Section 12 (Body Equipment - Repair (F56) -- Cooper, F56)
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2019 MINI Cooper, 2018 MINI Cooper, 2017 MINI Cooper, 2016 MINI Cooper, and 2015 MINI Cooper. However, it is still accessible from the selected car via links, so may be relevant.
- Safety And General Information
- (00 Safety information for working on vehicles with automatic engine start-stop function (MSA))
- (Safety at work)
- 51 00... Safety instructions for working on vehicles with airbag systems
- Information on vehicle protection
- Notes on component bonding with adhesive tape
- Notes
- Repair Notes For Bonded Seals
- Handling Rubber Seal Profiles
- REPAIR PART 1 OF 3 - Clean faulty areas
- REPAIR PART 2 OF 3 - Apply adhesive
- REPAIR PART 3 OF 3 - Press in rubber seal
- REPLACEMENT PART 1 OF 6 - Peeling off the faulty rubber seal
- REPLACEMENT PART 2 OF 6 - Clean bonding surface
- REPLACEMENT PART 3 OF 6 - Detach protective film of the bonding surface
- REPLACEMENT PART 4 OF 6 - Apply rubber seal
- REPLACEMENT PART 5 OF 6 - Establish sealing joint
- REPLACEMENT PART 6 OF 6 - Press gasket
- Checking The Rubber Seal
- Notes on film bonding
- Notes on installation of rubber window seals
- Touching up paintwork damage
- Overview of consumables
- 41 00... Replace bolts
- 41 00... Replacing blind rivets
- Bumper, Front
- General notes for labelling with adhesive films
- 51 11... Installing/replacing license plate (without number plate baseplate)
- 51 11 Removing and installing/replacing the air inlet frame for the left or right brake ventilation duct (Cooper S)
- 51 11... Removing and installing/replacing ornamental grille on bumper cover front left or right (Cooper JCW)
- 51 11.. Removing and installing/replacing mounting for fog light on front left or right (Cooper JCW)
- 51 11 Removing and mounting/exchanging side cover of front bumper (Cooper S and JCW)
- 51 11 050 Removing and installing/replacing support for front bumper
- 51 11 060 Removing and installing/replacing support for front lower bumper panel
- 51 11 152 Remove and install/replace the center spoiler on bumper panel (Cooper & Cooper S)
- 51 11 152 Remove and install/replace the center spoiler on bumper panel (Cooper JCW)
- 51 11 156 Removing and installing front bumper panel
- 51 11 157 Replacing bumper panel, front (Cooper S)
- 51 11 157 Replacing bumper panel, front (Cooper JCW)
- 51 11 158 Replacing base plate for number/license plate
- 51 11 180 Removing and installing/replacing ornamental grille in bumper panel (Cooper and Cooper S)
- 51 11 180 Removing and installing/replacing ornamental grille in bumper panel (Cooper JCW)
- 51 11 300 Removing and installing/replacing center trim (Cooper JCW)
- 51 11 760 Remove and install/replace deformation element for front left bumper
- 51 11 761 Remove and install/replace deformation element for front right bumper
- 51 11 780 Replacing the front deformation element on the bottom left
- 51 11 781 Replacing the front deformation element on the bottom right
- Bumper, Rear
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- 51 12 070 Replacing the center spoiler on rear bumper panel
- 51 12 090 Removing and installing/replacing ornamental grille in bumper trim (Cooper S)
- 51 12 090 Removing and installing/replacing side ornamental grille in bumper panel (Cooper JCW)
- 51 12 156 Removing and installing rear bumper panel
- 51 12... Removing and installing/replacing insert in bumper cover (JCW)
- 51 12 828 Removing and installing/replacing guide for bumper, rear left or right
- Exterior Trim / Covers
- 51 13 000 Removing and installing/replacing front grille center section (Cooper & Cooper S)
- 51 13 000 Remove and install/replace front ornamental grille center section (Cooper JCW)
- 51 13 005 Removing and installing/replacing ornamental grille frame (Cooper & Cooper S)
- 51 13 003 Remove and install/replace front ornamental grille frame (Cooper JCW)
- 51 13 015 Removing and installing/replacing trim ring for left or right headlight (Cooper JCW)
- 51 13 022 Removing and installing/replacing front compartment lid air duct (Cooper S & Cooper JCW)
- 51 13 085 Removing and installing/replacing trim strip on engine compartment lid (cowl panel)
