Section 1 (Automatic Transmission - 5L40-E/5L50-E - Introduction (2 Of 2))
WARNING: This page is about a different variant/trim than selected.
- Specifications
- Transmission Fluid Temperature Sensor Specifications
- Fastener Tightening Specifications
- End Play Specifications (5L40-E)
- Clutch Piston Travel Specifications
- Clutch Plate Selection Specifications
- Reverse Clutch Housing Selective Thrust Washer Specifications
- Intermediate and Overdrive Clutch Housing Retaining Ring Specifications
- Transmission Fluid Pump Specifications
- Transmission General Specifications
- Fluid Capacity Specifications
- Range Reference
- Shift Solenoid Valve State and Gear Ratio
- Shift Speed
- Transmission Internal Mode Switch Logic
- Line Pressure
- Component Resistance
- Schematic and Routing Diagrams
- Component Locator
- Automatic Transmission Electronic Component Views
- Disassembled Views
- Component Location
- Ball Check Valve Locations
- Automatic Transmission Inline 20-Way Connector End View
- Automatic Transmission Internal Connector End Views
- 1-2 Shift Solenoid (SS) Valve, Wiring Harness Side
- 2-3 Shift Solenoid (SS) Valve, Wiring Harness Side
- 4-5 Shift Solenoid (SS) Valve, Wiring Harness Side
- Input Speed Sensor, Wiring Harness Side
- Output Speed Sensor, Wiring Harness Side
- Pressure Control (PC) Solenoid Valve, Wiring Harness Side
- Torque Converter Clutch Pulse Width Modulated (TCC PWM) Solenoid Valve, Wiring Harness Side
- Transmission Manual Shift Shaft Switch Assembly, Wiring Harness Side
- Automatic Transmission Related Connector End Views
- Diagnostic Information and Procedures
- Repair Instructions
- Repair Instructions - On Vehicle
- Transmission Control Lever Knob Replacement
- Automatic Transmission Control Replacement
- Shift Control Linkage Adjustment
- Shift Control Linkage Replacement
- Automatic Transmission Fluid and Filter Replacement
- Transmission Fluid Cooler Hose/Pipe Quick-Connect Fitting Replacement
- Transmission Fluid Cooler Hose/Pipe Replacement
- Automatic Transmission Fluid Pressure Test Hole Plug Replacement
- Transmission Internal Electrical Harness Replacement
- Drive Flange and Seal Replacement
- Extension Housing and Seal Replacement
- Parking Pawl Replacement
- Manual Shift Shaft Position Switch Replacement
- Input Speed Sensor Replacement
- Output Speed Sensor Replacement
- 1-2 Shift Solenoid Valve Replacement
- 2-3 Shift Solenoid Valve Replacement
- 4-5 Shift Solenoid Replacement
- Pressure Control Solenoid Replacement
- Torque Converter Clutch Solenoid Replacement
- Control Valve Body Accumulator Assembly Replacement
- Transmission Control Module Replacement
- Torque Converter Replacement
- Torque Converter Fluid Seal Replacement
- Transmission Mount Inspection
- Transmission Rear Mount Replacement
- Transmission Replacement
- Repair Instructions - Off Vehicle
- Torque Converter Assembly Removal
- Holding Fixture Installation
- Transmission Fluid Draining
- Extension Housing Removal
- Transmission Fluid Pan and Filter Assembly Removal
- Wiring Harness Removal
- Control Valve Body Accumulator Assembly Removal
- Output Shaft Speed Sensor Removal
- Input Speed Sensor Removal
- Torque Converter Housing Removal
- Direct and Reverse and Forward and Coast Clutch Removal
- Input Sun Gear Shaft Removal
- Direct Clutch Hub Removal
- Intermediate Clutch Sprag Assembly Removal
- Overdrive Clutch Housing Removal
- Low Clutch Sprag Removal
- Center Support Removal
- Input and Reaction Carrier Removal
- Output Shaft Removal
- Parking System Components Removal
- Case Assembly Inspection
- Case Components Disassemble
- Case Components Assemble
- Parking System Components Installation
- Output Shaft and Rear Internal Ring Gear Disassemble
- Output Shaft and Rear Internal Ring Gear Assemble
- Input and Reaction Carrier Disassemble
- Input and Reaction Carrier Assemble
- Center Support Disassemble
- Center Support Assemble
- Low Clutch Sprag Assemble
- Overdrive and Intermediate Clutch Disassemble
- Overdrive and Intermediate Clutch Assemble
- Intermediate Clutch Sprag Inspection
- Intermediate Clutch Sprag Assemble
- Direct Clutch Hub Assemble
- Input Sun Gear Shaft Disassemble
- Input Sun Gear Shaft Assemble
- Forward and Coast Clutch Disassemble
- Forward and Coast Clutch Assemble
- Direct and Reverse Clutch Disassemble
- Direct and Reverse Clutch Assemble
- Direct and Reverse and Forward and Coast Clutch Installation
- Transmission Fluid Pump Removal
- Transmission Fluid Pump Disassemble
- Torque Converter Seal Removal
- Transmission Fluid Pump Assemble
- Torque Converter Housing Installation
- Torque Converter Seal Installation
- Control Valve Body Accumulator Assembly Disassemble
- Control Valve Rear Body Inspection
- Control Valve Rear Body Disassemble
- Control Valve Rear Body Assemble
- Control Valve Front Body Inspection
- Control Valve Front Body Disassemble
- Control Valve Front Body Assemble
- Control Valve Body Accumulator Assembly Assemble
- Input Speed Sensor Installation
- Output Shaft Speed Sensor Installation
- Control Valve Body Accumulator Assembly Installation
- Wiring Harness Installation
- Transmission Fluid Pan and Filter Assembly Installation
- Extension Housing Installation
- Prop Flange Assemble
- Holding Fixture Removal
- Torque Converter Assembly Installation
- Repair Instructions - On Vehicle
- Description and Operation
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission General Description
- Transmission Component and System Description
- Transmission Adaptive Functions
- Transmission Indicators and Messages
- Electronic Component Description
- Transmission Control Module (TCM)
- Transmission Manual Shift Shaft Switch Assembly (602)
- Automatic Transmission Output Speed (A/T OSS) Sensor (42)
- Automatic Transmission Input Speed (A/T ISS) Sensor (44)
- Automatic Transmission Fluid Temperature (TFT) Sensor
- Shift Solenoid Valves
- Torque Converter Clutch Pulse Width Modulation (TCC PWM) Solenoid Valve (352)
- Pressure Control (PC) Solenoid Valve (357)
- Duty Cycle, Frequency and Current Flow
- Transmission Adapt Function
- Automatic Transmission Inline 20-Way Connector Description
- Sport/Economy Mode Operation
- Winter Mode Operation
- Limp Home Mode Description
- Automatic Transmission Hydraulic Diagrams
- Park - Engine Running
- Reverse
- Neutral - Engine Running
- Overdrive Range, First Gear (Before First 1-2 Shift)
- Overdrive Range, First Gear (After First 1-2 Shift)
- Overdrive Range, Second Gear
- Overdrive Range, Third Gear
- Overdrive Range, Fourth Gear
- Overdrive Range, Fifth Gear - Torque Converter Clutch Released
- Overdrive Range, Fifth Gear - Torque Converter Clutch Applied
- Manual Fourth Gear
- Manual Third Gear
- Manual Second Gear
- Manual Second - First Gear
- Fluid Passages
- Special Tools and Equipment