Automatic Transmission - 6L50/6L80/6L90 - Introduction (2 Of 2)
- Specifications
- Schematic and Routing Diagrams
- Component Locator
- Automatic Transmission Electronic Component Views
- Disassembled Views (6L80)
- Component Location
- Bushing, Bearing & Washer Locations
- Seal Locations
- Ball Check Valve Locations
- Automatic Transmission Inline 16-Way Connector End View
- Automatic Transmission Internal Connector End Views
- Automatic Transmission Related Connector End Views
- Diagnostic Information and Procedures
- Repair Instructions
- Repair Instructions - On Vehicle
- Filler Tube and Seal Replacement
- Automatic Transmission Range Selector Lever Cable Adjustment
- Automatic Transmission Range Selector Lever Cable Replacement
- Automatic Transmission Range Selector Lever Cable Bracket Replacement
- Automatic Transmission Range Selector Lever Replacement
- Transmission Fluid Auxiliary Cooler Replacement
- Transmission Fluid Cooler Hose/Pipe Quick-Connect Fitting Replacement
- Transmission Fluid Cooler Hose/Pipe Replacement
- Transmission Heat Shield Replacement
- Automatic Transmission Fluid Pressure Test Hole Plug Replacement
- Automatic Transmission Electrical Connector Passage Sleeve Replacement
- Automatic Transmission Fluid, Fluid Pan and/or Filter Replacement
- Transmission Mount Inspection
- Transmission Mount Replacement (2WD)
- Transmission Mount Replacement (4WD)
- Extension Housing and Seal Replacement
- Transmission Output Shaft Seal Replacement
- Manual Shift Shaft and Seal Replacement
- Manual Shift Detent Lever and Park Pawl Actuator Replacement
- Manual Shift Shaft Position Switch Replacement
- Control Solenoid Valve and Transmission Control Module Assembly Replacement
- Control Valve Lower Body and Upper Body Replacement
- Input and Output Speed Sensor Replacement
- Transmission Replacement
- Repair Instructions - Off Vehicle
- Torque Converter Replacement
- Transmission Converter Cover Replacement
- Torque Converter Fluid Seal Replacement
- Torque Converter Removal and Holding Fixture Installation
- Case Extension Assembly Removal
- Fluid Pan, Fluid Filter and Electrical Connector Passage Sleeve Removal
- Control Valve Body Assembly Removal
- Torque Converter Housing with Fluid Pump Removal
- 1-2-3-4 and 3-5 Reverse Clutch Assembly and 4-5-6 Clutch Assembly Removal
- Center Support, Output Carrier and Output Shaft Removal
- Manual Shift Shaft and Parking System Components Overhaul (6L80/6L90)
- Manual Shift Shaft Seal Replacement
- Output Shaft Seal Replacement (AWD Models Only)
- Case Inspection
- Output Shaft Disassemble
- Output Shaft Assemble
- Output Carrier Assembly Overhaul (6L80)
- Output Carrier to Output Shaft Assemble (6L80/6L90)
- 2-6 Clutch Overhaul (6L80)
- Low and Reverse Clutch Overhaul (6L80)
- 4-5-6 Clutch Dampener Overhaul
- 4-5-6 Clutch Overhaul (6L80)
- 4-5-6 Clutch Backing Plate Retaining Ring Measurement
- 1-2-3-4 and 3-5 Reverse Clutch Overhaul (6L80)
- 1-2-3-4 and 3-5 Reverse Clutch Plates Removal
- 1-2-3-4 Clutch Piston Removal
- 3-5 Reverse Clutch Piston Removal
- 1-2-3-4 and 3-5 Reverse Clutch Piston Seals Replacement
- 3-5 Reverse Clutch Piston Installation
- 1-2-3-4 Clutch Piston Installation
- 1-2-3-4 Clutch Plate Installation
- 3-5 and Reverse Clutch Plate Installation
- 1-2-3-4 and 3-5 Reverse Clutch Bearing Assembly Replacement
- 1-2-3-4 Clutch Backing Plate Retaining Ring Measurement
- 3-5 Reverse Clutch Backing Plate Retaining Ring Measurement
- Torque Converter Housing with Fluid Pump Disassemble
- Fluid Pump Cover Cleaning and Inspection
- Torque Converter Housing Cleaning and Inspection
- Oil Cooler Pipe Seals Replacement
- Fluid Pump Selective Measurement
- Torque Converter Housing with Fluid Pump Assemble
- Fluid Pump Cover Installation
- Control Valve Body Assembly Disassemble
- Control Valve Lower Body Assembly Cleaning and Inspection
- Control Valve Upper Body Assembly Cleaning and Inspection
- Control Valve Body Assembly Assemble
- Upper to Lower Control Valve Body Assemblies Assemble
- Filter Plate Installation
- Control Solenoid Valve Assembly Installation
- Manual Shift Shaft Position Switch Installation
- Valve Body, Control Solenoid Torque Sequence
- Control Solenoid Valve Assembly Contact Gap Inspection
- Input and Output Speed Sensor Assembly Installation
- Center Support, Output Carrier and Output Shaft Installation
- 1-2-3-4 and 3-5 Reverse Clutch Assembly and 4-5-6 Clutch Assembly Installation
- Torque Converter Housing with Fluid Pump Installation
- Case Extension Seal Replacement
- Control Valve Body Assembly Installation
- Automatic Transmission Electrical Connector Passage Sleeve Installation
- Fluid Filter and Manual Shift Detent Assembly Installation
- Transmission Fluid Pan Installation
- Case Extension Assembly Installation
- Torque Converter Installation and Holding Fixture Removal (6L80)
- Repair Instructions - On Vehicle
- Description and Operation
- Definitions and Abbreviations
- Transmission Identification Information
- Transmission General Description
- Transmission Component and System Description
- Transmission Adaptive Functions
- Transmission Indicators and Messages
- Electronic Component Description
- Automatic Transmission Inline 16-Way Connector Description
- Automatic Transmission Hydraulic Diagrams
- Park - Engine Running
- Reverse
- Neutral - Engine Running
- Drive Range, First Gear Engine Braking
- Drive Range, First Gear
- Drive Range, Second Gear
- Drive Range, Third Gear
- Drive Range, Third Gear Default
- Drive Range - Fourth Gear
- Drive Range, Fifth Gear
- Drive Range, Fifth Gear Default
- Drive Range, Sixth Gear
- Fluid Passages
- Special Tools and Equipment