Section 324 (Electrical System, Equipment & Instructions -- CLK350 Coupe (209.356))
WARNING: This page is about a different car, the 2009 Mercedes-Benz CLK350 and 2008 Mercedes-Benz CLK350. However, it is still accessible from the selected car via links, so may be relevant.
- General Information
- Information on preventing damage to electronic components due to electrostatic discharge - AH54.00-P-0001-01A
- Note on the high-voltage on-board electrical system - AH54.00-P-0010-01A
- Evaluating electronic components after repair and painting work and after accidents - AH54.00-P-1000-01A
- General notes: Passenger cars: Electrical system, equipment and instruments - AH54.00-Z-9999AZ
- Notes on battery - AH54.10-P-0001-01A
- Notes on AGM battery - AH54.10-P-0002-01A
- Notes on programming control units - AH54.21-P-0001-03Y
- Notes on programming control units - AH54.21-P-0001-03Z
- Flow chart for offline programming with Special Release CD - AH54.21-P-0001-04Z
- Notes on SCN coding of control units - AH54.21-P-0004-01X
- Basic Knowledge
- Data bus system, block diagram - GF54.00-P-0004-03A
- Data bus system, advantages - GF54.00-P-0004-04A
- Data bus system function - GF54.00-P-0004A
- CAN data bus data telegram - GF54.00-P-0005-01A
- CAN data bus specification - GF54.00-P-0005-02A
- CAN data bus fault recognition - GF54.00-P-0005-03A
- CAN data bus applications - GF54.00-P-0005-04A
- CAN data bus, function - GF54.00-P-0005A
- CAN data bus, function - GF54.00-P-0005VA
- CAN data bus, contents, function description - GF54.00-P-0999ZZ
- Fuse and relay box as-built configuration - GF54.15-P-0800Q
- Fuse assignment of rear fuse and relay box - GF54.15-P-1256-01Q
- Fuse assignment of fuse and relay box in left engine compartment - GF54.15-P-1256-03Q
- Fuse assignment of fuse box in interior compartment on driver's side - GF54.15-P-1256-04Q
- Fuse assignment of front prefuse box - GF54.15-P-1256-07Q
- Relay assignment of rear fuse and relay box - GF54.15-P-1257-01P
- Relay assignment of fuse and relay box in engine compartment, left - GF54.15-P-1257-03P
- Steering column module, task - GF54.21-P-4104-02QA
- Overhead control panel control unit purpose - GF54.21-P-4105-02Q
- Upper control panel control unit, task - GF54.21-P-4105-02QA
- Overhead control panel control unit design - GF54.21-P-4105-03Q
- Upper control panel control unit, design - GF54.21-P-4105-03QA
- Upper control panel control unit, design - GF54.21-P-4105-03QB
- Upper control panel control unit, location/task/design/function - GF54.21-P-4105Q
- Front SAM control unit with fuse and relay module, task - GF54.21-P-4108-01Q
- Front SAM control unit with fuse and relay module, location / task / design - GF54.21-P-4108Q
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01Q
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01QA
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01QB
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01QC
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01QD
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01QE
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01QF
- Rear SAM control module with fuse and relay module, task - GF54.21-P-4112-01QG
- Rain sensor/light sensor, function - GF54.21-P-4123-04Q
- Rain/light sensor location/task/function - GF54.21-P-4123Q
- Steering column module location/task - GF54.21-P-4125Q
- Rear SAM control module with fuse and relay module, location/task - GF54.21-P-4130Q
- Rear control unit, task - GF54.21-P-4133-01Q
- Rear control unit, location/task - GF54.21-P-4133Q
- Lamp switch module, design - GF54.25-P-4103-01A
- Lamp switch module, location/task/design - GF54.25-P-4103A
- Instrument cluster (IC), operating information - GF54.30-P-0002-05QO
- Instrument cluster (IC), networking of components - GF54.30-P-0002-06QO
- Instrument cluster (IC), function - GF54.30-P-0002Q
- Table of contents for function description of instrument cluster (IC) - GF54.30-P-0997QZ
- Activating instrument cluster, function - GF54.30-P-2006Q
- Instrument cluster illumination, function - GF54.30-P-2007Q
- Setting switch and controls illumination, function - GF54.30-P-2010Q
- Function to display malfunction/warning indication via indication lights - GF54.30-P-2011QO
- Display monitoring/warning messages via multifunction display, function - GF54.30-P-2012QO
- Output acoustic warning messages, function - GF54.30-P-2013QO
- Indicator lamp test and engine running detection, function - GF54.30-P-2014QO
