Body Equipment -- Repair (G29)

51 00 General Information
- Notes on component bonding with adhesive tape
- Overview of consumables
- Safety instructions for working on vehicles with airbag systems
51 11 Bumper, Front
- 51 11 050 Removing and installing/replacing support for front bumper cover
  - Remove the support for the front bumper cover at top
  - Installing the support for the front upper bumper cover
- 51 11 060 Removing and installing/replacing support for front lower bumper cover
  - Remove support for bumper cover at front bottom
  - Install support for bumper cover at front bottom
- 51 11 156 Remove and install front bumper cover
  - Remove front bumper cover
  - Install front bumper cover
- 51 11 157 Replace bumper cover, front
- 51 11 158 Replacing the number plate baseplate for the license plate
  - Remove the number plate baseplate for the license plate
  - Install the number plate base for the license plate
- 51 11 180 Removing and installing/replacing ornamental grille in front bumper cover
- 51 11 181 Removing and mounting/replacing air inlet trim strip on ornamental grille for bumper cover at front
  - Removing the air inlet trim strip on the ornamental grille
  - Installing the air inlet trim strip on the ornamental grille
- 51 11 183 Removing and installing ornamental grille in bumper cover, front
  - Removing side ornamental grille
  - Installing the ornamental grille on the sides
- 51 11 300 removing/installing/replacing center trim
  - Removing the center bottom trim
  - Installing the center trim at the bottom
- 51 11 400 Removing and installing front end
  - Removing the front end
  - Installing the front end
51 12 Bumper, Rear
- 51 12 050 Removing and installing/replacing support for rear bumper panel
  - Removing the support for the rear bumper cover
  - Installing the support for the rear bumper cover
- 51 12 156 Removing and installing rear bumper panel
  - Remove rear bumper panel
  - Install rear bumper panel
- 51 12 157 Replace rear bumper panel
- 51 12 164 Removing and installing/replacing the rear bumper trim
  - Remove the rear bumper trim
  - Install the rear bumper trim
- 51 12 315 Removing and installing/replacing the rear diffuser
  - Removing the rear diffuser
  - Installing the rear diffuser
- 51 12 825 Removing and installing/replacing the bumper guide, rear, center (bumper cover disassembled)
  - Removing guide for rear center bumper cover
  - Installing guide for rear center bumper cover
- 51 12 831 Removing and installing/replacing the bumper guide, rear left (bumper cover disassembled)
  - Removing guide for rear left bumper cover
  - Installing guide for rear left bumper cover
- 51 12 832 Removing and installing/replacing the bumper guide, right rear (bumper cover disassembled)
  - Removing the guide for the right rear bumper cover
  - Installing the guide for the rear bumper cover at right
51 13 Exterior Body Trim Panels
- 51 13 001 Removing and installing/replacing front radiator grille on left or right
  - Remove the decorative front grill
  - Install front radiator grill
- 51 13 045 Removing and installing/replacing side panel trim on left or right
  - Remove the trim from the side panel
  - Install the trim on the side panel
- 51 13 061 Replacing front wheel arch trim on the side panel, left or right (if applicable)
- 51 13 063 Replacing rear quarter panel wheel arch trim, left or right (if applicable)
- 51 13 115 Removing and attaching/replacing windshield panel cover
  - Remove the cowl cover
  - Installing windshield panel cover
- 51 13 116 Removing and installing windshield panel cover
  - Remove the cowl cover
  - Installing windshield panel cover
- 51 13 128 Removing and installing/replacing trim on cowl panel at top (upper section)
  - Removing the top (upper section of the) windshield panel trim
  - Installing the top windshield panel trim (upper section)
- 51 13 129 Removing and installing/replacing trim on cowl panel at top (lower section)
  - Removing the top windshield panel trim (bottom part)
  - Installing the top windshield panel trim (bottom part)
- 51 13 402 Remove and install trunk lid handle
  - Removing the trunk lid handle
  - Installing the trunk lid handle
- 51 13 403 Replace trunk lid handle
51 14 Plates, Labels, Adhesive Films
- General information on sticking on adhesive films
