Section 968 (Body Equipment - Repair - F31)
WARNING: This page does not describe the selected car, but rather 6 other vehicles, including the 2016 BMW 328i xDrive, 2016 BMW 328d xDrive, 2015 BMW 328i xDrive, 2015 BMW 328d xDrive, and 2014 BMW 328i xDrive. However, it is still accessible from the selected car via links, so may be relevant.
- General
- 51 00... Notes on component bonding adhesive tape
- 51 00... Notes on fitting window guide seals
- 51 00... Overview of consumables
- 41 00... Replace bolts
- 41 00... Replacing blind rivets
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 51 00... Safety instructions for working on cars with airbag systems
- 51 00... Service position of engine compartment lid
- Front Bumper
- 51 11... Attaching/replacing support for number plate (using laser)
- 51 11... Punch overview holes in bumper panel
- 51 11... Punching holes in the bumper panel
- 51 11 183 Removing and installing (replacing) ornamental grille for bumper panel (side)
- 51 11 156 Removing and installing front bumper panel
- 51 11... Removing and installing/replacing holder for PDC/PMA/side view camera on left or right
- 51 11 770 Removing and installing/replacing left or right deformation element for front bumper panel
- 51 11 180 Removing and installing/replacing ornamental grille for bumper panel (center)
- 51 11 050 Removing and installing/replacing support for front bumper panel
- 51 11 060 Removing and installing/replacing support for front lower bumper panel
- 51 11 157 Replace bumper panel, front
- 51 11 158 Replacing base plate for number/license plate
- 51 11 773 Replacing front lower left or right deformation element
- Rear Bumper
- 51 00... Overview of consumables
- 51 12 156 Removing and installing (replacing) rear bumper panel
- 51 12 825 Removing and installing/replacing guide for rear center bumper panel
- 51 12 828 Removing and installing/replacing guide for the bumper panel, rear left or right
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- Trim, Covers, Handle Trim
- 51 13 316 Removing and installing or replacing trim strip on roof gutter at left or right
- 51 13 319 Removing and installing or replacing trim strip on roof gutter strip at rear left or right
- 51 13... Removing and installing/replacing cover in engine compartment on left or right
- 51 13 116 Removing and installing/replacing cowl panel cover
- 51 13 001 Removing and installing/replacing front radiator grille, middle left or right
- 51 13... Removing and installing/replacing partition wall attachment, right
- 51 13 307 Removing and installing/replacing the railing on the left or right (version with panorama glass roof)
- 51 13 280 Removing and installing/replacing trim strip on roof frame at left or right
- 51 13 061 Replacing wheel arch trim on front left or right side panel (Japanese national-market version)
- BMW Emblems, Model Emblems
- Mirrors/Covers/Ashtrays/Shelves/Trays
- 51 16... Calibrating the compass on the inside mirror
- 51 16 145 Removing and installing (replacing) decorative trim at center console
- 51 16 142 Removing and installing (replacing) insert in center armrest storage compartment
- 51 16... Removing and installing grab handle holder
- 51 16 480 Removing and installing or replacing front grab handle
- 51 16 045 Removing and installing or replacing retaining ring on left or right exterior mirror
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 145 Removing and installing the decorative trim to center console
- 51 16 206 Removing and installing/replacing center armrest
- 51 16 160 Removing and installing/replacing center console cover
- 51 16 165 Removing and installing/replacing complete center console
- 51 16 041 Removing and installing/replacing cover cap on left or right exterior mirror
- 51 16 210 Removing and installing/replacing cover for selector lever
- 51 16 383 Removing and installing/replacing damper for glove box
- 51 16 355 Removing and installing/replacing driver's side fold-down compartment
- 51 16 365 Removing and installing/replacing glove box cover
- 61 31 334 Removing and installing/replacing grip trim for gear selector switch
- 51 16 040 Removing and installing/replacing housing on left or right exterior mirror
- 51 16 063 Removing and installing/replacing interior mirror (as of 07/2011)
- 51 16 063 Removing and installing/replacing interior mirror (overview)
- 51 16 001 Removing and installing/replacing mirror on left or right front door
- 51 16 163 Removing and installing/replacing rear center console cover
