Fan Bracket Replacement
- Timing Belt Front Cover Replacement
- Timing Belt Rear Cover Replacement
- Timing Belt Replacement
- Timing Belt Tensioner Replacement
- Intake Manifold Replacement
- Engine Support Fixture
- Engine Mount Inspection
- Engine Mount Replacement - Left Side
- Engine Mount Replacement - Right Side
- Engine Mount Bracket Replacement - Left Side
- Engine Lift Front Bracket Replacement
- Oil Level Indicator Tube Replacement
- Oil Filler Tube Replacement
- Engine Oil Pressure Switch Replacement
- Cylinder Head Replacement
- Cylinder Head Core Hole Plug Replacement
- Crankshaft Sprocket Replacement
- Crankshaft Position Sensor Exciter Ring Replacement
- Crankshaft Front Oil Seal Replacement
- Crankshaft Rear Oil Seal Replacement
- Balancer Replacement
- Crankshaft Balancer Replacement
- Engine Front Cover Replacement
- Camshaft Replacement
- Camshaft Timing Pulley Replacement
- Automatic Transmission Flex Plate Replacement
- Compressor Air Intake Turbocharger Replacement
- Turbocharger Oil Return Pipe Replacement
- Turbocharger Oil Feed Pipe Replacement
- Lower Oil Pan Replacement
- Upper Oil Pan Replacement
- Engine Replacement
- Oil Filter Assembly Replacement
- Engine Oil and Oil Filter Replacement
- Valve Rocker Arm Cover Replacement
- Draining Fluids and Oil Filter Removal
- Automatic Transmission Flex Plate Removal
- Oil Level Indicator and Tube Removal
- Engine Oil Cooler Removal
- Engine Cooling Fan Bracket Removal
- Crankshaft Balancer Removal
- Timing Belt Front Cover Removal
- Timing Belt Removal
- Timing Belt Tensioner Removal
- Timing Belt Rear Cover Removal
- Camshaft Timing Pulley Removal
- Fuel Injection Pump Drive Pulley Removal
- Water Pump Removal
- Exhaust Manifold and Compressor Air Intake Turbocharger Removal
- Generator Bracket Removal
- Air Conditioning Compressor Bracket Removal
- Engine Coolant Thermostat Removal
- Water Pump Inlet Pipe Removal
- Intake Manifold Removal
- Valve Rocker Arm Cover Removal
- Camshaft Removal
- Glow Plug Removal
- Cylinder Head Removal
- Fuel Pump Removal
- Crankshaft Position Sensor Removal
- Lower Oil Pan Removal
- Upper Oil Pan Removal
- Oil Pan Baffle Removal
- Balancer and Oil Pump Removal
- Engine Front Cover Removal
- Crankshaft Front Oil Seal Removal
- Crankshaft Rear Oil Seal Housing Removal
- Piston Oil Nozzle Removal
- Piston, Connecting Rod, and Bearing Removal
- Crankshaft and Bearing Removal
- Engine Block Cleaning and Inspection
- Cylinder Honing
- Upper Oil Pan Cleaning and Inspection
- Camshaft Cleaning and Inspection
- Crankshaft and Bearing Cleaning and Inspection
- Engine Flywheel Cleaning and Inspection
- Piston and Connecting Rod Disassemble
- Piston, Connecting Rod, and Bearing Cleaning and Inspection
- Piston and Connecting Rod Assemble
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Valve and Seat Grinding
- Cylinder Head Assemble
- Valve Rocker Arm and Lifter Cleaning and Inspection
- Balancer Shaft Cleaning and Inspection
- Piston Oil Nozzle Cleaning and Inspection
- Oil Pump Cleaning and Inspection
- Engine Front Cover Cleaning and Inspection
- Lower Oil Pan Cleaning and Inspection
- Valve Rocker Arm Cover Cleaning and Inspection
- Timing Belt Pulley Cleaning and Inspection
- Intake Manifold Disassemble
- Intake Manifold Cleaning and Inspection
- Intake Manifold Assemble
- Engine Oil Cooler Cleaning and Inspection
- Engine Coolant Thermostat Cleaning and Inspection
- Exhaust Manifold Cleaning and Inspection
- Fuel Pump Cleaning and Inspection
- Compressor Air Intake Turbocharger Disassemble
- Compressor Air Intake Turbocharger Cleaning and Inspection
- Compressor Air Intake Turbocharger Assemble
- Water Pump Cleaning and Inspection
- Exhaust Gas Recirculation Valve Cooler Cleaning and Inspection
- Thread Repair
- Fuel Line Torquing
- Service Prior to Assembly
- Crankshaft and Bearing Installation
- Piston, Connecting Rod, and Bearing Installation
- Piston Oil Nozzle Installation
- Crankshaft Front Oil Seal Installation
- Engine Front Cover Installation
- Crankshaft Rear Oil Seal Housing Installation
- Balancer and Oil Pump Installation
- Oil Pan Baffle Installation
- Upper Oil Pan Installation
- Lower Oil Pan Installation
- Crankshaft Position Sensor Installation
- Fuel Pump Installation
- Cylinder Head Gasket Selection
- Cylinder Head Installation
- Glow Plug Installation
- Camshaft Installation
- Valve Rocker Arm Cover Installation
- Intake Manifold Installation
- Air Conditioning Compressor Bracket Installation
- Water Pump Inlet Pipe Installation
- Generator Bracket Installation
- Exhaust Manifold and Compressor Air Intake Turbocharger Installation
- Water Pump Installation
- Fuel Injection Pump Drive Pulley Installation
- Camshaft Timing Pulley Installation
- Timing Belt Rear Cover Installation
- Timing Belt Tensioner Installation
- Timing Belt Installation
- Timing Belt Front Cover Installation
- Crankshaft Balancer Installation
- Engine Cooling Fan Bracket Installation
- Engine Oil Cooler Installation
- Oil Level Indicator and Tube Installation
- Automatic Transmission Flex Plate Installation
- Engine Prelubing
- Description and Operation
- Special Tools and Equipment