- 51 14 000 Removing and installing/replacing front BMW badge
- 51 14 010 Removing and installing/replacing rear BMW emblem
  - Removing the emblem at the rear
  - Installing the rear emblem
- 51 14 111 Replace rear model inscription
  - Removing the model inscription at the rear
  - Installing the model inscription at the rear
- 51 14 111 Replacing model name plate, rear
- 51 14 400 Attach film for vehicle identification number
  - Apply the foil (straight) for the VIN
  - Apply the foil (bent) for the VIN
51 16 Mirrors, Consoles, Interior Trim
- 51 16 001 Removing and installing the outside rearview mirror on left or right front door
  - Removing the exterior mirror
  - Installing the outside rearview mirror
- 51 16 002 Replace exterior rearview mirror on left or right front door
  - Removing the exterior mirror
  - Removing the mirror electronics
  - Installing the mirror electronics
  - Installing the outside rearview mirror
- 51 16 026 Replace mirror glass for exterior vehicle mirror
  - Removing the mirror glass
  - Installing the mirror glass
- 51 16 040 Removing and installing/replacing housing on left or right vehicle exterior mirror
  - Removing mirror housing
  - Installing the mirror housing
- 51 16 041 Removing and installing/replacing protective cap on left or right outside rearview mirror
  - Removing the cover cap from the exterior mirror
  - Fitting the cover cap on the exterior mirror
- 51 16 045 Remove and installing or replacing retaining ring on left or right exterior vehicle mirror
  - Removing retaining ring from outside rearview mirror
  - Install the retaining ring on the outside rearview mirror
- 51 16 063 Removing and installing/replacing the interior rearview mirror
  - Remove inside mirror
  - Install interior rearview mirror
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
  - Remove sun visor
  - Remove the counter support for the sun visor
  - Install the counter support for the sun visor
  - Install the sun visor
- 51 16 145 Removing and installing decorative trim on center console
  - Remove decorative trim on center console
  - Installing the decorative trim on the center console
- 51 16 146 Replacing decorative trim on center console
  - Remove decorative trim on center console
  - Removing the operating facility in the center console
  - Installing the operating facility in the center console
  - Installing the decorative trim on the center console
- 51 16 150 Removing and installing front storage compartment
  - Removing the storage compartment in the front center console
  - Installing the storage compartment in the front center console
- 51 16 151 Replace front storage compartment
  - Removing the connecting socket of the USB audio interface in the front storage compartment
  - Install the connecting socket of the USB audio interface in the storage compartment
  - Removing the socket for the cigarette lighter in the front storage compartment
  - Replacing the socket for the cigarette lighter in the front storage compartment
- 51 16 152 Replacing the storage compartment frame, front
  - Removing the decorative trim of the storage compartment at the front
  - Remove the front storage compartment frame
  - Install the front storage compartment frame
  - Installing the decorative trim of the storage compartment at the front
- 51 16 160 Removing and installing the center console trim
  - Remove the center console trim
  - Installing the center console trim
- 51 16 161 Replacing the center console trim
  - Remove the center console trim
  - Remove decorative trim on center console
  - Installing the decorative trim on the center console
  - Installing the center console trim
- 51 16 163 Removing and installing rear center console trim
  - Removing the rear center console trim
  - Installing the rear center console trim
- 51 16 165 Completely removing and installing center console
  - Removing the center console
  - Install the center console
- 51 16 166 Replacing center console
  - When replacing the center console
- 51 16 172 Removing and installing the center armrest storage compartment
  - Removing the center armrest storage compartment
  - Installing the center armrest storage compartment
- 51 16 173 Replacing center armrest storage compartment
  - Removing the center armrest storage compartment
  - Removing the USB port out of the storage compartment in the center console
