General Electrical System -- Repair (G42)
- 61 00 General Information
- Information on removing, connecting and changing the battery
- Notes for disconnecting and connecting the vehicle battery
- Notes on handling optical fibers
- Notes on handling the high pressure cleaner
- Notes on handling wiring harnesses and cables
- Repairing airbag cables
- Safety instructions for handling vehicle battery
- Safety instructions on handling hybrid cars
- 61 00 730 Programming/encoding the control unit(s) including deletion of fault memory (after vehicle test)
- 61 12 Intelligent Battery Sensor
- 61 13 Plug Connections, Terminals
- Butt connector for repairing a plug connection
- Circular connector, 13-pin, system D2.5
- Connector housing, LCC contact (load current contact)
- Crimping annular contacts
- Crimping Micro Power Quadlock contacts (MPQ)
- Crimping Micro Quadlock System contacts (MQS)
- Crimping of NanoMQS contacts (MQS)
- Cutting, strip off insulation and crimping optical fibers
- Cutting to length and strip off insulation from cables
- In-line connectors, 24-/44-pin, Hybrid System MQS/MPQ
- Inline connectors, 6-, 8-pin, System MQS
- In-line plugs, 2-pin, System MDK 3 plus 2.8
- Inline plugs, 2-pin, System MPQ 2.8
- Inline plugs, 3-, 6-pin, System Elo-Power 2.8
- Inline plugs, 4-, 10-pin, System Elo
- Socket housing 42-, 43-, 46-pin, Hybrid System MQS/MPQ
- Socket housings, 2x21-, 2x27-pin, Hybrid Systems MQS/MPQ, Elo/Elo Power
- Socket housing (radio connector), Hybrid System MQS/MPQ
- Socket housings, 5-pin, 8-pin, System MQS/MPQ
- Special tools for wiring harness repairs
- Unlocking and disconnecting different plug connections
- Unlocking and disconnecting various plug connections in electrical and hybrid vehicles
- 61 14 Power Distribution Box
- 61 14 010 Remove and install/replace power distribution box (trunk)
- 61 14 035 Removal & install/replace power distribution box front positive battery cable
- 61 14 040 Removing and installing/replacing positive battery cable power distribution, rear
- 61 14 041 Removing and installing/replacing positive battery cable power distribution, rear (behind luggage compartment trim panel, right)
- 61 20 Battery Ground Cable, Power Reset
- Notes on AGM battery
- Notes regarding the lithium ion battery
- 61 20 503 Vehicle battery - closed current monitoring
- 61 20 900 Disconnecting and connecting battery ground lead
- Remove the cover of the rear right engine compartment
- Disconnecting the negative battery cable of the auxiliary battery in the engine compartment
- Remove luggage compartment floor covering
- If installed: Remove emergency wheel
- Disconnecting the negative battery cable of the system battery
- Connecting negative battery cable of the system battery
- If installed: Install the emergency wheel
- Install luggage compartment floor covering
- Connecting the negative battery cable of the auxiliary battery in the engine compartment
- Install the rear right engine compartment cover
- Activating the 48 V electrical system
- 61 20 908 Running vehicle battery "power reset"
- Assessment of the transportability of lithium-ion starter/auxiliary batteries in service workshops
- 61 21 Vehicle Battery
- 61 21 010 Removing and installing the vehicle battery
- 61 21 017 Replacing vehicle battery - registering with battery replacement
- 61 21 028 Charging battery
- 61 21 028 Supporting voltage of the vehicle electrical system/recharging vehicle battery
- 61 21 006 Removing and installing 48V battery (M240i and M240i xDrive 2024-)
- 61 21 007 Replacing 48V battery (after vehicle diagnosis) (M240i and M240i xDrive 2024-)
- Charging parameters for lithium ion batteries
- Description of the manual Li parameter setting for DEUTRONIC DBL800/1200/1600
- Description of the manual Li parameter setting for ELEKTRON HS-1000
- Description of the manual Li parameter setting for ELTEK MultiCharger 750/900/1500
- 61 31 Switches
- 61 31 008 Removing and installing steering column switch cluster
- 61 31 011 Removing and installing/replacing coil spring cassette on steering wheel
- 61 31 021 Remove and install/replace ring antenna
- 61 31 037 Removing and installing/replacing light control unit
- 61 31 043 Removing and installing roof console
