Section 833 (Automatic Transmission - 4L60-E/4L65-E (Service & Replacement))
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2003 GMC Yukon XL, 2003 GMC Yukon, 2003 Chevrolet Tahoe, 2003 Chevrolet Suburban, and 2003 Chevrolet Avalanche. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Transmission Fluid Temperature (TFT) Sensor Specification
- Fastener Tightening Specification
- Transmission General Specification
- Fluid Capacity Specification
- Range Reference Specification
- Shift Solenoid Valve State and Gear Ratio Specification
- Torque Converter End Play Specification
- Shift Speed Specification
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch Logic Specification
- Transmission Range Switch Logic Specification
- Line Pressure Specification
- Component Resistance Specification
- Schematic Wiring Diagrams
- Component Locator
- Diagnostic Information and Procedures
- Diagnostic Starting Point - Automatic Transmission
- Diagnostic System Check - Automatic Transmission
- Scan Tool Output Controls
- Transmission Scan Tool Data List
- Transmission Scan Tool Data Definitions
- Diagnostic Trouble Code (DTC) Type Definitions
- Diagnostic Trouble Code (DTC) List
- DTC P0218: TFT High
- DTC P0502: Low Vehicle Speed With High Engine Speed
- DTC P0503: Output Speed Drop High
- DTC P0706: Start-Up In A Drive Range, Or Vehicle Speed In PARK Or NEUTRAL Range
- DTC P0711: Transmission Fluid Temperature (TFT) Sensor
- DTC P0712: Short To Ground In TFT Signal Circuit
- DTC P0713: TFT Sensor Signal Voltage High
- DTC P0719: Open Brake Switch Circuit
- DTC P0724: Closed Brake Switch Circuit
- DTC P0740: Open, Short To Ground Or Short To Power In The Tcc Solenoid Valve Circuit
- DTC P0741: High TCC Slip Speed
- DTC P0742: Low TCC Slip
- DTC P0748: Open Or Short In The Pc Solenoid Valve Circuit
- DTC P0751: Gear Ratio
- DTC P0752: Gear Ratio
- DTC P0753: Open, Short To Ground Or Short To Power In The 1-2 SS Valve Circuit
- DTC P0756: Gear Ratio
- DTC P0757: Gear Ratio
- DTC P0758: Open, Short To Ground Or Short To Power In The 2-3 SS Valve Circuit
- DTC P0785: Open, Short To Ground Or Short To Power In The 3-2 SS Valve Assembly Circuit
- DTC P0894: Excessive TCC Slip
- DTC P1810: Invalid State Of The TFP Manual Valve Position Switch Circuit
- DTC P1860: Open, Short To Ground Or Short To Power In The TCC PWM Solenoid Valve Circuit
- DTC P1875: Open, Short To Ground Or Short To Power In The 4WD Low Circuit
- Range Selector Displays Incorrect Range
- Tow/Haul Switch/Indicator Always On or Inoperative
- Transmission Fluid Checking Procedure
- Line Pressure Check Procedure
- Road Test Procedure
- Torque Converter Diagnosis Procedure
- Flexplate/Torque Converter Vibration Test
- Noise and Vibration Analysis
- Clutch Plate Diagnosis
- Engine Coolant in Transmission
- Fluid Leak Diagnosis
- Find the Cause of the Leak
- Possible Points of Fluid Leaks
- Case Porosity Repair
- Shift Solenoid Leak Test
- Automatic Transmission Oil Cooler Flushing and Flow Test (J 45096)
- Automatic Transmission Oil Cooler Flushing and Flow Test (J 35944-A)
- Transmission Overheats
- Oil Pressure High Or Low
- Harsh Shifts
- Inaccurate Shift Points
- First Gear Range Only - No Upshift
- Slips In First Gear
- Slipping Or Harsh 1 - 2 Shift
- No 2 - 3 Shift Or 2 - 3 Shift Slips, Rough Or Hunting
- Second/Third Gear Only Or First/Fourth Gears Only
- No First Or Second Gear/No Third Or Fourth Gear
- No Second Gear, No Fourth Gear, And No Reverse Gear
- Third Gear Only
- 3 - 2 Flare Or Tie-Up
- No 3 - 4 Shift, Slips Or Rough 3 - 4 Shift
- No Reverse Or Slips In Reverse
- No Part Throttle Or Delayed Downshifts
- Harsh Garage Shift
- No Overrun Braking - Manual 3-2-1
- No Torque Converter Clutch (TCC) Apply (300 RPM Slip)
- Torque Converter Clutch (TCC) Shudder
- No Torque Converter Clutch (TCC) Release
- Torque Converter Clutch (TCC) Slip - 100 RPM Slip
- Torque Converter Clutch (TCC) Slip With Stall/Stumble
- Torque Converter Clutch (TCC) Intermittent - OK Cold/Slips Hot
- No Fourth Gear, Or Slips In Fourth Gear
- Slip/Flare In Any Gear
- No Third Gear
- Drives in Neutral
- Second Gear Start
- No Park
- Oil Out Vent
- Vibration In Reverse And Whining Noise In Park
- Retouching Noise
- Popping Noise
- Whine Noise Varying With RPM Or Fluid Pressure
- Buzz Noise Or High Frequency Rattle Sound
- Noise In Random Ranges
- No Drive In All Ranges
- No Drive In Drive Range
- Shift Lever Indicates Wrong Gear
- No Gear Selection
- Automatic Transmission - 4L60-E/4L65-E (Service & Replacement)
- Delay In Drive And Reverse
- Lack Of Power Or Hesitation
- Repair Instructions
- Automatic Transmission Range Selector Cable Replacement
- Automatic Transmission Range Selector Cable Bracket Replacement
- Automatic Transmission Range Selector Cable Adjustment
- Park/Neutral Position Switch Replacement
- Park/Neutral Position Switch Adjustment
- Automatic Transmission Fluid/Filter Replacement
- Transmission Fluid Cooler Hose/Pipe Replacement
- Transmission Oil Cooler Line Quick Connect Fitting
- Transmission Fluid Auxiliary Cooler Replacement
- 2-4 Servo
- Pressure Regulator Replacement
- Filler Tube and Seal Replacement
- Manual Shift Shaft Seal Replacement
- Valve Body and Pressure Switch Replacement
- Control and Shift Solenoids Replacement
- Torque Converter Clutch Pulse Width Modulation (TCC PWM) Solenoid, TCC Solenoid, and Wiring Harness
- Accumulator Assembly, Spacer Plate, and Gaskets
- Transmission Extension Housing Rear Oil Seal Replacement
- Transmission Extension Housing Assembly Replacement
- Vehicle Speed Sensor (VSS) Replacement
- Transmission Mount Replacement
- Transmission Replacement
- Description and Operation
- Transmission General Information
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission Component and System Description
- Transmission Adaptive Functions
- Clearing Transmission Adaptive Pressure (TAP)
- Transmission Indicators and Messages
- Electronic Component Description
- 1-2 and 2-3 Shift Solenoid Valves
- 3-2 Shift Solenoid Valve Assembly
- Transmission Pressure Control Solenoid
- Torque Converter Clutch Solenoid Valve
- Torque Converter Clutch Pulse Width Modulation Solenoid Valve
- Transmission Fluid Pressure (TFP) Manual Valve Position Switch
- Vehicle Speed Sensor Assembly
- Automatic Transmission Fluid Temperature Sensor
- Transmission Range Switch
- Tow/Haul Mode Switch
- Automatic Transmission In-line 20-Way Connector Description
- Special Tools and Equipment