Section 9 (Body Equipment - Repair (R61) -- Cooper Paceman)
WARNING: This page is about a different car, the 2016 MINI Cooper Paceman, 2015 MINI Cooper Paceman, 2014 MINI Cooper Paceman, and 2013 MINI Cooper. However, it is still accessible from the selected car via links, so may be relevant.
- Safety And General Information
- 51 00... Safety information for working on vehicles with airbag systems
- 00 Safety information for working on vehicles with automatic engine start-stop function (MSA)
- 51 00... Notes on component bonding with adhesive tape
- 51 00... Notes on installing rubber window seals
- 41 00... Replacing bolts
- 41 00... Replacing blind rivets
- 51 00... Overview of consumables
- Front Bumper
- 51 11... Overview of front bumper
- 51 11 152 Remove and install/replace the center spoiler on bumper panel
- 51 11 156 Removing and installing front bumper panel
- 51 11 180 Removing and installing/replacing ornamental grille in bumper panel
- 51 11 182 Removing and installing/replacing ornamental grille in bumper panel at top front
- 51 11 050 Removing and installing/replacing support for front bumper panel
- 51 11 157 Replace bumper panel, front
- Rear Bumper
- 51 12 156 Removing and installing rear bumper panel
- 51 12 825 Removing and installing/replacing guide for rear center bumper
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- 51 12 157 Replace rear bumper panel
- 51 12 070 Replace the center spoiler on rear bumper panel
- 51 12 801 Replacing holder for rear bumper at left or right
- Trim, Covers, Handle Trim
- 51 13 305 Removing and installing/replacing left or right roof railing
- 51 13 102 Removing and installing/replacing cover on front left or right wheel arch
- 51 13 095 Removing and installing/replacing cover on front side wall left or right
- 51 13 375 Removing and installing/replacing cover on left or right rear roof pillar (D-pillar)
- 51 13 105 Removing and installing/replacing cover on wheel arch
- 51 13 000 Removing and installing/replacing front grille center section
- 51 13 091 Removing and installing/replacing front side panel trim strip, left or right
- 51 13 123 Removing and installing/replacing left cowl panel cover
- 51 13 301 Removing and installing/replacing left or right roof strip
- 51 13 124 Removing and installing/replacing right cowl panel cover
- 51 13 015 Removing and installing/replacing trim ring for left or right headlight
- 51 13 085 Removing and installing/replacing trim strip on engine hood/bonnet (cowl panel)
- Emblems, Model Emblems
- 51 14... General notes for labelling with adhesive films
- 51 14... Instructions for attaching number/letter designation combination
- 51 14 002 Removing and installing/replacing front MINI badge
- 51 14 012 Removing and installing/replacing rear MINI plate
- 51 14 110 Removing and installing/replacing rear model designation
- Mirrors/Covers/Ashtrays/Shelves/Trays
- 51 16... Calibrating the compass on the inside mirror
- 51 16... Overview of center console
- 51 45.. Overview of dashboard
- 51 16 265 Remove and install/replace rear trim on rear console
- 51 16 254 Removing and installing/replacing the rail (short)
- 51 16 292 Remove and install or replace the rear rail
- 51 16 480 Removing and installing or replacing front grab handle
- 51 16 060 Removing and installing or replacing inside mirror
- 51 16 000 Removing and installing or replacing mirror on left or right front door
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 366 Removing and installing right glove box with housing
- 51 16... Removing and installing the lid on the rear center console cover
- 51 16 206 Removing and installing/replacing center armrest
- 51 16 160 Removing and installing/replacing center console cover
- 51 16 165 Removing and installing/replacing complete center console
- 51 16... Removing and installing/replacing decorative ring on gearshift lever cover
- 51 16 202 Removing and installing/replacing front cupholder
- 51 16 365 Removing and installing/replacing glove box cover
- 51 16... Removing and installing/replacing holder for inside mirror
- 51 16 041 Removing and installing/replacing protective cap on left or right exterior mirror
- 51 16 274 Removing and installing/replacing rear center console
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 200 Removing and installing/replacing storage compartment
- 51 16 254 Removing and installing/replacing the rail (long)
- 51 16 026 Replacing mirror glass
- Front Door Locks, Handles, Fittings
- 51 21 004 Adjusting front left or right lock striker
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 170 Removing and installing or replacing outer door handle from left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 330 Removing and installing/renewing weather strip on inner front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 280 Removing and installing/replacing door stop on left or right front door
- 51 21 130 Removing and installing/replacing left or right front door lock
- 51 21... Removing weather strip with special tool 00 9 324 at front or rear
- 51 21 003 Replacing door detent (lock striker), front left or right
- Hood Latch, Locks
- 51 23 004 Adjusting engine compartment lid catch
- 51 23... Adjusting/replacing bump stops
- 51 23 200 Remove, install/replace lever with console for engine compartment lid catch
- 51 23 160 Removing and installing/replacing arrester hook on engine hood