- Displaying fuel quantity, function - GF54.30-P-3018Q
- Display outside temperature, function - GF54.30-P-3019QO
- Displaying coolant temperature, function - GF54.30-P-3020Q
- Displaying engine speed, function - GF54.30-P-3021Q
- Displaying distance, function - GF54.30-P-3022Q
- Display transmission information, function - GF54.30-P-3023QO
- Display transmission information, function - GF54.30-P-3023QQO
- Displaying time, function - GF54.30-P-3024Q
- Displaying speed, function - GF54.30-P-3025Q
- Battery charge/alternator monitoring function - GF54.30-P-3027Q
- Instrument cluster (IC), task - GF54.30-P-3039-02Q
- Instrument cluster (IC), location / task - GF54.30-P-3039Q
- Coolant/washer fluid level voltage coding, function - GF54.30-P-4001QO
- Component description for an engine diagnosis indicator lamp - GF54.30-P-5010V
- Component description for the "CHECK ENGINE" indicator lamp - GF54.30-P-5011V
- Survey of system components of instrument cluster (IC), location / task / design / function - GF54.30-P-9997QZ
- Trip computer (TRIP), networking of components - GF54.50-P-0001-02QA
- Function of trip computer (TRIP) - GF54.50-P-0001QA
- Trip computer (TRIP), contents, function description - GF54.50-P-0999QAZ
- Kilometer / miles switchover, function - GF54.50-P-2002QA
- Travel time, function - GF54.50-P-2004QA
- Range, function - GF54.50-P-2006QA
- Fuel consumption, function - GF54.50-P-2007QA
- Distance, function - GF54.50-P-2008QA
- Average speed, function - GF54.50-P-2009QA
- Reset, function - GF54.50-P-2010QA
- Survey of system components, trip computer (TRIP), location / task / design / function - GF54.50-P-9999QAZ
- Parktronic system (PTS) block diagram - GF54.65-P-0001-01Q
- Parktronic system (PTS), location of components - GF54.65-P-0001-02Q
- Parktronic system (PTS), function - GF54.65-P-0001Q
- Contents, function description, Parktronic system (PTS) - GF54.65-P-0999Q
- Self-test, function - GF54.65-P-2000Q
- Forward travel, function - GF54.65-P-4000Q
- Reversing, function - GF54.65-P-4001Q
- PTS control module, location / task - GF54.65-P-4100Q
- Sensors, location/task/function - GF54.65-P-4102T
- Warning display, function - GF54.65-P-4104-01Q
- Warning display, location / task / design / function - GF54.65-P-4104T
- Warning display, location / task / design / function - GF54.65-P-4104TA
- Survey of system components, Parktronic system (PTS), location / task / design / function - GF54.65-P-9999Q
- Safety Precautions
- Risk of death when touching components on vehicles with high-voltage on-board electrical system - AS54.00-Z-0001-01A
- Safety information: Electrical system, equipment and instruments - AS54.00-Z-9999ZZ
- Risk of explosion from gas. Risk of poisoning and burns from swallowing battery electrolyte. Risk of injury to eyes and skin as result of caustic burns from battery electrolyte or from handling damaged lead-acid batteries. - AS54.10-Z-0001-01A
- Risk of injury caused by contact with battery gel when handling damaged lead-gel batteries - AS54.10-Z-0001-02A
- Testing & Repair
- Testing and repair work: Passenger cars: Electrical system, equipment and instruments - AR54.00-Z-9000AA
- Testing and repair work: Passenger cars: Electrical system, equipment and instruments - AR54.00-Z-9209AA
- Initial filling of battery - AR54.10-P-0001Z
- Disconnect/connect battery ground line - AR54.10-P-0003Q
- Remove/install battery - AR54.10-P-0005P
- Treatment of battery if vehicle taken out of service - AR54.10-P-0006P
- Remove/install cigarette lighter - AR54.10-P-0030TX
- Remove/install 12 Volt socket - AR54.10-P-1000TX
- Preparing test with quiescent current retention unit - AR54.10-P-1030-01P
- Preparing test without quiescent current retention unit - AR54.10-P-1030-02P
- Testing quiescent current - AR54.10-P-1030-03P
- Determining circuit with excessive quiescent current consumption - AR54.10-P-1030-04P
- Determining fused components with excessive quiescent current consumption - AR54.10-P-1030-05P
- Determining unfused components with excessive quiescent current consumption - AR54.10-P-1030-06P
- Check quiescent current consumption - AR54.10-P-1030P
- Install/remove battery disconnect switch - AR54.10-P-1060P
- Check battery - AR54.10-P-1129-01A
- Check battery voltage by means of the instrument cluster (IC) - AR54.10-P-1129-02A
- Reduce increased voltage after charging process - AR54.10-P-1129-03A
- Check condition of battery - AR54.10-P-1129P
- Charge battery - AR54.10-P-1130P
- Check battery condition before vehicle delivery - AR54.10-P-1132A
