Section 1745 (Automatic Transaxle - AF33-5 (Removal & Installation, Service & Overhaul))
WARNING: This page is about a different car, the 2003 Saturn Vue. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Transmission Fluid Temperature (TFT) Sensor Specifications
- Fastener Tightening Specifications
- Sealers, Adhesives, and Lubricants
- Transmission General Specifications
- Fluid Capacity Specifications
- Range Reference
- Shift Solenoid Valve State and Gear Ratio
- Shift Speed
- Transmission Range Switch Logic
- Line Pressure
- Component Resistance
- Shim Size Specifications
- Transmission Clearance Specifications
- Third Gear Band Servo Piston Pin Selection
- Race and Bearing Specifications
- Schematic and Routing Diagrams
- Component Locator
- Repair Instructions
- Transmission Fluid Replacement
- Shift Control Replacement
- Transmission Shift Control Bracket Replacement
- Shift Control Knob Replacement
- Shift Cable Replacement
- Shift Cable Adjustment
- Shift Control Cable Bracket Assembly Replacement
- Shift Indicator Replacement
- Park Lock Cable Replacement
- Transaxle Range Switch Lever Assembly Replacement
- Park Lock Cable Adjustment
- Transmission Control Module (TCM) Replacement
- Filler Tube and Seal Replacement
- Park/Neutral Position Switch Replacement
- Park/Neutral Position Switch Adjustment
- Input Shaft Speed Sensor Replacement
- Output Shaft Speed Sensor Replacement
- Control Valve Body Cover Replacement
- Control Valve Body Replacement
- Oil Cooler Line Replacement
- Oil Cooler Pipe Seals Replacement
- Automatic Transmission Oil Cooler Flushing
- Transmission Oil Cooler Replacement
- Drive Axle Shaft Seal Replacement (Right)
- Drive Axle Shaft Seal Replacement (Left)
- Transmission Mount Inspection
- Transmission Mount Replacement - Front
- Transmission Mount Replacement - Rear
- Transmission Mount Bracket Replacement - Rear
- Transmission Mount Replacement - Side
- Transmission Replacement
- Torque Converter Assembly Removal
- Holding Fixture Installation
- Draining Transmission Fluid
- Output Speed Sensor Removal
- Input Speed Sensor Removal
- Park/Neutral Position Switch Removal
- Control Valve Body Cover Removal
- Wiring Harness Removal
- Control Valve Body Assembly Removal
- Fluid Pump Assembly Removal
- Second Coast, Second Clutch Hub and Second Clutch Sprag Assembly Removal
- Torque Converter Housing Removal
- Front Differential Assembly Removal
- Fluid Filter Removal
- Transmission Fluid Baffle Removal
- Third Gear Band Apply Tube Removal
- Manual Shift Detent Lever and Park Pawl Removal
- Front Differential Transfer Drive Gear Assembly Removal
- Third Gear Band Servo Piston Pin Measurement
- 4-5 Clutch Assembly Removal
- Third Gear Band Assembly Removal
- 1-2 Reverse Carrier Gear Assembly Removal
- Third Gear Band Servo Piston Assembly Removal
- Case Cover and 1-2 Reverse Clutch Assembly Removal
- Forward and Direct Clutch Assembly Removal
- Rear Internal Gear and Front Carrier Removal
- Front Internal Gear and Low and Reverse Clutch Assembly Removal
- Low and Reverse Clutch Piston Removal
- Output Gear Assembly Removal
- Transmission Cooler Line Seals Removal
- Transmission Case Inspection
- Transmission Cooler Line Seals Installation
- Rotational Torque Measurement Procedure (AWD)
- Rotational Torque Measurement Procedure (FWD)
- Front Differential Bearing Race and Selective Shim Removal
- Front Differential Bearing Race and Selective Shim Installation
- Manual Shift Shaft Seal and Bearing Removal
- Manual Shift Shaft Seal and Bearing Installation
- Front Wheel Drive Shaft Oil Seal Removal
- Front Wheel Drive Shaft Oil Seal Installation
- Front Differential Carrier Seal Removal
- Front Differential Carrier Seal Installation
- 4-5 Clutch Drum Assembly Disassemble
- 4-5 Clutch Drum Assembly Assemble
- 4-5 Clutch Piston Travel Measurement
- Output Gear Assembly Installation
- Low and Reverse Clutch Piston Installation
- Front Internal Gear and Low Clutch Sprag Disassemble
