Section 13 (Engine Controls And Fuel - 1.6L (LH7) Diesel - Diagnostic Information And Procedures (P0016 - P049D))
WARNING: This page is about a different variant/trim than selected.
- Diagnostic Information And Procedures
- DTC P0016: Crankshaft Position - Camshaft Position Not Plausible
- DTC P003A: Turbocharger Boost Control Position Not Learned
- DTC P0045, P0047, Or P0048: Turbocharger Boost Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0046, P2598, Or P2599: Turbocharger Boost Control Position Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P007B: Charge Air Cooler Temperature Sensor 1 Performance
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P007C, P007D Or P007E: Charge Air Cooler Temperature Sensor 1 Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0087, P0089, P228C, P228D, Or P2293: Fuel Rail Low Pressure/Fuel Pressure Regulators
- DTC P0090, P0091, Or P0092: Fuel Pressure Regulator 1 Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0096 Or P0111: Intake Air Temperature (IAT) Sensor 1/2 Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTCs
- Conditions for Setting the DTCs
- Action Taken When the DTC Sets
- Conditions for Clearing the DTCs
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P00C7: Intake Air Pressure Measurement System
- DTC P00E9: Intake Air Temperature (IAT) Sensor 3 Circuit Performance
- Diagnostic Instructions
- DTC Descriptor
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTCs
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P00EA, P00EB, Or P00EC: Intake Air Temperature (IAT) Sensor 3 Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0097, P0098, P0099, P00F4, P00F5, Or P00F6: Intake Air Temperature (IAT) Sensor 2 Circuit/Intake Air Humidity Sensor Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTCs
- Conditions for Setting the DTCs
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P00FF, P069E, P06EC, P0700, P0800, P0AC4, P1700, P1E00, P2561, P25A2, P25AF, P25C9, P26C8, Or P26C9: Control Module Requested MIL Illumination
- DTC P0101: Mass Air Flow (MAF) Sensor Performance
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0102 Or P0103: Mass Air Flow (MAF) Sensor Circuit Low/High Frequency
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0106: Manifold Absolute Pressure (MAP) Sensor Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0107 Or P0108: Manifold Absolute Pressure (MAP) Sensor Circuit Low/High Voltage
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0112, P0113, Or P0114: Intake Air Temperature (IAT) Sensor 1 Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTCs
- Conditions for Setting the DTCs
- Action Taken When the DTCs Set
- Conditions for Clearing the DTCs
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0117, P0118, Or P0119: Engine Coolant Temperature (ECT) Sensor Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0128: Engine Coolant Temperature (ECT) Below Thermostat Temperature
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0171 Or P0172: Fuel System Lean/Rich
- DTC P0181, P0182, P0183, Or P0184: Fuel Temperature Sensor Performance/Fuel Temperature Sensor Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P018B, P018C, Or P018D: Fuel Pressure Sensor Performance/Fuel Pressure Sensor Circuit Voltage
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0191, P0192, Or P0193: Fuel Rail Pressure Sensor Performance/Fuel Rail Pressure Sensor Circuit Voltage
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P01CB, P01CC, P01CD, P01CE, P01CF, P01D0, P01D1, Or P01D2: Cylinder 1-4 Injection Timing Retarded/Advanced
- DTC P01F0: Coolant Temperature Dropped Below Diagnostic Monitoring Temperature
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0201, P0202, P0203, Or P0204: Cylinder 1-4 Injector Control Circuit
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P020A, P020B, P020C, Or P020D: Cylinder 1-4 Injection Timing
- DTC P0216: Injector Timing Control Circuitry
- DTC P0234, P0299, Or P2263: Engine Overboost/Engine Underboost/Turbocharger Boost System Performance
- DTC P0261, P0262, P0264, P0265, P0267, P0268, P0270, Or P0271: Cylinder 1-4 Injector Control Circuit Low/High Voltage
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0263, P0266, P0269, Or P0272: Cylinder 1-4 Balance System
- DTC P026A: Charge Air Cooler (CAC) Low Efficiency
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P02CC, P02CD, P02CE, P02CF, P02D0, P02D1, P02D2, Or P02D3: Cylinder 1-4 Injector Exceeded Minimum/Maximum Learning Limit
- DTC P02E0, P02E2, P02E3, P02EB, P122B, P122C, Or P1425: Intake Air Flow Valve Control Circuit/Intake Air Flow Valve Control Motor
- DTC P02E1, P02E4, Or P02E5: Intake Air Flow Valve Control Performance/Intake Air Flow Valve Stuck
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0300: Engine Misfire Detected
- DTC P0315: Crankshaft Position System Variation Not Learned
- DTC P0335 Or P0336: Crankshaft Position Sensor Circuit/Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0340 Or P0341: Camshaft Position Sensor Circuit/Performance
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Actions Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P034A Or P034B: Crankshaft Position Sensor - Engine Start Position Incorrect/Crankshaft Direction Incorrect
- DTC P037A, P037B, Or P0381: Wait To Start Indicator Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P037E Or P037F: Glow Plug Feedback Circuit Low/High Voltage
- DTC P0401 Or P0402: Exhaust Gas Recirculation (EGR) Flow Insufficient/Excessive
- Diagnostic Instructions
- DTC Descriptors
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0403, P0490, P1402, P1407, Or P140F: Exhaust Gas Recirculation (EGR) Circuits/Exhaust Gas Recirculation (EGR) Current Performance
- DTC P0404, P0405, Or P0406: Exhaust Gas Recirculation (EGR) Open Position Performance/Exhaust Gas Recirculation (EGR) Position Sensor Circuit Voltage
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- Repair Verification
- DTC P0407, P0408, P046E, Or P046F: Exhaust Gas Recirculation Cooler Coolant Inlet Temperature Sensor
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P0421: Catalyst 1 Low Efficiency
- DTC P042E Or P042F: Exhaust Gas Recirculation (EGR) Open/Closed Position Performance
- DTC P049D: Exhaust Gas Recirculation (EGR) Position Not Learned