  - Installing the USB port in the storage compartment of the center console
  - Installing the center armrest storage compartment
- 51 16 206 Removing and installing/replacing center armrest
  - Remove center armrest
  - Install center armrest
- 51 16 341 Removing and installing/replacing lock cylinder for glove compartment
  - Replacing lock cylinder
- 51 16 355 Removing and installing/replacing driver's side fold-out compartment
  - Removing left fold-out compartment
  - Install fold-out compartment on the left
- 51 16 366 Remove and install the right-hand glove compartment with | housing
  - Remove glove compartment
  - Install glove compartment
- 51 16 368 Replace right hand glove box and casing too
  - When replacing the glove compartment
- 51 16 383 Remove and install/replace damper for glove compartment
  - Removing the glove compartment damper
  - Installing the glove compartment dampers
51 31 Windshield, Rear Window
- General procedure for the disassembly and installation of bonded window glass
- Materials for bonding window
- Notes on window bonding repair kit
- Remove windshield with "Roll Out 2000"
- Removing windows with a "Spider"
- Removing windows with an oscillating knife
- Window glass removal with wire pull handle
- 51 31 000 Removing and installing windshield
  - Remove the windshield
  - Installing windshield
- 51 31 011 Replace windshield
  - Replace windshield
- 51 31 045 Removing and installing/replacing the outer A-pillar cover on the left or right
  - Removing the A-pillar trim panel
  - Install A-pillar trim panel
51 33 Front Power Window Component Bracket
- 51 33 066 Removing and installing module bracket of left front door
  - Removing module bracket
  - Installing module bracket
- 51 33 068 Removing and installing module bracket of right front door
  - Removing module bracket
  - Installing module bracket
- 51 33 070 Replacing left front door module bracket
  - When replacing the module bracket
- 51 33 072 Replacing right front door module bracket
  - When replacing the module bracket
51 37 Rear Quarter Panel Trim Strip
- 51 37 330 Develop and install/replace trim strips on left or right rear quarter panel
  - Removing the trim strip at side panel
  - Installing the trim strip on the side panel
51 41 Front Door Trim Panel
- 51 41 000 Removing and installing left or right front door trim panel
  - Remove front door trim panel
  - Installing the front door trim panel
- 51 41 001 Replacing left or right front door trim panel
  - When replacing the door trim panel: Remount components
- 51 41 017 Removing and installing or replacing cover on door handle, front left or right
  - Removing the cover on the door handle
  - Installing the cover on the door handle
- 51 41 018 Replacing speaker trim on left or right front door trim panel
  - Remove the speaker cover from the door trim panel
  - Install the speaker cover on the door trim panel
51 43 Interior Side Pillar Trim Panels
- 51 43 000 Removing and installing/replacing rear left or right side trim panel
  - Remove rear side trim panel
  - Install rear trim panel
- 51 43 030 Removing and installing/replacing cover on rollover protection mounting bracket, left or right front
  - Removing the cover on the front roll bar
  - Installing the cover on the front roll bar
- 51 43 031 Removing and installing/replacing cover on rollover protection mounting bracket, left or right rear
  - Removing the cover on the rear roll bar
  - Installing the rear cover at the roll bar
- 51 43 070 Remove and install/replace side trim panel, footwell, on A-pillar, left
  - Remove lower A-pillar trim panel
  - Installing bottom A-pillar trim panel
- 51 43 075 Remove and install/replace side trim panel, footwell, on A-pillar, right
  - Removing the lower right A-pillar trim panel
  - Installing the bottom right A-pillar trim panel
- 51 43 148 Removing and installing/replacing trim panel for left or right door pillar (center)
  - Removing the trim panel for the body pillar
  - Installing the trim panel for the body pillar
- 51 43 150 Removing and installing/replacing trim panel for left or right door pillar (bottom)
  - Removing the trim panel for the lower bodywork pillar
  - Installing the trim panel for the lower bodywork pillar
- 51 43 201 Removing and installing/replacing A-pillar trim panel, left front or right front