- 51 23 212 Removing and installing/replacing cable for front engine hood/bonnet locks (in passenger compartment)
- 51 23 215 Removing and installing/replacing cable for front hood/bonnet locks (in engine compartment) on right and left
- 51 23 110 Removing and installing/replacing left hood/bonnet lock
- 51 23 265 Removing and installing/replacing left or right gas pressure spring for engine compartment lid
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- Trunk Latch, Locks
- 51 24 004 Adjusting tailgate lock
- 51 23... Adjusting/replacing bump stops
- 51 24 300 Removing and installing or replacing left or right gas pressure spring for tailgate
- 51 24 146 Removing and installing/replacing button for rear lid actuation
- 51 24 130 Removing and installing/replacing striker for tailgate lock
- 51 24 100 Removing and installing/replacing tailgate lock
- Front And Rear Window
- 61 35... Overview, rain sensor (additional work when replacing the windscreen/sensor replacement)
- 51 31 015 Repairing damage to windscreens caused by pitting (stone chips) (clear and tinted laminated safety glass)
- 51 31... General procedure for the disassembly and installation of bonded window glass
- 51 31... Notes on window bonding repair kit
- 51 31... Remove windscreen with "Roll Out 2000"
- 51 31 000 Removing and installing/renewing windscreen
- 51 31 284 Removing and installing/replacing lower cover on rear window
- 51 31 200 Removing and installing/replacing rear window
- 51 31 045 Removing and installing/replacing trim cover on A-pillar (outer), left or right
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31... Window glass removal with wire pull handle
- Front Windows
- Power Window Regulator
- Hinged Window
- Front Door Trim Panel With Arm Rest
- 51 48... Notes for bonding sound insulation (SI), doors
- 51 48 060 Removing and installing/replacing sound insulation in left or right front door
- 51 41 110 Remove and install/replace the driver's side handle recess (front passenger side)
- 51 41 000 Removing and installing left or right front door trim panel
- 51 41... Removing and installing/replacing front (inside) left or right door opener cover
- 51 41 001 Replacing left or right front door trim panel
- Side Covering With Armrests
- 51 43 002 Removing and installing (replacing) rear left or right side trim panel
- 51 43 251 Removing and installing or replacing trim panel for left or right rear roof pillar (C-pillar)
- 51 43 201 Removing and installing or replacing trim panel for roof pillar at front (A-pillar), left or right
- 51 43 148 Removing and installing or replacing trim panel on left or right door post (top)
- 51 43 060 Removing and installing/replacing armrest on rear left or right side trim panel
- Roof Trim Panel
- 51 44 002 Removing and installing (replacing) headlining (on version without panorama glass roof)
- 51 44 013 Removing and installing (replacing) headlining (with panorama glass roof)
- 51 44 152 Removing and installing/replacing front roofliner cover
- 51 44 156 Removing and installing/replacing rear roofliner cover
- Instrument Cluster Trim Panel
- 51 45.. Overview of dashboard
- 51 45 180 Removing and installing (replacing) instrument panel trim, bottom left
- 51 45 072 Removing and installing dashboard completely with support
- 51 45 050 Removing and installing dashboard upper section trim
- 51 45 430 Removing and installing/replacing air outlet vent cover on left side
- 51 45 432 Removing and installing/replacing air outlet vent cover on right side
- 51 45... Removing and installing/replacing bottom left dashboard trim panel
- 51 45 435 Removing and installing/replacing cover for instruments
- 51 45 181 Removing and installing/replacing for lower instrument panel trim (only US incl. knee airbag)
- 51 45 181 Removing and installing/replacing instrument panel trim, bottom right
- 51 45... Removing and installing/replacing lid of air outlet vent cover, left or right
- 51 45 076 Replacing carrier for dashboard
- 51 45 321 Replacing decorative trim on dashboard - driver's side- on left
- 51 45 323 Replacing decorative trim on dashboard - driver's side- on right
- 51 45 265 Replacing instrument panel trim panel
- 51 45 331 Replacing right decorative trim on dashboard
- 51 45 051 Replacing upper part of dashboard trim panel
- Parcel Shelf Trim Panel/Roller Sun Blind
- Floor/Luggage Compartment/Engine Compartment Trim Panels
- 51 47 490 Removing and installing/replacing front underbody protection
- 51 47 065 Removing and installing/replacing cover at front left or right entrance
- 51 47 000 Removing and installing/replacing front left or right door sill cover strip
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 47 156 Removing and installing/replacing left or right capping in luggage compartment
- 51 75 001 Removing and installing/replacing left or right underbody cover
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 030 Removing and installing/replacing rear left door sill cover strip
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch panel
- Front Lid Insulation Lining
- Rear Lid Trim Panel
- Gaskets/Seals, Loose Body Components
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71... Removing and installing/replacing heater end panel
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 412 Removing and installing/replacing rear spoiler
- 51 71 447 Removing and installing/replacing trim panel for cover on frame side member (left or right)
- MUCKET For Doors