- Front Internal Gear Cleaning and Inspection
- Front Internal Gear and Low Clutch Sprag Assemble
- Front Internal Gear and Low and Reverse Clutch Installation
- Low and Reverse Clutch Piston Travel Measurement
- Rear Internal Gear Assembly Disassemble
- Rear Internal Gear Assembly Assemble
- Front Carrier and Sun Gear Installation
- Rear Internal Gear Assembly Installation
- Rear Sun Gear and Hub Assembly Installation
- Forward and Direct Clutch Assembly Disassemble
- Forward and Direct Clutch Assembly Assemble
- Direct Clutch Piston Travel Check
- Forward Clutch Piston Travel Check
- Forward and Direct Clutch Assembly Installation
- Transmission Case Cover Assembly Disassemble
- 1-2 Reverse Clutch Disassemble
- Transmission Case Cover Cleaning and Inspection
- 1-2 Reverse Clutch Assemble
- Transmission Case Cover Assembly Assemble
- 1-2 Reverse Clutch Piston Travel Measurement
- Forward and Direct Clutch End Play Measurement
- Transmission Case Cover and 1-2 Reverse Clutch Assembly Installation
- Third Gear Band Servo Piston Disassemble
- Third Gear Band Servo Piston Assemble
- Third Gear Band Servo Piston Installation
- 1-2 Reverse Carrier Gear Assembly Installation
- Third Gear Band Assembly Installation
- 4-5 Clutch Assembly Installation
- Front Differential Transfer Drive Gear Assembly Installation
- Manual Shift Detent Lever and Park Pawl Installation
- Third Gear Band Apply Tube Installation
- Transmission Fluid Baffle Installation
- Fluid Filter Installation
- Front Differential Assembly Cleaning and Inspection
- Front Differential Assembly Installation
- Torque Converter Housing Cleaning and Inspection
- Torque Converter Housing Installation
- Second Coast Clutch Disassemble
- Second Clutch Disassemble
- Fluid Pump Disassemble
- Fluid Pump Cleaning and Inspection
- Fluid Pump Assemble
- Second Clutch Assemble
- Second Coast Clutch Assemble
- Second Clutch Piston Travel Measurement
- Second Coast Clutch Piston Travel Measurement
- Second Coast, Second Clutch Hub and Second Clutch Sprag Disassemble
- Second Coast, Second Clutch Hub and Second Clutch Sprag Assemble
- Fluid Pump Installation
- Control Valve Body Assembly Disassemble
- Middle Control Valve Body Disassemble
- Middle Control Valve Body Assemble
- Rear Control Valve Body Disassemble
- Rear Control Valve Body Assemble
- No. 2 Rear Control Valve Body Disassemble
- No. 2 Rear Control Valve Body Assemble
- Front Control Valve Body Disassemble
- Front Control Valve Body Assemble
- Control Valve Body Assembly Assemble
- Control Valve Body Assembly Installation
- Wiring Harness Installation
- Control Valve Body Cover Installation
- Park/Neutral Position Switch Installation
- Input Speed Sensor Installation
- Output Speed Sensor Installation
- Drain Plug Installation
- Holding Fixture Removal
- Torque Converter Assembly Installation
- Description and Operation
- Park - Engine Running
- Reverse
- Reverse Inhibit
- Neutral - Engine Running
- Drive and Intermediate Range - First Gear
- Low Range - First Gear, Engine Braking
- Drive, Intermediate and Low Range - Second Gear
- Drive and Intermediate Range - Third Gear
- Drive Range - Fourth Gear
- Drive Range Fifth Gear - TCC Released
- Drive Range Fifth Gear - TCC Applied
- Drive Range - Emergency Fifth Gear
- Fluid Passages
- Transmission General Information
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission General Description
- Transmission Component and System Description
- Transmission Adaptive Functions
- Transmission Indicators and Messages
- Electronic Component Description
- Automatic Transmission Output Speed (A/T OSS) Sensor Assembly (62)
- Automatic Transmission Input Speed (A/T ISS) Sensor Assembly (73)
- Shift Solenoid Valves
- Line Pressure Control Solenoid Valve (SLT) (316)
- TCC Lock Up Pressure Control Solenoid Valve (SLU) (339)
- Shift Pressure Control Solenoid Valve (SLS) (340)
- Automatic Transmission Fluid Temperature (TFT) Sensor
- Park/Neutral Position Switch Assembly (75)
- Special Tools and Equipment