  - Removing the A-pillar trim panel
  - Install A-pillar trim panel
- 51 43 310 Removing and installing/replacing the seat belt finisher strip, left or right
  - Remove the seat belt finisher strip
  - Install the seat belt finisher strip
51 45 Dashboard Trim, Instrument Panel Trim
- 51 45 030 Removing and installing instrument panel trim
  - Remove instrument panel trim
  - Installing the dashboard trim
- 51 45 031 Replacing instrument panel trim
- 51 45 075 Removing and installing support for dashboard
  - Removing the support for the instrument panel
  - Installing the support for the instrument panel
- 51 45 076 Replacing carrier for dashboard
  - Replacing the support for the instrument panel
- 51 45 115 Removing and installing/replacing the speaker trim on the dashboard trim, top
  - Removing the speaker trim at the dashboard
  - Installing the speaker trim at the dashboard
- 51 45 184 Remove and install the trim panel for pedal assembly
  - Removing the trim panel for pedal assembly
  - Installing the trim panel for the pedal assembly
- 51 45 186 Replacing trim panel for pedal mechanism
- 51 45 195 Removing and installing instrument trim panel trim at bottom right
  - Remove right footwell trim
  - Install right footwell trim
- 51 45 196 Replacing instrument panel trim at bottom right
- 51 45 320 Removing and installing decorative trim on driver's side dashboard left
  - Remove the decorative strip on the dashboard on the left
  - Install the decorative strip on the dashboard on the left
- 51 45 321 Replacing decorative trim on left driver's side dashboard
- 51 45 330 Remove and install decorative trim on right dashboard
  - Removing the right ventilation grille
  - Installing the right ventilation grille
- 51 45 332 Removing and installing decorative trim on center dashboard
  - Remove decorative strip on dashboard at center
  - Install decorative strip on center of dashboard
- 51 45 333 Replacing decorative trim on dashboard at center
51 46 Topping Partition Trim Panel
- 51 46 070 Removing and installing/replacing top partition panel trim panel
  - Removing the trim panel for the top rollover protection
  - Installing the trim panel for the top rollover protection
51 47 Floor/Trunk/Engine Compartment Trim Panels
- 51 47 000 Removing and installing/replacing front left door sill cover strip (inner)
  - Remove door sill cover strip
  - Installing the door sill cover strip
- 51 47 065 Removing and installing/replacing sill trim, front left or right (Outer)
  - Remove the front sill trim
  - Installing the front sill trim
- 51 47 101 Removing and installing/replacing luggage compartment floor covering
  - Removing the cargo area floor covering
  - Install luggage compartment floor covering
- 51 47 140 Removing and installing/replacing panel for luggage compartment partition wall
  - Removing the panel for the luggage compartment partition wall
  - Installing the panel for the luggage compartment partition wall
- 51 47 143 Removing and installing/replacing partition wall trim panel (interior)
  - Removing the trim panel for the inner luggage compartment partition wall
  - Installing the inner panel for the luggage compartment partition wall
- 51 47 151 Removing and installing/replacing left trunk wheel arch trim
  - Luggage compartment wheel arch trim panel
  - Installing luggage compartment wheel arch trim panel
- 51 47 161 Removing and installing/replacing right trunk wheel arch panel
  - Remove right luggage compartment wheel arch trim panel
  - Install luggage compartment wheel arch trim panel on right
- 51 47 171 Removing and installing/replacing the flap in the trunk trim panel, right
  - Removing flap in the luggage compartment wheel arch trim panel
  - Installing the flap in the luggage compartment wheel arch trim panel
- 51 47 219 Removing and installing/replacing the loading edge trim
  - Removing the loading edge trim
  - Installing loading edge trim
- 51 47 314 Removing and installing/replacing the carpet for the vehicle interior
  - Removing the front carpet
  - Installing the front carpet
- 51 47 485 Replace upper trim panel for rollover protection system
  - Removing the trim panel for the top rollover protection
  - Installing the trim panel for the top rollover protection
- 51 47 490 Removing and installing/replacing underbody protection (front)
