Section 910 (Heating, Ventilation And Air Conditioning)
WARNING: This page is about a different car, the 2003 GMC Sonoma, 2003 GMC Jimmy, 2003 Chevrolet S10 Pickup, and 2003 Chevrolet Blazer. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Heating, Ventilation and Air Conditioning
- Leak Testing
- Air Conditioning (A/C) System Performance Test
- Air Conditioning (A/C) Diagnostics - Pressure Zone A
- Air Conditioning (A/C) Diagnostics - Pressure Zone B
- Air Conditioning (A/C) Diagnostics - Pressure Zone C
- Air Conditioning (A/C) Diagnostics - Pressure Zone D
- Heating Performance Diagnostic
- Defrosting Insufficient
- Noise Diagnosis - Blower Motor
- Noise Diagnosis - Air Conditioning (A/C) System
- Odor Diagnosis
- Repair Instructions
- Odor Correction
- Refrigerant Recovery and Recharging
- Flushing
- Compressor Oil Balancing
- Compressor Replacement (2.2L)
- Compressor Replacement (4.3L)
- Compressor Clutch Plate and Hub Assembly Removal (V7 - Direct Mount)
- Compressor Clutch Plate and Hub Assembly Removal (HT6/HD6/HU6)
- Clutch Rotor and/or Bearing Removal (HT6/HD6/HU6)
- Clutch Rotor and/or Bearing Removal (V7 - Direct Mount)
- Compressor Clutch Coil Removal (HT6/HD6/HU6)
- Compressor Clutch Coil Removal (V7 - Direct Mount)
- Compressor Pressure Relief Valve Removal (HT6/HD6/HU6)
- Compressor Pressure Relief Valve Removal (V7 - Direct Mount)
- Compressor Control Switches Removal (HT6/HD6/HU6)
- Compressor Clutch Plate/Hub Assembly Install (V7 - Direct Mount)
- Compressor Clutch Plate/Hub Assembly Install (HT6/HD6/HU6)
- Clutch Rotor and/or Bearing Install (HT6/HD6/HU6)
- Clutch Rotor and/or Bearing Install (V7 - Direct Mount)
- Compressor Clutch Coil Install (HT6/HD6/HU6)
- Compressor Clutch Coil Install (V7 - Direct Mount)
- Compressor Pressure Relief Valve Install (2.2L)
- Compressor Pressure Relief Valve Install (4.3L)
- Compressor Control Switches Install (HT6/HD6)
- Compressor Leak Testing
- Compressor Sealing Washers Replacement
- O-Ring Replacement
- Compressor Hose Assembly Replacement (2.2L)
- Compressor Hose Assembly Replacement (4.3L)
- Evaporator Tube Replacement (2.2L)
- Evaporator Tube Replacement (4.3L)
- Air Conditioning (A/C) Refrigerant Filter Installation
- Air Conditioning (A/C) Refrigerant Filter Replacement
- Expansion (Orifice) Tube Replacement
- Suction Screen Installation
- Suction Screen Replacement
- Compressor Relay Replacement
- Air Conditioning (A/C) High Pressure Switch Replacement (4.3L)
- Air Conditioning (A/C) Low Pressure Switch Replacement (4.3L)
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement (2.2L)
- Condenser Replacement
- Accumulator Replacement
- Evaporator Core Replacement
- Heater Hose Replacement - Inlet (2.2L)
- Heater Hose Replacement - Inlet (4.3L)
- Heater Hose Replacement - Outlet (2.2L)
- Heater Hose Replacement - Outlet (4.3L)
- Blower Motor Relay Replacement
- Blower Motor Resistor Assembly Replacement (C42)
- Blower Motor Resistor Assembly Replacement (C60)
- Blower Motor Replacement (C60, C68)
- Blower Motor Replacement (C42)
- Air Distributor Duct Replacement
- Air Outlet Replacement - Instrument Panel - Right
- Air Outlet Replacement - Center Floor (Pickup)
- Air Outlet Replacement - Rear Floor (Utility Only)
- Air Temperature Door Replacement
- Defroster Door Replacement
- Mode Door Replacement
- Recirculation Door Replacement
- Heater Core Replacement
- Heater/Vent Module Replacement
- Special Tools and Equipment