Manual A/C-Heater Systems - HVAC
- Troubleshooting
- Climate Control System
- Troubleshooting Index - Air Conditioning (A/C)
- Pinpoint Test 1: Incorrect/Erratic Direction Of Airflow From Outlet(S)
- Pinpoint Test 2: Insufficient, Erratic, Or No Heat
- Pinpoint Test 3: The Air Conditioning (A/C) Does Not Operate/Does Not Operate Correctly
- Pinpoint Test 4: The Air Conditioning (A/C) Is Always On
- Pinpoint Test 5: Insufficient Air Conditioning (A/C) Cooling
- Pinpoint Test 6: No Operation In All The Temperature Settings
- Pinpoint Test 7: The Blower Motor Does Not Operate
- Pinpoint Test 8: The Blower Motor Operates Continuously In High Speed
- Pinpoint Test 9: No Operation In High Blower Setting
- Pinpoint Test 10: No Operation In Lower Speeds
- Refrigerant System Warnings
- Refrigerant Identification Testing
- Contaminated Refrigerant Handling
- Manifold Gauge Set Connection
- Electronic Leak Detection
- Refrigerant System
- Vacuum Hose Repair
- A/C Evaporator/Condenser On-Vehicle Leak Test
- Spring Lock Coupling
- Air Conditioning Line (Peanut) Fitting
- Tracer Dye Leak Detection
- A/C Compressor External Leak Test
- Air Conditioning (A/C) System Flushing
- Discharging And Recovery
- Air Conditioning (A/C) System Evacuation And Charging
- Refrigerant Oil Adding
- Refrigerant System Filtering Following Air Conditioning (A/C) Component Installation
- Climate Control System
- Control Components
- Air Distribution
- Heating And Ventilation
- Center Register Duct
- Defroster Duct
- Rear FOOTWELL Duct
- Heater Hose - 2.0L ZETEC
- Heater Hose - 3.0L DURATEC (4V)
- Heater Core Housing
- Heater Core
- Heater Core Plugged
- Heater Core Pressure Test
- Heater Core Bench Test
- Evaporator Core Housing
- Evaporator Core
- Evaporator Core Orifice
- Air Conditioning (A/C) Pressure Relief Valve
- Air Conditioning (A/C) Compressor - 2.0L ZETEC
- Air Conditioning (A/C) Compressor - 3.0L DURATEC (4V)
- Air Conditioning (A/C) Compressor Bracket
- Inspection And Assembly Requirements
- Clutch And Clutch Field Coil
- Air Conditioning (A/C) Clutch Air Gap Adjustment
- Air Conditioning (A/C) Compressor Shaft Seal
- Condenser Core
- Pressure Cutoff Switch
- Suction Accumulator
- Air Conditioning (A/C) Cycling Switch
- Manifold And Tube Assembly
- Condenser To Evaporator Line
- Function Selector Switch
- Vacuum Control Motor - Panel Vent
- Temperature Blend Door Control Cable
- Vacuum Control Motor - Outside Air Inlet
- Vacuum Control Motor - Defrost
- Vacuum Control Motor - FOOTWELL Vent
- Blower Motor
- Climate Control Assembly
- Blower Motor Switch
- Temperature Control Switch
- Climate Control Assembly Illumination Bulbs
- Specifications
- Torque Specifications
- Special Tools