Sliding Roof, Soft Top, Top Attachments -- 190 Chassis

• General Information
  • Notes On Magic Sky Control - AH77.00-P-0001-01A
  • General Notes: Passenger Cars: Sliding Roof, Soft Top, Top Attachments - AH77.00-Z-9999AZ
  • Notes On Removal/Installation Of Bonded Elements Of Panoramic Roof - AH77.21-P-0001-01A
• Basic Knowledge
  • Rain Closing Function, Basic Function - GF77.20-P-1002A
  • Roof Roller Sunblind Drive Unit, Basic Function - GF77.20-P-2015A
  • Sliding Sunroof Control Module, Basic Function - GF77.20-P-9891A
  • Roof System, Basic Function - GF77.20-P-9900A
  • Open/Close Sliding Sunroof, Basic Function - GF77.20-P-9901A
  • Open/Close Roof Roller Sunblind, Basic Function - GF77.20-P-9902A
  • Panoramic Sliding Sunroof Drive Unit, Basic Function - GF77.21-P-2002A
  • Panoramic Sliding Sunroof Control Unit, Basic Function - GF77.21-P-9891A
  • Soft Top, Function - GF77.30-P-0002RR
  • Table Of Contents For Function Description Of Soft Top - GF77.30-P-0999RR
  • Overview Of System Components For Soft Top, Component Description - GF77.30-P-9997RR
  • Soft Top Control Control Unit, Component Description - GF77.39-P-3211RR
• Safety Precautions
  • Safety Information: Sliding Roof, Soft Top, Top Attachments - AS77.00-Z-9999ZZ
  • Risk Of Injury Due To Snapping Or Warming Up Of Cutting Wire And Due To Splinters When Cutting Out Glued Panoramic Roofs - AS77.21-Z-0002-01A
• Testing & Repair
  • Remove/Install Roller Sun Blind On Panoramic Sunroof - AR77.21-P-0205RG
  • Remove/Install Panoramic Roof - AR77.21-P-0750RG
  • Prepare Panoramic Roof Frame For Installation - AR77.21-P-0800-02RG
  • Apply Glue For Panoramic Roof Frame - AR77.21-P-0800-03RG
  • Prepare Panoramic Roof Frame Body Flange For Installation. - AR77.21-P-0800-05RG
  • Set Up Soft Top On Fixture - AR77.30-P-1002-03RGR
  • Remove/Install Soft Top - AR77.30-P-1002RGR
  • Remove/Install Front Soft Top Roof Lining - AR77.30-P-1007RGR
  • Remove/Install Rear Soft Top Roof Lining - AR77.30-P-1012RGR
  • Close Mechanical Soft Top - AR77.30-P-1020RGR
  • Bring Soft Top To Intermediate Position And Secure - AR77.30-P-1030-01RGR
  • Remove/Install Front Soft Top Seal To Front Door Side Window - AR77.30-P-3361RGR
  • Remove/Install Center Soft Top Seal To Front Door Side Window - AR77.30-P-3362RGR
  • Remove/Install Rear Soft Top Seal To Front Door Side Window - AR77.30-P-3363RGR
  • Fasten Water Drain In Area Of B-Pillar - AR77.30-P-3370-01RGR
  • Remove/Install Water Drain For Soft Top - AR77.30-P-3370RGR
  • Remove/Install Seal On Crossmember Above Windshield - AR77.30-P-4050RGR
  • Prepare Soft Top Canvas - AR77.31-P-1001-04RGR
  • Prepare Soft Top Frame - AR77.31-P-1001-05RGR
  • Align Soft Top Canvas - AR77.31-P-1001-06RGR
  • Bond Soft Top Canvas - AR77.31-P-1001-07RGR
  • Remove/Install Soft Top Canvas - AR77.31-P-1001RGR
  • Remove/Install Soft Top Tension Cable - AR77.33-P-1005RGR
  • Remove/Install Soft Top Locking Unit - AR77.33-P-1006RGR
  • Remove/Install Soft Top Lock On Windshield Frame - AR77.33-P-1007RGR
  • Remove/Install Header Bow - AR77.33-P-1022RGR
  • Adjust Header Bow - AR77.33-P-1023RGR
  • Remove/Install Drive For Header Bow - AR77.33-P-1040RGR
  • Remove/Install Rear Soft Top Latch - AR77.33-P-1100RGR
  • Adjust Rear Soft Top Latch - AR77.33-P-1101RGR
  • Remove/Install Soft Top Control Hydraulic Unit - AR77.37-P-3500RGR
  • Check/Correct Fluid Level Of Hydraulic Unit - AR77.37-P-3501RGR
  • Remove/Install Soft Top Mechanism Hydraulic Cylinder - AR77.37-P-4171RGR
  • Prepare Test Valve Block - AR77.37-P-4205-01RGR
  • Connection Scheme For Pressure Test - AR77.37-P-4205-02RGR
  • Connect/Disconnect Test Valve Block At Hydraulic Unit - AR77.37-P-4205RGR
  • Remove/Install Soft Top Mechanism Control Unit - AR77.39-P-3606RGR
• Test & Adjustment Values
  • Test And Adjustment Values: Passenger Cars: Sliding Roof, Soft Top, Top Attachments - BE77.00-Z-9999AZ
• Maintenance
  • Clean Water Drains In Soft Top Compartment - AP77.30-P-7731HW
  • Clean And Lubricate Soft Top Seal - AP77.30-P-7736SL
  • Check Side Header Bows - AP77.33-P-7751HW
• Capacities & Specifications
  • Capacities: Passenger Cars: Sliding Roof, Soft Top, Top Attachments - BF77.00-Z-9999AZ
• Torque Specifications
  • Tightening Torques: Passenger Cars: Sliding Roof, Soft Top, Top Attachments - BA77.00-Z-9999AZ
  • Soft Top Mechanism - BA77.33-P-1000-02D
  • Soft Top Hydraulic System - BA77.37-P-1000-01A
• Wiring Diagrams
  • Electrical Function Schematic For Electrohydraulic Soft Top
    • Electrical Function Schematic For Electrohydraulic Soft Top - PE77.39-P-2052-97HBA
    • Electrical Function Schematic For Electrohydraulic Soft Top - PE77.39-P-2052HBA
• Special Tools
  • 168 589 00 62 00 Handles - WS77.00-P-0007B
  • 129 589 01 98 00 Welding Bead Catcher - WS77.00-P-0010K
  • 230 589 04 63 00 Support - WS77.00-P-0026B
  • 230 589 01 63 00 Filling Syringe - WS77.00-P-0028B
  • 230 589 00 91 00 Valve Block - WS77.00-P-0035B
  • 171 589 00 91 00 Adapter - WS77.00-P-0047B
  • 126 589 14 21 00 Tester - WS77.00-P-0051B
  • 197 589 01 31 00 Device - WS77.00-P-0058C
  • 231 589 02 63 00 Support - WS77.00-P-0062B