- 61 31 066 Removing and installing/replacing hotel position switch
- 61 31 068 Remove and install/replace the switch for the front passenger airbag deactivation
- 61 31 082 Remove and install/replace the central locking button
- 61 31 083 Removing and installing/replacing the switch for tailgate release
- 61 31 084 Removing and installing/replacing the switch for the power tailgate
- 61 31 117 Removing and installing/replacing power window switch on driver's side
- 61 31 118 Removing and installing/replacing the power window switch on the passenger's side
- 61 31 174 Removing and installing control unit, additional seat function (one)
- 61 31 195 Removing and installing infotainment system controller
- 61 31 197 Removing and installing operating facility for center console
- 61 31 204 Replacing operating unit for seat adjustment
- 61 31 221 Removing and installing/replacing both multifunction steering wheel switches
- 61 31 251 Remove and install audio operating facility
- 61 31 310 Replacing brake light switch
- 61 31 362 Removing and installing remote control receiver (Trim panel for rear shelf removed)
- 61 31 513 Replacing steering column switch cluster (after vehicle diagnosis)
- 61 31 544 Replace roof function center (After vehicle diagnosis)
- 61 31 696 Replacing front controller (After vehicle diagnosis)
- 61 31 704 Replacing the operating facility in the center console (After vehicle diagnosis)
- Removing the operating facility in the center console
- Deactivate electrical system
- Removing the iDrive Controller
- Removing the HDC button/trim
- Installing the HDC button/trim
- Installing the iDrive Controller
- Installing the operating facility in the center console
- Activate electrical system
- Activating the 48 V electrical system
- 61 33 Horn
- 61 34 Cigarette Lighter, Power Sockets
- 61 35 Control Units, Modules
- Notes on ESD protection (Electro Static Discharge)
- Overview, rain sensor (additional work when replacing the windshield/sensor replacement)
- Overview of additional work for the removal and installation or replacement of electronic components in the body area/windshield
- 61 35 013 Removing and installing LIN power distribution box
- 61 35 021 Removing and installing/replacing the storage tray for the near field communication
- 61 35 080 Removing and installing control unit/module for left or right seat adjustment
- 61 35 095 Removing and installing control unit/module for seat heating (left or right)
- 61 35 097 Removing and installing control unit/module for left or right seat heating (rear seat)
- 61 35 177 Removing and installing the rain-light sensor
- 61 35 179 Remove and install rain-light-solar-condensation sensor
- 61 35 196 Removing and installing the control unit for automatic tailgate operation
- 61 35 240 Removing and installing the control unit for contactless trunk opening
- 61 35 243 Removing and installing the sensor line for top contactless trunk opening
- 61 35 245 Removing and installing the sensor line for bottom contactless trunk opening
- 61 35 278 Removing/installing Body Domain Controller (BDC) control unit
- 61 35 582 Replacing the control unit/module for seat adjustment, left or right (After vehicle diagnosis)
- 61 35 678 Replacing rain/light sensor (after vehicle diagnosis)
- 61 35 697 Replacing the control unit for automatic tailgate operation (After vehicle diagnosis)
- 61 35 779 Replace Body Domain Controller control unit (BDC) (After vehicle diagnosis)
- 61 35 953 Removing and installing/replacing interior antenna for Comfort Access (front storage compartment) (following vehicle diagnosis)
- 61 35 954 Removing and installing/replacing the interior antenna for Comfort Access (center console at rear) (after vehicle diagnosis)
- 61 35 970 Removing and installing/replacing the luggage compartment antenna for Comfort Access (after vehicle diagnosis)
- 61 35 975 Removing and installing/replacing the bumper antenna for Comfort Access (after vehicle diagnosis)
- 61 35 980 Removing and installing/replacing the antenna for Comfort Access on the left or right (after vehicle diagnosis)
- 61 42 Voltage Transformer
- 61 61 Windshield Wiper System
- 61 71 WINDHSHIELD Washer System