- 51 13 091 Removing and installing/replacing front side panel trim strip, left or right
- 51 13 102 Removing and installing/replacing trim on front left or right wheel arch
- 51 13 105 Removing and installing/replacing trim on rear left or right wheel arch
- 51 13 123 Remove and fit/replace left cowl panel cover
- 51 13 124 Remove and fit/replace right cowl panel cover
- 51 13 301 Removing and installing/replacing left or right roof trim strip
- 51 13 305 Removing and installing/replacing left or right roof railing
- 51 13 375 Removing and installing/replacing cover on left or right rear roof pillar (C-pillar)
- 51 13 402 Removing and installing/replacing the tailgate handle strip
- 51 13 425 Removing and installing/replacing cover on left or right rear light
- Emblems / Badges
- Interior Trim / Accessories
- 51 16... Calibrating the compass on the inside mirror
- 51 16 000 Removing and installing/replacing the left or right exterior mirror on the front door
- 51 16 026 Replacing mirror glass
- 51 16 041 Removing and installing/replacing protective cap on left or right exterior mirror
- 51 16 063 Removing and installing/replacing interior mirror (as of 07/2011)
- 51 16 063 Removing and installing/replacing interior mirror (overview)
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 085 Removing and installing/replacing sun visor and counter support on driver's side (side)
- 51 16 165 Removing and installing/replacing complete center console
- 51 16 204 Removing and installing/replacing rear cup holder
- 51 16 206 Removing and installing/replacing center armrest
- 51 16 365 Removing and installing/replacing glove box cover
- 51 16 366 Removing and installing/replacing right glove box with housing
- 51 16 383 Removing and installing/replacing damper for glove box
- 51 16 480 Removing and installing or replacing front grab handle
- 51 45 460 Removing and installing/replacing upper instrument panel storage compartment
- Fuel Filler Flap, Cover Bowl
- Front Door Locks, Handles, Fittings
- 51 21 003 Replacing front left or right lock striker
- 51 21 004 Adjusting front left or right lock striker
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 125 Removing and installing/replacing support for left or right outer door handle with lock barrel
- 51 21 125 Removing and installing/replacing support for left or right outer door handle without lock barrel
- 51 21 140 Removing and installing/replacing complete lock barrel in left or right front door
- 51 21 170 Removing and installing/replacing the outer door handle of front door on the left or right
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 233 Removing and installing/replacing Bowden cable for outer door handle on left or right front door
- 51 21 235 Remove and install/replace Bowden cable for inner door opener on left or right front door
- 51 21 280 Remove and install/replace door stop of the front left or front right door
- 51 21 300 Removing and installing/replacing weather strip on outside of front door
- 51 21 330 Removing and installing/replacing the weather strip on the inside of the front door
- 51 21... Removing window channel strip with special tools
- 51 21 370 Removing and installing/replacing the cover on the bottom left or right of the front door
- Hood Latch, Locks
- 51 23... Adjusting/replacing bump stops
- 51 23... Removing/installing ball sockets with clip
- 51 23 004 Adjusting engine compartment lid catch
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 131 Removing and installing/replacing striker on engine compartment lid
- 51 23 211 Removing and installing/replacing cable for front engine compartment locks (in engine compartment)
- 51 23 212 Removing and installing/replacing cable for engine compartment lock, front (in passenger compartment)
- 51 23 265 Removing and installing/replacing left or right gas pressure spring for engine compartment lid
- 51 23 400 Removing and installing/replacing left or right actuator (active pedestrian protection)
- Tailgate Latch, Locks
- 51 24 004 Adjusting rear lid lock
- 51 24 105 Removing and installing/replacing rear lid lock
- 51 24 130 Removing and installing/replacing striker for tailgate lock