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 366 Removing and installing/replacing right glove box with housing
- 51 16 400 Removing and installing/replacing roller sunblind on fixed side window of left or right rear door
- 51 16 405 Removing and installing/replacing roller sunblind on side window of left or right rear door
- 51 16 158 Removing and installing/replacing side cover on center console
- 51 16 210 Removing and installing/replacing the trim for the selector lever
- 51 16 156 Replacing ashtray insert
- 51 16 026 Replacing mirror glass
- 51 16 160 Uninstall and install trim center console
- Lids
- Front Door Locks, Handles, Fittings
- 51 21 004 Adjusting front left or right lock striker
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 170 Removing and installing or replacing outer door handle from left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 181 Removing and installing/renewing cover on outer door handle with lock barrel
- 51 21 330 Removing and installing/renewing weather strip on inner front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 233 Removing and installing/replacing Bowden cable for outer door handle on left or right front door
- 51 21 140 Removing and installing/replacing complete lock barrel in left or right front door
- 51 21 180 Removing and installing/replacing cover on outside door handle
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 280 Removing and installing/replacing door stop on left or right front door
- 51 21 125 Removing and installing/replacing support for left or right outer door handle with lock barrel
- 51 21 126 Removing and installing/replacing support for left or right outer door handle without lock barrel
- 51 21... Removing weather strip with special tool 00 9 324 at front or rear
- 51 21 003 Replacing door detent (lock striker), front left or right
- Rear Door Locks, Handles, Fittings
- 51 22 004 Adjusting rear left or right door lock striker
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 233 Removing and installing/replacing Bowden cable for outer door handle on left or right rear door
- 51 22 180 Removing and installing/replacing cover on outer door handle, left or right
- 51 22 090 Removing and installing/replacing door lock in left or right rear door
- 51 22 280 Removing and installing/replacing door stop on left or right rear door
- 51 22 225 Removing and installing/replacing inside door opener of rear left or right door
- 51 22 170 Removing and installing/replacing outer door handle on left or right rear door
- 51 22 126 Removing and installing/replacing support for outer door handle on left or right rear door
- 51 22 330 Removing and installing/replacing weather strip on inside rear door
- 51 22 300 Removing and installing/replacing weather strip on outside of rear door
- 51 21... Removing weather strip with special tool 00 9 324 at front or rear
- 51 22 001 Replacing door detent (lock striker), rear left or right
- Hood Latch, Locks
- 51 23 004 Adjusting engine compartment lid catch
- 51 23 131 Adjusting left or right striker on engine compartment lid
- 51 23... Adjusting/replacing bump stops
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 265 Removing and installing/replacing left or right gas pressure spring for engine compartment lid
- 51 23 211 Removing and installing/replacing pull cable for hood/bonnet locks at front
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- 51 23... Removing/installing ball sockets with clip
- Trunk Latch, Locks
- 51 24... Adjusting opening height of automatic luggage compartment lid actuation (automatic tailgate activation)
- 51 24 004 Adjusting rear lid lock
- 51 23... Adjusting/replacing bump stops
- 51 24 300 Removing and installing or replacing left or right gas pressure spring for tailgate
- 51 24 133 Removing and installing/replacing drive for Automatic Soft Close drive on tailgate
- 51 24 350 Removing and installing/replacing left spindle drive (automatic tailgate activation)
- 51 24 105 Removing and installing/replacing rear lid lock
- 51 24 140 Removing and installing/replacing rear window locking
- 51 24 351 Removing and installing/replacing right spindle drive (automatic tailgate activation)
- 51 24 130 Removing and installing/replacing striker for tailgate lock
- 51 23... Removing/installing ball sockets with clip
- 51 24 147 Replace button for tailgate activation
- Front And Rear Window
- 51 31 201 Adjusting rear window
