Section 147 (Heating, Ventilation And Air Conditioning)
WARNING: This page is about a different car, the 2003 Pontiac Sunfire and 2003 Chevrolet Cavalier. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Heating, Ventilation and Air Conditioning
- Leak Testing
- Air Conditioning (A/C) System Performance Test
- A/C System Pressure - Zone Classification
- A/C Performance
- Air Conditioning (A/C) Diagnostics - Pressure Zone A
- Air Conditioning (A/C) Diagnostics - Pressure Zone B
- Air Conditioning (A/C) Diagnostics - Pressure Zone C
- Air Conditioning (A/C) Diagnostics - Pressure Zone D
- Heating Performance Diagnostic
- Defrosting Insufficient
- High or Low Mode Control Effort
- High or Low Temperature Control Effort
- Noise Diagnosis - Blower Motor
- Noise Diagnosis - Air Conditioning (A/C) System
- Noise Diagnosis - HVAC Module
- Odor Diagnosis
- Repair Instructions
- Odor Correction
- Refrigerant Recovery and Recharging
- Flushing
- Compressor Oil Balancing
- Compressor Replacement
- Compressor Pressure Relief Valve Removal (CVC-Direct Mount)
- Compressor Pressure Relief Valve Install (CVC - Direct Mount)
- Compressor Clutch Assembly Replacement
- Sealing Washer Replacement
- O-Ring Replacement
- Compressor Hose Assembly Replacement (L61)
- Evaporator Tube Replacement
- Accumulator Tube Replacement
- Air Conditioning (A/C) Refrigerant Filter Installation
- Air Conditioning (A/C) Refrigerant Filter Replacement
- Expansion (Orifice) Tube Replacement
- Compressor Relay Replacement
- Service Ports Replacement
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement
- Condenser Replacement
- Accumulator Replacement (L61)
- HVAC Module Assembly Replacement
- Evaporator Core Replacement
- Heater Hose Replacement - Inlet (L61)
- Heater Hose Replacement - Outlet (L61)
- Blower Motor Relay Replacement
- Blower Motor Resistor Assembly Replacement
- Blower Motor Replacement
- Air Distributor Duct Replacement (Chevrolet)
- Air Distributor Duct Replacement (Pontiac)
- Deflector Replacement - Instrument Panel Air (Chevrolet)
- Deflector Replacement - Instrument Panel Air (Pontiac)
- Air Outlet Replacement - Floor
- Air Outlet Replacement - Rear Floor
- Air Outlet Duct Replacement - Defroster (Chevrolet)
- Air Outlet Duct Replacement - Defroster (Pontiac)
- Air Outlet Duct Replacement - Right Defogger (Chevrolet)
- Air Outlet Duct Replacement - Right Defogger (Pontiac)
- Air Outlet Duct Replacement - Left Defogger (Chevrolet)
- Air Outlet Duct Replacement - Left Defogger (Pontiac)
- Air Temperature Door Replacement
- Defroster Door Replacement
- Mode Door Replacement
- Recirculation Door Replacement
- Heater Door Replacement
- Heater Core Replacement
- Special Tools and Equipment