Section 21 (Automatic Transmission - 5R110W (TORQSHIFT(R)) -- F450 & F550 Super Duty)
WARNING: This page is about a different car, the 2012 Ford F550 Super Duty and 2012 Ford F450 Super Duty. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description & Operation
- Transmission Description
- Identification Tags
- Range Selection
- Shift Patterns
- Bushings, Bearing & Thrust Washer Locator
- Seals, Rings & Gasket Locator
- Main Components & Functions
- Torque Converter
- Geartrain
- Apply Components
- Hydraulic System
- Transmission Electronic Control System
- Electronic System Description
- Output Shaft Speed (OSS) Sensor
- Engine Coolant Temperature (ECT) Sensor
- Intake Air Temperature (IAT) Sensor
- Accelerator Pedal Position (APP) Sensor
- TSS Sensor & Intermediate Shaft Speed Sensor
- Brake Pedal Position (BPP) Switch
- Powertrain Control Module (PCM)
- Transmission Control Switch (TCS)
- Transmission Control Indicator Lamp (TCIL)
- Four-Wheel Drive (4WD) Low Switch
- Transmission Solenoid Body Assembly
- Transmission Fluid Temperature (TFT) Sensor
- Pressure Control Solenoid A (PCA)
- Torque Converter Clutch (TCC) Solenoid
- Shift Solenoid Pressure Control Solenoids
- Line Pressure Relief Valve
- Transmission Range (TR) Sensor Assembly
- Power Take-Off (PTO)
- Diagnosis & Testing
- Notes
- Preliminary Inspection
- Road Testing Vehicle
- Shift Point Road Test
- Visual Inspection
- Diagnostics
- Transmission Drive Cycle Test
- Diagnostic Parameters Identification (PID) Chart
- Diagnostic Trouble Code (DTC) Charts
- Transmission Connector Layouts
- Internal Transmission Harness Connector/Component Locator
- Transmission Vehicle Harness - C1385
- Transmission Internal Harness Connector
- Internal Harness Transmission Range (TR) Sensor Connector - Tan
- Internal Harness SSPC-x Solenoid Connector - Tan
- Output Shaft Speed (OSS) Sensor - C193
- Turbine Shaft Speed (TSS) & Intermediate Shaft Speed Sensor - C1387
- Pcm - C175T
- Pinpoint Tests - OSC Equipped Vehicle
- Notes
- Solenoid Pre-Diagnosis
- Pinpoint Tests
- Notes
- Pinpoint Test A: Control Solenoids
- Pinpoint Test B: Transmission Fluid Temperature (TFT) Sensor
- Pinpoint Test C: Transmission Range Sensor (TRS)
- Pinpoint Test D: Turbine Shaft Speed (TSS), Intermediate Shaft Speed & Output Shaft Speed (OSS) Sensors
- Pinpoint Test E: Pressure Control (Pc-A) (Line Pressure) Solenoid
- Special Testing Procedures
- Leakage Inspection
- Transmission Fluid Cooler
- Diagnosis By Symptom
- General Procedures
- In-Vehicle Repair
- Fluid Pan, Gasket & Filter
- Transmission Filler Tube
- Solenoid Body Assembly
- Speed Sensor Assembly/Turbine Shaft Speed (TSS) Sensor & Intermediate Shaft Speed Sensor
- Output Shaft Speed (OSS) Sensor
- Extension Housing Seal
- Extension Housing Gasket
- Transmission Fluid Temperature (TFT) Sensor
- Internal Harness Service
- Shift Solenoids (SS)
- Manual Control Lever Shaft & Seal
- Line Pressure Control Solenoid - PC-A
- Transmission Range (TR) Sensor
- Park System
- Transmission Support Insulator
- Removal
- Disassembly
- Disassembly & Assembly Of Subassemblies
- Assembly
- Installation