Rear Axle - Repair -- M4 (F82 & F83)

• 33 00 Rear Axle, General Information
  • Information on replacing shock absorbers
  • Instructions (chassis components made of aluminium)
  • Rear axle: wheel/chassis alignment check must be carried out after the following work
  • Start-up for regulated differential lock
• 33 10 Rear Axle Differential
  • Removing and installing rear axle final drive
  • Replace the rear axle final drive
  • Replacing left or right radial shaft seal for output shaft on rear axle differential
  • Replacing both radial shaft seals for the output shaft on the rear axle differential
  • Removing and installing/replacing oil sump on rear axle differential (220M)
  • Removing and installing/replacing holder (adapter) on rear axle differential at front
  • Removing and installing/replacing adapter on rear axle differential
  • Removing and installing/replacing temperature sensor
  • Remove and install/replace servomotor (complete) of rear axle differential, right
  • Removing and installing/replacing the rear axle differential servomotor
• 33 11 Rear Differential Drive Flange And Dust Plate
  • Replacing radial shaft seal for drive flange on rear axle final drive
  • Replacing the dust plate on the rear axle differential (drive flange removed)
    • Notes
    • REP-TAT-P-3311-01 Removing the dust plate
    • REP-TAT-P-3311-02 Installing the dust plate
• 33 17 Rear Axle Differential Mounting
  • Replacing the rubber mounts for the rear axle final drive suspension at rear
• 33 21 Output Shafts
  • Pressing output shaft out of drive flange and drawing in
  • Removing and installing/replacing left or right output shaft
• 33 31 Rear Axle Carrier
  • Removing and installing complete rear axle support
  • Replacing rear axle support
  • Lowering/raising rear axle support (universal lifter)
• 33 32 Trailing Arms And Struts
  • Overview of control arms and camber arm
  • Replacing a ball joint in lower steering stub/wheel carrier
  • Replacing a wheel carrier
  • Removing and installing/replacing left or right rear reinforcement strut
  • Removing and installing/replacing left or right camber arm
  • Replacing rubber mount for camber arm in rear axle support
  • Replace bottom rear wishbone
  • Replacing front bottom wishbone
  • Replace upper front wishbone
  • Replace top rear wishbone
• 33 41 Wheel Bearings
  • Detaching wheel bearing inner ring from drive flange (drive flange removed)
  • Replacing drive flange on left/right rear axle shaft
  • Replacing left or right wheel bearing on rear axle shaft
• 33 52 Shock Absorbers
  • Removing and installing rear left or right shock absorber
  • Replacing rear left or right side shock absorber (Except M4 GTS)
  • Replacing the rear left or right shock absorbers (M4 GTS)
  • Replacing rear left or right support bearing for shock absorber
• 33 53 Coil Springs
  • Removing and installing/replacing rear left or right coil spring
• 33 55 Anti-Roll Bar
  • Removing and installing/replacing rear anti-roll bar
  • Replacing both rubber mounts for anti-roll bar mounting
  • Replacing anti-roll bar link for anti-roll bar on left or right