- 51 31... General procedure when dismantling/installing bonded window glass
- 51 31... Instructions for repairing stone chip damage on laminated safety glass (clear and tinted)
- 51 31... Materials for bonding window
- 62 30... Notes on head-up display
- 51 31... Notes on window bonding repair kit
- 61 35... Overview, rain sensor (additional work when replacing the windscreen/sensor replacement)
- 51 31... Remove windscreen with "Roll Out 2000"
- 51 31 030 Removing and installing or replacing left or right gutter strip along windscreen
- 51 31 000 Removing and installing windscreen
- 51 31 245 Removing and installing/renewing gasket for rear window
- 51 31 200 Removing and installing/replacing rear window
- 51 31 021 Removing and installing/replacing windscreen rubber surround
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31 015 Repairing damage to windscreen caused by stone chips (clear and tinted laminated safety glass)
- 51 31 011 Replace windscreen
- 51 31 221 Replacing rear window (rear window broken)
- 51 31... Window glass removal with wire pull handle
- Front Manually Operated Windows
- 51 32 170 Removing and installing/replacing door window glass, front left or right
- 51 32 160 Removing and installing/replacing inner cover on left or right window frame
- 51 32 420 Removing and installing/replacing trim cover on front door window frame, left or right
- 51 32 211 Replacing front left or right rubber guide for left or right door window
- Front Electrically Operated Windows
- Rear Manually Operated Windows
- 51 34 190 Removing and installing rear left or right fixed door window in rear window frame
- 51 34 420 Removing and installing/replacing cover on window frame of rear door (front), left or right
- 51 34 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 34 191 Replacing left or right fixed door window in rear window frame
- 51 34 426 Replacing left or right window guide bar cover
- 51 34 171 Replacing rear left or right door window
- 51 34 211 Replacing rubber seal for rear left or right door window
- Rear Electrically Operated Windows
- Hinged Window
- Electrical Power Windows, Body
- Front Door Trim Panel With Arm Rest
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 41 000 Removing and installing left or right front door trim panel
- 51 41 060 Removing and installing or replacing armrest on door trim panel, front left or right
- 51 41 017 Removing and installing or replacing cover on door handle, front left or right
- 51 41 019 Removing and installing or replacing door handle on door trim, front left or right
- 51 41 090 Removing and installing or replacing lighting strip on door trim, front left or right
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 41... Removing and installing/replacing switch cover on left or right front door trim panel
- 51 41 001 Replacing left or right front door trim panel
- 51 41 018 Replacing speaker cover on left or right front door trim panel
- Rear Door Trim Panel With Arm Rest
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 42 000 Remove and install left or right rear door trim panel
- 51 42 000 Removing and attaching the left or right rear door trim panel
- 51 42 019 Removing and installing or replacing door handle on door trim, rear left or right
- 51 42 090 Removing and installing or replacing light strip on left or right rear door trim panel
- 51 42 060 Removing and installing/replacing armrest in rear door, left or right
- 51 42 017 Removing and installing/replacing cover on door handle, rear left or right
- 51 48 070 Removing and installing/replacing sound insulation on left or right rear door
- 51 42 001 Replacing left or right rear door trim panel
- 51 42 018 Replacing speaker cover on rear left or right door trim panel
- Side Covering With Armrests
- 51 43 150 Removing and installing or replacing trim for left or right door pillar (bottom)
- 51 43 201 Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- 51 43 251 Removing and installing or replacing trim panel for left or right rear roof pillar (C-pillar)
- 51 43 148 Removing and installing or replacing trim panel on left or right door post (top)
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- 51 43 320 Removing and installing/replacing trim panel for D-pillar left (right)
- Roof Trim Panel
- Instrument Cluster Trim Panel
- 51 45 380 Removing and installing (replacing) right decorative strip on dashboard
- 51 45 370 Removing and installing decorative strip on left dashboard
- 51 45 030 Removing and installing instrument panel trim
