Section 10 (Engine Mechanical - 4.3L (LV1))
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic Wiring Diagrams
- Visual Identification
- Diagnostic Information and Procedures
- DTC P06DA-P06DD
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- Symptoms - Engine Mechanical
- Base Engine Misfire without Internal Engine Noises
- Base Engine Misfire with Abnormal Internal Lower Engine Noises
- Base Engine Misfire with Abnormal Valve Train Noise
- Base Engine Misfire with Coolant Consumption
- Base Engine Misfire with Excessive Oil Consumption
- Engine Noise on Start-Up, but Only Lasting a Few Seconds
- Upper Engine Noise, Regardless of Engine Speed
- Lower Engine Noise, Regardless of Engine Speed
- Engine Noise Under Load
- Engine Will Not Crank - Crankshaft Will Not Rotate
- Coolant in Combustion Chamber
- Coolant in Engine Oil
- Engine Compression Test
- Cylinder Leakage Test
- Oil Consumption Diagnosis
- Oil Pressure Diagnosis and Testing
- Camshaft Position Actuator and Solenoid Valve Diagnosis and Testing
- Engine Oil Level Sensor Diagnosis
- Oil Leak Diagnosis
- Crankcase Ventilation System Inspection/Diagnosis
- Drive Belt Chirping, Squeal, and Whine Diagnosis
- Drive Belt Rumbling and Vibration Diagnosis
- Drive Belt Falls Off and Excessive Wear Diagnosis
- Drive Belt Tensioner Diagnosis
- DTC P06DA-P06DD
- Repair Instructions
- Vacuum Pump Belt Replacement
- Drive Belt Replacement - Accessory
- Air Conditioning Compressor Belt Replacement
- Drive Belt Idler Pulley Replacement
- Drive Belt Tensioner Replacement - Accessory
- Engine Mount Replacement - Left Side
- Engine Mount Replacement - Right Side
- Positive Crankcase Ventilation Hose/Pipe/Tube Replacement (Left Side)
- Positive Crankcase Ventilation Hose/Pipe/Tube Replacement (Right Side)
- Positive Crankcase Ventilation Valve Replacement
- Oil Filler Tube Replacement
- Intake Manifold Replacement
- Engine Block Valley Cover Replacement
- Valve Rocker Arm Cover Replacement - Left Side
- Valve Rocker Arm Cover Replacement - Right Side
- Valve Rocker Arm and Push Rod Replacement
- Valve Stem Oil Seal and Valve Spring Replacement
- Oil Level Indicator Tube Replacement (Upper)
- Oil Level Indicator Tube Replacement (Lower)
- Cylinder Head Replacement - Left Side
- Cylinder Head Replacement - Right Side
- Valve Lifter Follower Guide Replacement
- Valve Lifter Replacement
- Balancer Shaft Replacement
- Crankshaft Balancer Replacement
- Crankshaft Front Oil Seal Replacement
- Engine Front Cover Replacement
- Oil Pump Replacement
- Oil Filter Center Tube Replacement
- Camshaft Position Actuator Solenoid Valve Replacement
- Crankshaft Rear Oil Seal Replacement
- Crankshaft Rear Oil Seal Housing Replacement
- Oil Pan Replacement
- Engine Oil Level Indicator Switch Replacement
- Balance Chain Replacement
- Balance Shaft Sprocket Replacement
- Timing Chain, Crankshaft Sprocket, Camshaft Position Actuator, and Solenoid Valve Replacement
- Camshaft Replacement
- Automatic Transmission Flex Plate Replacement
- Engine Replacement
- Engine Oil and Oil Filter Replacement
- Draining Fluids and Oil Filter Removal
- Crankshaft Balancer Removal
- Automatic Transmission Flex Plate Removal
- Exhaust Manifold Removal - Left Side
- Exhaust Manifold Removal - Right Side
- Oil Level Indicator and Tube Removal
- Engine Coolant Manifold Removal
- Throttle Body Assembly Removal
- Intake Manifold Removal
- Fuel Pump Insulator and Fuel Feed Pipes Removal
- Fuel Rail and Injectors Removal
- Fuel Pump Removal
