Section 1233 (Heating, Ventilation And Air Conditioning)
WARNING: This page is about a different car, the 2003 Pontiac Grand Prix. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Heating, Ventilation and Air Conditioning
- Leak Testing
- Air Conditioning (A/C) System Performance Test
- Air Conditioning (A/C) Diagnostics - Pressure Zone A
- Air Conditioning (A/C) Diagnostics - Pressure Zone B
- Air Conditioning (A/C) Diagnostics - Pressure Zone C
- Air Conditioning (A/C) Diagnostics - Pressure Zone D
- Heating Performance Diagnostic
- Defrosting Insufficient
- Noise Diagnosis - Blower Motor
- Noise Diagnosis - Air Conditioning (A/C) System
- Noise Diagnosis - HVAC Module
- Odor Diagnosis
- Repair Instructions
- Odor Correction
- Refrigerant Recovery and Recharging
- Flushing
- Compressor Oil Balancing
- Compressor Replacement (3.1L)
- Compressor Replacement (3.8L)
- Compressor Clutch Plate and Hub Assembly Removal (V5 - Direct Mount)
- Compressor Clutch Plate and Hub Assembly Removal (V5 - Conventional Mount)
- Clutch Rotor and/or Bearing Removal (V5 - Direct Mount)
- Clutch Rotor and/or Bearing Removal (V5 - Conventional Mount)
- Compressor Clutch Coil Removal (V5 - Direct Mount)
- Compressor Clutch Coil Removal (V5 - Conventional Mount)
- Compressor Control Valve Assembly Removal (V5 - Direct Mount)
- Compressor Control Valve Assembly Removal (V5 - Conventional Mount)
- Compressor Pressure Relief Valve Removal (V5 - Direct Mount)
- Compressor Pressure Relief Valve Removal (V5 - Conventional Mount)
- Compressor Control Switches Removal (V5 - Conventional Mount)
- Compressor Control Valve Assembly Install (V5 - Direct Mount)
- Compressor Control Valve Assembly Install (V5 - Conventional Mount)
- Compressor Clutch Plate/Hub Assembly Install (V5 - Direct Mount)
- Compressor Clutch Plate/Hub Assembly Install (V5 - Conventional Mount)
- Clutch Rotor and/or Bearing Install (V5 - Direct Mount)
- Clutch Rotor and/or Bearing Install (V5 - Conventional Mount)
- Compressor Clutch Coil Install (V5 - Direct Mount)
- Compressor Clutch Coil Install (V5 - Conventional Mount)
- Compressor Pressure Relief Valve Install (V5 - Direct Mount)
- Compressor Pressure Relief Valve Install (V5 - Conventional Mount)
- Compressor Control Switches Install (V5 - Conventional Mount)
- Compressor Leak Testing (V5 - Conventional Mount)
- Compressor Leak Testing (V5 Direct Mount)
- Clutch Rotor and/or Bearing Replacement (V-5 Direct Mount)
- Clutch Rotor and/or Bearing Replacement (V-5 Conventional Mount)
- Sealing Washer Replacement
- O-Ring Replacement
- Compressor Hose Assembly Replacement (3.1L)
- Compressor Hose Assembly Replacement (3.8L)
- Condenser Tube Replacement
- Evaporator Tube Replacement
- Accumulator Tube Replacement
- Air Conditioning (A/C) Refrigerant Filter Installation
- Air Conditioning (A/C) Refrigerant Filter Replacement
- Expansion (Orifice) Tube Replacement
- Compressor Relay Replacement
- Service Ports Replacement
- Air Conditioning (A/C) Refrigerant Pressure Sensor Replacement
- Condenser Replacement
- Accumulator Replacement
- HVAC Module Assembly Replacement
- Evaporator Core Replacement
- Heater Hose Replacement - Inlet (3.1L)
- Heater Hose Replacement - Inlet (3.8L)
- Heater Hose Replacement - Outlet (3.1L)
- Heater Hose Replacement - Outlet (3.8L)
- Heater Pipe Replacement - Inlet (3.1L)
- Heater Pipe Adapter Replacement - Inlet (3.8L)
- Heater Pipe Adapter Replacement - Outlet (3.8L)
- Blower Motor Resistor Assembly Replacement
- Blower Motor Replacement
- Deflector Replacement - Instrument Panel Air - Center
- Deflector Replacement - Instrument Panel Air - Right
- Air Distribution Duct Replacement
- Air Outlet Replacement - Defroster
- Air Temperature Door Replacement - Right
- Air Temperature Door Replacement - Left
- Defroster Door Replacement
- Mode Door Replacement
- Vent Door Replacement
- Recirculation Door Replacement
- Heater Core Replacement
- Air Distribution Ducts Replacement - Auxiliary
- Special Tools and Equipment