Section 27 (Mechanical Brake System - Base (Service Information) - Coupe)
WARNING: This page is about a different car, the 2005 Dodge Stratus and 2005 Chrysler Sebring. However, it is still accessible from the selected car via links, so may be relevant.
- General Description
- Basic Brake System Diagnosis
- Introduction
- Troubleshooting Strategy
- Symptom Chart
- Symptom Procedures
- INSPECTION PROCEDURE 1: Vehicle Pulls to One Side When Brakes are Applied
- INSPECTION PROCEDURE 2: Insufficient Braking Power
- INSPECTION PROCEDURE 3: Increased Pedal Stroke (Reduced Pedal-to-Floor Board Clearance)
- INSPECTION PROCEDURE 4: Brake Drag
- INSPECTION PROCEDURE 5: Scraping or Grinding Noise When Brakes are Applied
- INSPECTION PROCEDURE 6: Squealing, Groaning or Chattering Noise When Brakes are Applied
- INSPECTION PROCEDURE 7: Squealing Noise When Brakes are not Applied
- INSPECTION PROCEDURE 8: Groaning, Clicking or Rattling Noise When Brakes are not Applied.
- Special Tools
- On-Vehicle Service
- Brake Pedal Check And Adjustment
- Stoplight Switch Check
- Brake Booster Operating Test
- Check Valve Operation Check
- Proportioning Valve Function Test
- Bleeding
- Brake Fluid Level Sensor Check
- Disc Brake Pad Check And Replacement
- Disc Brake Rotor Check
- Front Disc Brake Run-Out Check And Correction
- Rear Disc Brake Run-Out Check And Correction
- Brake Disc Thickness Check
- Brake Lining Thickness Check
- Brake Drum Inside Diameter Check
- Brake Lining And Brake Drum Contact Check
- Auto Adjuster Function Check
- Master Cylinder Function Check
- Brake Pedal
- Master Cylinder Assembly And Brake Booster
- Front Disc Brake Assembly
- Rear Disc Brake Assembly
- Rear Drum Brake
- Proportioning Valve
- Specifications