- Valve Rocker Arm Cover Removal - Left Side
- Valve Rocker Arm Cover Removal - Right Side
- Valve Rocker Arm and Push Rod Removal
- Cylinder Head Removal - Left Side
- Cylinder Head Removal - Right Side
- Oil Pan Removal
- Crankshaft Front Oil Seal Removal
- Engine Front Cover Removal
- Crankshaft Rear Oil Seal Removal
- Crankshaft Rear Oil Seal Housing Removal
- Oil Pump Removal
- Piston, Connecting Rod, and Bearing Removal
- Balancer Shaft and Timing Chain Assembly Removal
- Engine Block Valley Cover Removal
- Valve Lifter Follower Guide Removal
- Valve Lifter Removal
- Camshaft Removal
- Crankshaft and Bearing Removal
- Engine Block Plug Removal
- Engine Block Cleaning and Inspection
- Crankshaft and Bearing Cleaning and Inspection
- Crankshaft Balancer Cleaning and Inspection
- Automatic Transmission Flex Plate Cleaning and Inspection
- Piston and Connecting Rod Disassemble
- Piston, Connecting Rod, and Bearing Cleaning and Inspection
- Piston and Connecting Rod Assemble
- Camshaft Bearing Removal
- Camshaft and Bearings Cleaning and Inspection
- Camshaft Bearing Installation
- Camshaft Timing Chain and Sprocket Cleaning and Inspection
- Camshaft Position Actuator Cleaning and Inspection
- Camshaft Position Actuator Magnet Cleaning and Inspection
- Camshaft Position Actuator Solenoid Valve Inspection
- Valve Rocker Arm and Push Rod Cleaning and Inspection
- Valve Lifter and Guide Cleaning and Inspection
- Cylinder Head Disassemble
- Cylinder Head Cleaning and Inspection
- Valve Guide Reaming, and Valve and Seat Grinding
- Cylinder Head Assemble
- Oil Pump Cleaning and Inspection
- Engine Front Cover Cleaning and Inspection
- Crankshaft Rear Oil Seal Housing Cleaning and Inspection
- Engine Block Valley Cover Cleaning and Inspection
- Valve Rocker Arm Cover Cleaning and Inspection
- Oil Pan Disassemble
- Oil Pan Cleaning and Inspection
- Oil Pan Assemble
- Intake Manifold Cleaning and Inspection
- Exhaust Manifold Cleaning and Inspection
- Engine Coolant Manifold Disassemble
- Engine Coolant Manifold Cleaning and Inspection
- Engine Coolant Manifold Assemble
- Fuel Rail and Injectors Cleaning and Inspection
- Thread Repair
- Service Prior to Assembly
- Engine Block Plug Installation
- Crankshaft and Bearing Installation
- Piston, Connecting Rod, and Bearing Installation
- Camshaft Installation
- Valve Lifter Installation
- Valve Lifter Follower Guide Installation
- Engine Block Valley Cover Installation
- Balancer Shaft and Timing Chain Assembly Installation
- Oil Pump Installation
- Crankshaft Rear Oil Seal Housing Installation
- Crankshaft Rear Oil Seal Installation
- Engine Front Cover Installation
- Crankshaft Front Oil Seal Installation
- Oil Pan Installation
- Oil Filter Installation
- Cylinder Head Installation - Left Side
- Cylinder Head Installation - Right Side
- Valve Rocker Arm and Push Rod Installation
- Valve Rocker Arm Cover Installation - Left Side
- Valve Rocker Arm Cover Installation - Right Side
- Fuel Pump Installation
- Fuel Rail and Injectors Installation
- Fuel Pump Insulator and Fuel Feed Pipes Installation
- Intake Manifold Installation
- Throttle Body Assembly Installation
- Engine Coolant Manifold Installation
- Oil Level Indicator and Tube Installation
- Exhaust Manifold Installation - Left Side
- Exhaust Manifold Installation - Right Side
- Automatic Transmission Flex Plate Installation
- Crankshaft Balancer Installation
- Engine Prelubing
- Description and Operation
- Special Tools and Equipment