- 51 24 146 Removing and installing/replacing button for rear lid actuation
- 51 24 300 Removing and installing or replacing left or right gas pressure spring for tailgate
- Windscreen And Rear Window
- General procedure for the disassembly and installation of bonded window glass
- 51 31 015 Repairing damage to windscreen caused by stone chips (clear and tinted laminated safety glass)
- Materials for bonding window
- Notes on window bonding repair kit
- Overview, rain sensor (additional work when replacing the windshield/sensor replacement)
- Overview of additional work for the removal and installation or replacement of electronic components in the body area/windshield
- 51 31... Remove windshield with "Roll Out 2000"
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31... Window glass removal with wire pull handle
- Notes for bonding sound insulation (SI), doors
- 51 31 011 Replacing windscreen
- 51 31 021 Removing and installing/replacing rubber frame for windscreen (top)
- 51 31 045 Removing and installing/replacing trim for left or right A-pillar
- 51 31 200 Removing and installing/replacing rear window
- 51 31 284 Removing and installing/replacing lower cover on rear window
- Side Windows
- Power Window Regulator
- Hinged Side Window
- Front Door Interior Trim / Panels
- Interior Side Trim Panels
- 51 43 002 Removing and installing (replacing) rear left or right side trim panel
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- 51 43 148 Removing and installing or replacing trim panel on left or right door post (top)
- 51 43 201 Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- 51 43 251 Removing and installing or replacing trim panel for left or right rear roof pillar (C-pillar)
- Headlining
- Trim Panels, Dashboard / Instrument Panel
- 51 45... Removing and installing/replacing side panel on dashboard on left or right
- 51 45... Removing and installing (replacing) side center console trim panel
- 51 45 030 Removing and installing instrument panel trim
- 51 45 031 Replacing instrument panel trim
- 51 45 075 Removing and installing/replacing support for instrument panel (Version 1)
- 51 45 075 Removing and installing/replacing support for instrument panel (Version 2)
- 51 45 080 Replacing decorative strip of right storage compartment
- 51 45 106 Removing and installing (replacing) function support on instrument panel trim
- 51 45 180 Removing and installing/replacing lower left instrument panel trim
- 51 45 195 Removing and installing/replacing lower right instrument panel trim
- 51 45 370 Removing and installing (replacing) left decorative strip on dashboard
- 51 45 380 Removing and installing (replacing) right decorative strip on dashboard
- 51 45 435 Removing and installing/replacing cover for instruments
- 51 45 460 Removing and installing/replacing upper instrument panel storage compartment
- Trim Panels, Rear Interior
- Floor/Luggage Compartment/Engine Compartment Trim Panels, Floor Mats
- 51 47 000 Removing and installing/replacing front left or right door sill cover strip
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch panel
- 51 47 312 Replacing footrest for front vehicle interior
- 51 47 314 Removing and installing/replacing carpet for passenger compartment
- 51 47 490 Removing and installing/replacing underbody protection (front)
- 51 47 491 Removing refitting/replacing rear engine undercover
- 51 75 001 Removing and installing/replacing left or right underbody cover
- Sound Insulation
- Trim Panel, Rear Lid / Window Frame
- Exterior Body Trim
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing the rear left or right wheel arch cover
- 51 71... Remove and install/replace left or right lower front brake air duct (Cooper JCW)
- 51 71 096 Removing and installing/replacing the automatic air flap control
- 51 71 360 Remove and install/replace sealing for tailgate
- 51 71 412 Removing and installing/replacing rear spoiler (Cooper & Cooper S)
- 51 71 412 Removing and installing/replacing rear spoiler (Cooper JCW)
- 51 71 418 Replacing cover on trim panel for cover on side member, left or right
- 51 71 447 Detaching and attaching/replacing trim panel for left or right side sill
- Seals / Door Edge Protection
- Underbody Panels
- Roof Frame Seal