Section 4 (Hybrid/EV Energy Storage System)
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Schematic Wiring Diagrams
- Component Locator
- Diagnostic Information and Procedures
- High Voltage Safety
- High Voltage Disabling
- High Voltage Enabling
- EL-48571 High Voltage Battery Pin Out Box Reference
- High Voltage Connectors
- DTC P0651, P0697, P06A3 or P06D2: 5V Reference (Hybrid/EV Powertrain Control Module 2)
- DTC P0A0C or P0A0D: High Voltage System Interlock Circuit
- DTC P0A7F: Hybrid/EV Battery Pack Life
- DTC P0AA1, P0AA4, P0AD9, P0ADB-P0ADD, P0ADF, P0AE0, P0AE4, P0AE6, P0AE7 or P1EC0: Hybrid/EV Battery Contactor Circuit
- DTC P0AA6: Hybrid/EV Battery Voltage System Isolation Lost
- DTC P0AA7-P0AAA, P1E0C or P1E0D: Hybrid/EV Battery Voltage Isolation Sensing Circuit
- DTC P0ABB, P0ABC or P0ABD: Hybrid/EV Battery Voltage Sensor
- DTC P0AC1 or P0AC2: Hybrid/EV Battery Current Sensor Circuit
- DTC P0AFA or P0AFB: Hybrid/EV Battery System Voltage
- DTC P0B3B-P0BBB, P1B16-P1B2D, P1B45-P1BD4 or P1E4C-P1E7B: Hybrid/EV Battery
- DTC P0C78 or P3061: Hybrid/EV Battery System Precharge Time Too Long/Precharge High Current
- DTC P1E92, P1E93, P1E98, P1E99, P1E9E, P1E9F, P1EA4, P1EA5, P1FC3-P1FC6, P1FC9-P1FCC, P1FD5-P1FDC, P1FDF-P1FE6, P1FE9-P1FEF or P1FF0: Hybrid/EV Battery Interface Control Module
- DTC P1EAB or P1EAC: Battery Energy Control Module Hybrid-EV Battery Cell High Voltage/Hybrid-EV Battery Cell Overvoltage Signal Circuit Performance
- DTC P1EAD-P1EB0: Hybrid/EV Interface Control Module Cell Overvoltage Signal Circuit
- DTC P1EBA: Hybrid/EV Battery Low Resolution Current Sensor Exceeded Learning Limit
- DTC P1F17: System Isolation / Impact Sensor Fault - Hybrid/EV Battery System Contactors Open
- DTC P3240-P3244, P3246, P3248 or P324A: Hybrid/EV Battery Interface Control Module Cell Overvoltage
- DTC P3245, P3247, P3249 or P324B: Hybrid/EV Battery Interface Control Module Cell Overvoltage Signal Circuit
- Loss of Isolation on the High Voltage Main Bus
- Hybrid/EV Battery Voltage Present
- Troubleshooting With an Insulation Multimeter
- Repair Instructions
- High Voltage System Inspection
- Drive Motor Battery High Voltage Manual Disconnect Lever Replacement
- High Voltage Battery High Voltage Manual Disconnect Connector Replacement
- High Voltage Battery Cover Replacement
- High Voltage Battery Tray Replacement
- Hybrid Powertrain Control Module 2 Replacement
- 300-Volt Battery Positive and Negative Cable Replacement
- High Voltage Battery Positive Cable Replacement (A/C Compressor Cable)
- High Voltage Battery Positive Cable Replacement (High Voltage Battery to APM Module)
- Battery Hold Down Retainer Replacement (Left Side Panel)
- Battery Hold Down Retainer Replacement (Right Side Panel)
- Cell Battery Cooling Manifold Replacement
- Cell Battery Module Replacement (Cell Battery 7)
- Cell Battery Module Replacement (Cell Battery 8)
- Cell Battery Module Replacement (Cell Battery 6)
- Cell Battery Module Replacement (Cell Battery 5)
- Cell Battery Module Replacement (Cell Battery 4)
- Cell Battery Module Replacement (Cell Battery 3)
- Cell Battery Module Replacement (Cell Battery 2)
- Cell Battery Module Replacement (Cell Battery 1)
- High Voltage Battery Replacement and Shipping Preparation
- High Voltage Battery Disconnect Relay Replacement
- High Voltage Battery Cover Reinforcement Replacement
- High Voltage Battery Tray Reinforcement Replacement (Left Side)
- High Voltage Battery Tray Reinforcement Replacement (Right Side)
- High Voltage Battery Positive and Negative Cable Cover Replacement
- Cell Battery Vent Tube Replacement
- Battery Cover Replacement (Back Panel)
- Battery Cover Replacement (Front Panel)
- Auxiliary Battery Cable Replacement
- Clear Secured High Voltage DTCs
- Hybrid/EV Battery Cell Balancing
- Hybrid/EV Battery Low State of Charge Recovery
- Description and Operation
- Drive Motor Battery System Description
- Notes
- High Voltage Battery Assembly
- Hybrid/EV Battery Sections
- Hybrid/EV Powertrain Control Module 2
- High Voltage Contactors
- High Voltage Isolation
- 12 V Output
- Main Contactors, Pre-Charge Contactor and Pre-Charge Resistor
- High Voltage Battery Current Sensor
- High Voltage Battery Assembly High Voltage Manual Disconnect Lever and Fuse
- Vehicle Collision Detection
- Hybrid/EV System High Voltage Isolation Description
- Drive Motor Battery System Description
- Special Tools and Equipment