Section 648 (Instrument Panel, Gauges & Console)
WARNING: This page does not describe the selected car, but rather 7 other vehicles, including the 2002 GMC Yukon XL, 2002 GMC Yukon, 2002 Chevrolet Tahoe, 2002 Chevrolet Suburban, and 2002 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Schematic & Routing Diagrams
- Component Locator
- Diagnostic Information & Procedures
- Diagnostic Starting Point - Instrument Panel, Gauges & Console
- Diagnostic System Check - Instrument Cluster
- Diagnostic System Check - Driver Information Systems
- Diagnostic System Check - Audible Warnings
- Scan Tool Output Controls
- Scan Tool Data List
- Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) List
- DTC B0540: DIC Receives Class 2 Message Indicating Loss of Vehicle Speed
- DTC B1023: DIC Detects Switch Signal Circuit is Low
- DTC B1367: Ignition 0 Voltage Circuit Less Than 75 Percent of Battery Voltage
- DTC B2961: Ignition 1 Input is Active - Key in Ignition Switch Signal Circuit is Inactive - Signal Circuit is High
- DTC P0461: PCM Not Detecting Change in Fuel Level After Distance of 201 km (125 mi)
- DTC P0462: Detects Fuel Level Signal is Less than 3.5%
- DTC P0463: Detects Fuel Level Signal is Greater than 98%
- DTC P0608: PCM Detects Control Circuit Mismatch
- DTC P0654: PCM Detects Control Circuit Mismatch
- DTC P1431: PCM Detects No Change in Secondary Fuel Level
- DTC P1432: Fuel Level Signal 3.5% or Less
- DTC P1433: Fuel Level Signal Greater Than 98%
- Symptoms - Instrument Panel, Gauges & Console
- Instrument Cluster Inoperative
- Clock Malfunction
- Engine Coolant Temperature Gauge Inaccurate or Inoperative
- Engine Oil Pressure Gauge Inaccurate or Inoperative
- Fuel Gauge Inaccurate or Inoperative (Dual Tank)
- Fuel Gauge Inaccurate or Inoperative (Single Tank)
- Hourmeter Inaccurate or Inoperative
- Odometer Trip/Reset Switch Inoperative
- Speedometer and/or Odometer Inaccurate or Inoperative
- Tachometer Inaccurate or Inoperative
- Transmission Fluid Temperature Gauge Inaccurate or Inoperative
- Volt Gauge Inaccurate or Inoperative
- Change Engine Oil Indicator Always On
- Change Engine Oil Indicator Inoperative
- Engine Oil Pressure Indicator Always On
- Low Engine Oil Level Indicator Always On
- Low Engine Oil Level Indicator Inoperative
- PRNDL Display Park Indicator Inoperative
- Driver Information Center (DIC) Inoperative
- Driver Information Center (DIC) Switch(es) Inoperative
- Chime Always On
- Chime Inoperative
- Repair Instructions
- Accessory Switch Replacement
- Insulator Replacement - IP
- IP Extension Replacement (Luxury)
- IP Extension Replacement (Non-Luxury)
- Knee Bolster Replacement (Non-Luxury)
- Knee Bolster Replacement (Luxury)
- Trim Panel Replacement - Instrument Panel (IP) Upper
- Bezel Replacement - IP Cluster
- Compartment Replacement - IP
- Deflector Replacement - Instrument Panel Air - Center
- Deflector Replacement - Instrument Panel Air - Left
- Deflector Replacement - Instrument Panel Air - Right Vent
- IP Assist Handle Replacement
- Driver Information Center Replacement
- Instrument Panel Cluster (IPC) Replacement
- Instrument Cluster Lamp Replacement
- Ashtray Replacement
- Cupholder Replacement
- 12-Volt Power Supply Replacement
- IP Trim Panel Replacement - Lower
- IP Carrier Replacement
- Door Replacement - Console Compartment
- Lock Cylinder Replace - Console Compartment Door
- Console Storage Bin Replacement (Non-Luxury)
- Console Storage Bin Replacement (Luxury)
- Clock Replacement - Console
- Console Replacement (Base Console)
- Console Replacement (Luxury Console)
- Bezel Replacement - Floor Console (Luxury)
- Bracket Replacement - Console Floor
- Power Accessory Port Replace - Front Floor Console
- Power Accessory Outlet Cover Replacement - Floor Console
- Cupholder Replacement - Front Floor Console
- Center Console End Panel Replacement
- IP Harness Replacement
- Air Distributor Duct Replacement
- Description & Operation
- Special Tools & Equipment