- Removing and installing driver's side interior fuse box - AR54.15-P-1310Q
- Install headliner wiring harness - AR54.18-P-0020Q
- Install wiring harness - AR54.18-P-0056P
- Repair wiring harness by means of axial solder connectors - AR54.18-P-0100-06A
- Checking wiring harness - AR54.18-P-0600-01A
- Repair supplemental restraint system (SRS) squib wiring harness - AR54.18-P-0600A
- Disconnect cables from control units and fuse and relay boxes - AR54.18-P-1261-01P
- Disconnecting cables from control modules and fuse and relay boxes - AR54.18-P-1261-01QA
- Connecting cables to control units and fuse and relay boxes - AR54.18-P-1261-02P
- Removing and installing module box - AR54.20-P-2360Q
- Online SCN coding - AR54.21-P-0013-01X
- Offline SCN coding - AR54.21-P-0013-04X
- Program control unit - AR54.21-P-0014-01Y
- Program control unit - AR54.21-P-0014-01Z
- Programming of control units - AR54.21-P-0014Y
- Programming of control units - AR54.21-P-0014Z
- SCN coding of control units - AR54.21-P-0015X
- Remove/install SAM control unit with fuse and relay box in rear - AR54.21-P-1259Q
- Remove/install SAM with fuse and relay box, left front - AR54.21-P-1260P
- Remove/install upper control panel control unit - AR54.21-P-1262Q
- Remove/install contact switch for door - AR54.25-P-2000P
- Removing and installing combination switch - AR54.25-P-2800PQ
- Remove/install steering column module - AR54.25-P-2802PQ
- Remove/install cruise control switch - AR54.25-P-2803PQ
- Remove/install steering column adjustment switch - AR54.25-P-2804PQ
- Remove/install light switch module - AR54.25-P-3270P
- Pull out instrument cluster - AR54.30-P-6015-01P
- Remove/install instrument cluster - AR54.30-P-6015P
- Removing and installing instrument cluster housing - AR54.30-P-6031P
- Remove/install fanfare horns - AR54.35-P-1555Q
- Remove/install Parktronic system (PTS) sensors in rear bumper - AR54.65-P-0002Q
- Removing and installing Parktronic system (PTS) warning display in instrument panel - AR54.65-P-0003Q
- Remove/install Parktronic system (PTS) warning indicator in rear dome lamp - AR54.65-P-0004P
- Removing and installing Parktronic system (PTS) switch - AR54.65-P-0005Q
- Remove/install Parktronic system (PTS) control unit - AR54.65-P-0006Q
- Test & Adjustment Values
- Maintenance
- Retrofitting & Conversion
- Torque Specifications
- Miscellaneous Notes
- Special Tools
- 124 589 00 21 00 35-pin socket box - WS54.00-P-0002B
- 129 589 00 09 00 Pin socket - WS54.00-P-0007B
- 129 589 00 21 00 126-pin socket box - WS54.00-P-0008B
- 140 589 02 33 00 Pulling hook - WS54.00-P-0011B
- 140 589 12 21 00 Baseline current draw test adapter 1 - WS54.00-P-0015B
- 140 589 13 21 00 Quiescent current test adapter 2 - WS54.00-P-0016B
- 140 589 43 63 00 -pin test cable - WS54.00-P-0020B
- 129 589 01 09 00 Pin socket - WS54.00-P-0040B
- 220 589 00 99 01 Adapter cable - WS54.00-P-0050-01B
- 220 589 00 99 02 Adapter line - WS54.00-P-0050-02B
- 220 589 00 99 03 Adapter line - WS54.00-P-0050-03B
- 220 589 00 99 04 Adapter line - WS54.00-P-0050-04B
- 220 589 00 99 05 Adapter line - WS54.00-P-0050-05B
- 220 589 00 99 06 Adapter line - WS54.00-P-0050-06B
- 220 589 00 99 07 Adapter line - WS54.00-P-0050-07B
- 220 589 00 99 08 Adapter line - WS54.00-P-0050-08B
- 220 589 00 99 09 Adapter line - WS54.00-P-0050-09B
- 220 589 00 99 10 Adapter line - WS54.00-P-0050-10B
- 220 589 00 99 11 Adapter line - WS54.00-P-0050-11B
- 220 589 00 99 12 Adapter line - WS54.00-P-0050-12B
- 220 589 00 99 13 Adapter line - WS54.00-P-0050-13B
- 220 589 00 99 20 Test cable - WS54.00-P-0050-14B
- 220 589 00 99 21 Clamp - WS54.00-P-0050-15B
- 220 589 00 99 22 Safety clamp - WS54.00-P-0050-16B
- 220 589 00 99 23 Clamp test probe - WS54.00-P-0050-17B
- 220 589 00 99 24 Connection plug - WS54.00-P-0050-18B
- 220 589 00 99 30 Adapter cable - WS54.00-P-0050-19B
- 220 589 00 99 31 Adapter cable - WS54.00-P-0050-20B
- 220 589 00 99 33 Safety cable - WS54.00-P-0050-22B
- 220 589 00 99 34 Adapter cable - WS54.00-P-0050-23B
- 220 589 00 99 35 Adapter cable - WS54.00-P-0050-24B
- 220 589 00 99 14 Adapter line - WS54.00-P-0050-25B
- 220 589 00 99 25 Empty case - WS54.00-P-0050-26B
- 220 589 05 99 01 Empty case - WS54.00-P-0050-29B
- 220 589 00 99 37 Adapter cable - WS54.00-P-0050-37B
- 168 589 02 31 00 Unlocking tool - WS54.00-P-0051B
- 169 589 00 37 00 Pliers - WS54.00-P-0073B
- Special tools: Passenger cars: Electrical system, equipment and instruments - WS54.00-Z-9999AZ