  - Removing the front underbody protection
  - Install front underbody protection
- 51 47 491 Removing refitting/replacing rear engine undercover
  - Removing rear underbody protection
  - Installing underbody protection at rear
51 48 Engine Compartment Insulation
- 51 48 001 Removing and installing/replacing insulation lining on engine hood/hood
  - Remove the damping material on the hood
  - Installing the damping layer on the hood
51 49 Trunk Lid Inner Trim Panel
- 51 49 008 Removing and installing the tailgate trim panel
  - Remove tailgate trim panel
  - Installing the tailgate trim panel
51 64 Front Panel, Front End
- 51 64 020 Remove and install top rear connection
  - Remove rear cross connection
  - Installing the rear cross connection
- 51 64 025 Removing and installing/replacing upper front connection
  - Remove front cross connection
  - Install front cross connection
- 51 64 035 Removing and installing/replacing the upper section cross connection
  - Remove front cross connection
  - Install front cross connection
- 51 64 060 Removing and refitting/replacing left or right front end strut
  - Remove left front-end strut
  - Install the left front-end strut
- 51 64 710 Replacing air flap control (after vehicle diagnosis)
  - Removing the air flap control
  - Installing the air flap control
51 71 Gaskets And Loose Body Parts
- 51 71 015 Removing and installing/replacing left or right undershield
  - Remove undershield from the left or right side
  - Installing the undershield on the left or right side
- 51 71 017 Removing and installing/replacing left underbody protection
  - Remove undershield from the left or right side
  - Installing the undershield on the left or right side
- 51 71 018 Removing and installing/replacing right underbody protection
  - Remove undershield from the left or right side
  - Installing the undershield on the left or right side
- 51 71 038 Removing and installing/replacing front left or right wheel arch cover (front section)
  - Removing the front section of the front wheel arch cover
  - Installing the front section of the front wheel arch cover
- 51 71 039 Removing and installing/replacing front left or right wheel arch cover (rear section)
  - Removing the rear section of the front wheel arch cover front
  - Install the rear section of the front wheel arch cover
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
  - Removing rear wheel arch cover
  - Removing the rear wheel arch cover
- 51 71 120 Removing and installing/replacing front cowl panel seal
  - Removing the seal from the windshield panel
  - Installing the seal from the windshield panel
- 51 71 341 Remove & install/replace strut brace
  - Remove thrust field on shock tower
  - Installing thrust field on the shock tower
- 51 71 447 Removing and installing/replacing left or right door sill trim panel
  - Remove door sill trim panel
  - Attach door sill trim panel
51 72 Edge Protection For Doors
- Seal installation
51 75 UNDERSHIELD
- 51 75 030 Removing and installing/replacing the sound insulation, cowl, upper sections, center
  - Remove upper section of the cowl sound insulation
  - Install upper section of cowl sound insulation
- 51 75 040 Install/replace sound insulation on upper section of left cowl
  - Remove the cover of the engine compartment at the rear left
  - Install the cover of the engine compartment on the rear left
- 51 75 045 Install/replace sound insulation on upper section of right cowl
  - Remove the cover of the rear right engine compartment
  - Install the rear right engine compartment cover
51 76 Seals
- 51 76 030 Removing and installing/replacing the rear hood seal
  - Removing the rear hood seal
  - Installing the rear hood seal
- 51 76 031 Removing and installing/replacing the hood seal at the front
  - Removing seal for front hood
  - Install the front hood seal
- 51 76 035 Removing and installing/replacing the mount of the hood seal on the left or right
  - Removing the mount of the hood seal
  - Installing the mounting for hood seal
- 51 76 046 Replacing tailgate seal
  - Remove the tailgate seal
  - Installing the tailgate seal
- 51 76 120 Replace left A-pillar gap seal
  - Removing gap seal on the A-pillar
  - Installing gap seal on the A-pillar
- 51 76 121 Replace right A-pillar gap seal
  - Removing gap seal on the A-pillar
  - Installing gap seal on the A-pillar