Section 29 (Steering - Removal, Replacement And Installation)
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
- Power Steering Servo Equipment (B5254T2; B6294S2; B6294T; 2004)
- Power Steering Servo Equipment (B6284T; 1999-2001)
- Power Steering Servo Equipment (B6294S; 2000-2001)
- Power Steering Servo Equipment (B6294S2; B6294T; 2002-2003)
- Power Steering Servo Equipment (B6304S3; 1999)
- Steering Gear (2004-2006)
- Internal pipe steering gear
- Limiters, replacing
- Replacing the outer steering arm
- Replacing the steering gear
- Notes
- Removal
- Notes
- Installing lifting tools
- Disconnecting the connector
- Removing track rod ends
- Measuring the position of the track rod in the steering gear
- Removing the splash guard
- Removing the bracket for the exhaust pipe
- Removing the collision protection system over the steering gear
- Removing the nuts and screw for the steering gear
- Lowering the sub-frame at the rear edge
- Removing steering gear
- Installation
- Installing steering gear
- Checking the position of the track rod in the steering gear
- Installing the sub-frame at the rear edge
- Installing the cable harness for the heated oxygen sensors (HO2S)
- Installing the bracket for the exhaust pipe
- Installing the track rod ends on the steering arms
- Removing the lifting tools
- Finishing
- Solenoid, steering gear, replacement
- Steering arm inner, replacing
- Stepper motor, steering gear, replacing
- Steering Gear (1999-2003)
- Steering Wheel, Steering Wheel Lock, Steering Column, Shaft (2005-2006)
- Lever steering wheel adjustment, replacing
- Replacing the steering column/steering shaft
- Notes
- Removing the steering column/steering shaft
- Remove the steering wheel
- Remove the steering column covers
- Remove the soundproofing panel
- Remove the steering wheel lock unit
- Remove the ignition switch interlock cable (only automatic transmission)
- Remove the gear selector assembly
- Remove the floor lighting
- Remove the steering wheel lock
- Remove the joint from lower steering shaft
- Remove the steering column and the steering shaft
- Installing the steering column/steering shaft
- Install the steering column and the steering shaft
- Install the steering shaft joint on the lower steering shaft
- Install the cable sleeve on the steering column
- Install the floor lighting
- Install the soundproofing panel
- Install the steering wheel lock
- Install the cable for the ignition switch interlock (only automatic transmission)
- Install the steering wheel lock unit
- Install the lever unit
- Install the steering column covers
- Zero the contact reel
- Install the steering wheel and check the steering wheel position
- Tighten the screw in the center of the steering wheel
- Install the steering wheel module
- Check the function
- Combined instrument panel surround
- Replacing the steering wheel
- Steering shaft, lower, replacing
- Steering wheel module (SWM), replacing
- Steering-column lock replacement
- Steering Wheel, Steering Wheel Lock, Steering Column, Shaft (1999-2004)
- Servo Equipment (2005-2006)
- Servo Equipment (B5254T2; B6294S2; B6294T; 2005-2006)