- 51 45 075 Removing and installing/replacing carrier for instrument panel
- 51 45 195 Removing and installing/replacing instrument panel trim, bottom right
- 51 45... Removing and installing/replacing side panel on dashboard on left or right
- 51 45 184 Removing and installing/replacing trim panel for pedal mechanism
- 51 45 371 Replace the decorative strip on the dashboard, left
- 51 45 031 Replacing instrument panel trim
- Parcel Shelf Trim Panel/Roller Sun Blind
- Floor-Luggage Compartment-Engine Compartment Trim Panels
- 51 47 315 Removing and installing/replacing front carpet for passenger compartment
- 51 47 490 Removing and installing/replacing front underbody protection
- 51 47 440 Removing and installing or replacing rear carpet on seat pan
- 51 71 017 Removing and installing/replacing (left or right) underbody panelling
- 51 47 072 Removing and installing/replacing finishing strip on rear left or right entrance (outer)
- 51 47 173 Removing and installing/replacing flap in luggage compartment trim on left
- 51 47 000 Removing and installing/replacing front (inside) left or right door sill cover strip
- 51 47 480 Removing and installing/replacing left (right) capping trim panel
- 51 47 152 Removing and installing/replacing left luggage compartment wheel arch panel
- 51 75 010 Removing and installing/replacing left or right steering assembly cover
- 51 75... Removing and installing/replacing left or right tank cover
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 220 Removing and installing/replacing luggage compartment trim panel on side wall, right
- 51 47 030 Removing and installing/replacing rear (inside) left or right door sill cover strip
- 51 47 491 Removing and installing/replacing rear underbody protection
- 51 47 162 Removing and installing/replacing right luggage compartment wheel arch panel
- 51 47 065 Removing and installing/replacing rocker panel trim on front left or right entrance (outer)
- 51 47 145 Removing and installing/replacing roller cover for luggage compartment
- 51 47... Removing and installing/replacing storage compartment for first-aid kit and warning triangle
- 51 47 490 Removing and installing/replacing underbody protection (front)
- 51 75 030 Removing or installing/replacing the sound insulation of the upper part of the bulkhead
- 51 47 810 Replace one holder for adaptive mount
- Front Lid Insulation Lining
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 48 001 Removing and installing/replacing insulation lining on engine hood/bonnet
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 48 070 Removing and installing/replacing sound insulation on left or right rear door
- Rear Lid Trim Panel
- 51 49 000 Removing and installing or replacing trim for rear lid
- 51 49 003 Removing and installing/replacing cover for rear window frame on left or right
- 51 49 017 Removing and installing/replacing left or right rear window frame trim panel
- 51 49 013 Removing and installing/replacing the cover for the rear window frame at top
- 51 49 002 Removing and installing/replacing trim panel for rear window frame, top
- Reinforcement, Body
- Front Panel, Front End
- Gaskets/Seals, Loose Body Components
- 51 71 447 Removing and installing or replacing trim panel for cover on left or right side member
- 51 71 017 Removing and installing/replacing (left or right) underbody panelling
- 51 64 012 Removing and installing/replacing V-support
- 51 13... Removing and installing/replacing cover in engine compartment on left or right
- 51 13 116 Removing and installing/replacing cowl panel cover
- 51 71 038 Removing and installing/replacing front left or right wheel arch cover (front section)
- 51 71 039 Removing and installing/replacing front left or right wheel arch cover (rear section)
- 51 71 482 Removing and installing/replacing left or right tension strut
- 51 13... Removing and installing/replacing partition wall attachment, right
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 412 Removing and installing/replacing rear spoiler
- 51 71 373 Removing and installing/replacing trailing link on spring strut dome
- 51 75 030 Removing or installing/replacing the sound insulation of the upper part of the bulkhead
- 51 71 115 Replacing seal on left or right front door
- 51 71 215 Replacing sealing on left or right rear door
- 51 72... Sealing installation
- 51 71... Sticking templates for door seal to inner door panel (door seal removed)
- MUCKET For Doors
- Underbody Panelling