Section 19 (Engine Controls And Fuel - 1.6L (LH7) Diesel - Diagnostic Information And Procedures (P040B - P204D))
WARNING: This page is about a different variant/trim than selected.
- Diagnostic Information And Procedures
- DTC P040B, P040C, P040D, P040E, P041B, P041C, P041D, Or P041E: Exhaust Gas Recirculation (EGR) Temperature Sensor 1-2
- Diagnostic Instructions
- DTC Descriptors
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0506 Or P0507: Idle Speed Low/High
- DTC P053A, P053B, Or P053C: Positive Crankcase Ventilation Heater Control Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0545, P0546, P2032, P2033, P242C Or P242D: Exhaust Gas Temperature Sensor Circuit Voltages
- DTC P054E Or P054F: Idle Control - Fuel Quantity
- DTC P057B, P057C, P057D, Or P057E: Brake Pedal Position Sensor
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0601, P0602, P0603, P0604, P0606, P062B, P062F, P0630, P16F3 Or P262B: Control Module/VIN Not Programmed Or Mismatched - Engine Control Module (ECM)
- DTC P0627, P0628, Or P0629: Fuel Pump Enable Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P062D Or P062E: Control Module Fuel Injector
- DTC P0641, P0651, P0697 Or P06A3: 5V Reference 1-4 Circuit
- DTC P0650, P263A Or P263B: Malfunction Indicator Lamp (MIL) Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0658 Or P0659: Actuator High Control Circuit Group 1 Low/High Voltage
- DTC P066A, P066B, P066C, P066D, P066E, P066F, P0671, P0672, P0673, P0674, P067A Or P067B: Cylinder 1-4 Glow Plug Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0685, P0686, P0687, P0689, P0690 Or P1682: Engine Controls Ignition Relay/Ignition 1 Switch Circuit 2
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC C1201, P1000, P1001, P1003, P1008, P1009, P100A, P100E, P103D, P103E, P10B6-P10B9, P10BF, P10C6, P10C7, P10C8, P10F5, P1100, P1103, P117A, P11FF, P1200, P128C, P128D, P128E, P128F, P129E, P12A8, P130F, P135C, P135D, P135E, P135F, P1436, P143A, P143B, P1472, P14A0, P14B6, P14BD, P14CD, P14CE, P14D4, P14D5, P14D6, P150C, P151A, P151D, P153C, P153D, P155D, P1591, P15E2, P15F2, P15F9, P15FA, P15FB, P165C, P167F, P16E8, P16FF, P175F, P1761, P1762, P1775, P179B, P189C, P2544, P308D, P30B4, P30B5, P30BC, P30BD, P30D5, P30DE, P3168, P3169 Or P316B: Message Counter Incorrect
- DTC P1004, P119D, P119E, P119F, P11BE, P11BF, P11C0, P11C7, P11C8, P11D0, P11D1, P11D2, P11D5, P11D8, P11D9, P11DA, P11DC, P11FC, P11FD, P11FE, P22A0, P22A1, P22A3, P22A4, P22A5, P22A6, P22A7, P22A8, P22A9 Or P22FE: NOx Sensor 2
- DTC P1005: Fuel Pump Driver Control Module Enable Too Many Resets
- DTC P1007 Or P129D: Fuel Pump Driver Control Module Ignition On/Start Switch Circuit Voltage
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P1015, P1016, P1017, P1018, P1019 Or P101A: Reductant Control Module Sensor
- DTC P1029, P102A, Or P102B: Fuel Pump Phase U-V-W Circuits
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P103F Or P1040: Reductant Pump Driver High Temperature/Reductant Pump Control Circuit Shorted
- DTC P1048, P1049, P2047, P2048, Or P2049: Reductant Injector Control Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTCs
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P1050: Reductant Level Sensor Invalid Range
- DTC P1051 Or P1052: Reductant Heater 1-2 Driver High Temperature
- DTC P105A: Reductant Pump Low Speed
- DTC P1089: Fuel Rail Pressure Performance During Deceleration Fuel Cut-Off
- DTC P10D1: Reductant Injector Temperature - Exhaust Gas Temperature Not Plausible
- DTC P10D5: Charge Air Cooler Temperature Sensor 2 Performance
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P10D6, P10D7, P10D8: Charge Air Cooler Temperature Sensor 2 Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P111E: Engine Coolant Temperature Sensor Not Plausible
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P113B, P113C, Or P113D: Exhaust Gas Temperature Sensor 1, 2, 3
- Diagnostic Instructions
- DTC Descriptors
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P115E, P115F, P1160, P116A, P116B, P116C, P116D, P116E, P116F, P1192, P1193, P1194, P119A, P119B, P119C, P11C5, P11C6, P11CC, P11D3, P11DB, P2202, P2203, P2205, P2206, P2207, P2208, P2209, P2210, Or P2211: NOx Sensor 1
- DTC P1176 Or P1177: Fuel Pump Driver Control Module 5V Reference 1-2 Circuit
- DTC P1178 Or P1179: Fuel Pump Driver Control Module Sensor 1-2 Internal Supply Circuit
- DTC P118B: Particulate Matter Sensor Temperature Not Plausible
- DTC P118E, P118F Or P1196: Exhaust Gas Temperature Sensor 1, 2, 3 Performance - Engine Running
- DTC P122D: Intake Air Flow Valve Position Sensor Exceeded Learning Limit
- DTC P1248, P1249, P124A, Or P124B: Cylinder 1-4 Injector High Control Circuit Shorted To Control Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P1255: Fuel Pump Control Module Driver High Temperature
- DTC P127C Or P127D: Fuel Rail Pressure Sensor 2 Circuit Low/High Voltage
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P129F: Fuel Pump Driver Control Module Fuel Pump Speed Signal Incorrect
- DTC P12A6: Fuel Pump Driver Control Module Enable Circuit Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P1307-P130A: Cylinder 1-4 Glow Plug Resistance
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P140B Or P140C: Exhaust Gas Recirculation (EGR) Slow Response - Increasing/Decreasing Flow
- DTC P1424: Exhaust Gas Recirculation (EGR) Motor Overtemperature
- DTC P1428 Or P142A: EGR Temperature Sensor 1-2 - Intake Air Temperature 2 Not Plausible
- Diagnostic Instructions
- DTC Descriptors
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P142B, P142C, P142D, P142E, P142F, Or P1435: Particulate Matter Sensor Control Module Temperature
- DTC P142B, P142C, P142D, P142E, P142F, P1435 Or P1436: Particulate Matter Sensor Control Module Temperature
- DTC P1436: Particulate Matter Sensor Control Module Temperature Signal Message Counter Incorrect
- DTC P144E Or P144F: Closed Loop Diesel Particulate Filter (DPF) Regeneration Control At Limit - Stage 2 Low/High Temperature
- DTC P1474, P1475, P1476, P1477, P1478, P1479, P147B Or P1488: Particulate Matter Sensor
- DTC P157A: Sensor Supply Voltage Relay Feedback Circuit High Voltage
- DTC P161E: Glow Plug Supply Voltage Circuit
- DTC P163A: Control Module Fuel Pressure Regulator 1 Control System Circuitry Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P163B: Control Module Fuel Pressure Regulator 2 Control System Circuitry Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P02E8, P02E9, P16A0, P16A1, Or P16A2: Sensor Communication Circuit 1/Intake Air Flow Valve Position Sensor Circuit Voltage
- DTC P16A7, P16AF Or P16B3: Engine Controls Ignition Relay Feedback Circuit 2
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P16D7, P16D8, Or P16D9: Sensor Supply Voltage Relay Control Circuit
- DTC P2002: Diesel Particulate Filter (DPF) Low Efficiency
- DTC P2006 Or P200A: Intake Manifold Runner Control Valve
- DTC P2008, P2009, Or P2010: Intake Manifold Runner Control Valve Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P200C: Diesel Particulate Filter (DPF) High Temperature
- DTC P2015, P2016, Or P2017: Intake Manifold Runner Control Valve Position Sensor
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P203C Or P203D: Reductant Level Sensor Circuit Low/High Voltage
- DTC P204B: Reductant Pressure Sensor Performance
- DTC P204C Or P204D: Reductant Pressure Sensor Circuit Low/High Voltage
- DTC P040B, P040C, P040D, P040E, P041B, P041C, P041D, Or P041E: Exhaust Gas Recirculation (EGR) Temperature Sensor 1-2