Section 17 (Engine Controls And Fuel - 2.4L - DTC P0628 To DTC P2635 And Diagnostic Information And Procedures)
WARNING: This page is about a different variant/trim than selected.
- Diagnostic Information and Procedures
- DTC P0628: Fuel Pump Enable Circuit (LUK)
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0641, P0651, P0697, or P06A3: 5V Reference (ECM)
- DTC P0641 or P06A6: 5V Reference (Chassis Control Module)
- DTC P0650, P263A, or P263B: Malfunction Indicator Lamp (MIL) Control Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P0685-P0687, P0689, P0690, or P1682: Engine Controls Ignition Relay
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P069E: Fuel Pump Control Module Requested MIL Illumination
- DTC P0700: Fuel Pump Control Module Requested MIL Illumination
- DTC P0AC4: Hybrid/EV Powertrain Control Module Requested MIL Illumination
- DTC P1255: Fuel Pump Control Module Driver Over Temperature (Fuel Pump Power Control Module)
- DTC P1255 or P064A: Fuel Pump Control Module (Chassis Control Module)
- DTC P129B or P129C: Fuel Pump Driver Control Module System Voltage Low/High
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P129D: Fuel Pump Driver Control Module Ignition On/Start Switch Circuit
- DTC P12A6: Fuel Pump Driver Control Module Enable Circuit
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P129E or P12A8: Fuel Pump Driver Control Module Signal Message Counter
- DTC P135A: Ignition Coil Supply Voltage Circuit Bank 1
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P1400: Cold Start Emission Reduction Control System
- DTC P150C: Transmission Control Module Engine Speed Request Signal Message Counter
- DTC P1516, P2101, P2119, or P2176: Throttle Actuator Position
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- Repair Verification
- DTC P15F2: Engine Torque Command Signal Message Counter
- DTC P15F9: Hybrid/EV System Engine Speed Control Intervention Request Type Signal Message Counter
- DTC P15FB: Brake Pedal Position Sensor Signal Message Counter
- DTC P163A: Control Module Fuel Pressure Regulator 1 Control System
- DTC P2096 or P2097: Post Catalyst Fuel Trim System Low/High
- DTC P2122, P2123, P2127, P2128, or P2138: Accelerator Pedal Position (APP) Sensor
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P2199: Intake Air Temperature (IAT) Sensors 1-2 Not Plausible (With LEA)
- Diagnostic Instructions
- DTC Descriptor
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P219A: Fuel Trim Cylinder Balance
- DTC P2227-P2230: Barometric Pressure (BARO) Sensor
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- DTC P2430, P2431, P2435, or P2436: Secondary Air Injection System Pressure Sensor Circuit
- Diagnostic Instructions
- DTC Descriptor
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- Repair Verification
- DTC P2432, P2433, P2437, or P2438: Secondary Air Injection System Pressure Sensor Circuit Voltage
- Diagnostic Instructions
- DTC Descriptors
- Diagnostic Fault Information
- Typical Scan Tool Data
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the MIL/DTC
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Component Testing
- Repair Instructions
- DTC P2440: Secondary Air Injection System Cut-Off Valve Stuck Open
- DTC P2444: Secondary Air Injection System Pump Stuck On
- DTC P2544: Transmission Torque Request Signal Message Counter
- DTC P2635: Fuel Pump Flow (Chassis Control Module)
- DTC P2635: Fuel Pump Flow (Fuel Pump Power Control Module)
- Diagnostic Instructions
- DTC Descriptor
- Circuit/System Description
- Conditions for Running the DTC
- Conditions for Setting the DTC
- Action Taken When the DTC Sets
- Conditions for Clearing the DTC
- Diagnostic Aids
- Reference Information
- Circuit/System Verification
- Circuit/System Testing
- Repair Instructions
- Repair Verification
- Symptoms - Engine Controls (LUK)
- Symptoms - Engine Controls (LEA
- Malfunction Indicator Lamp (MIL) Diagnosis
- Engine Cranks But Does Not Run (LUK)
- Engine Cranks But Does Not Run (LEA)
- Fuel System Diagnosis (LUK)
- Fuel System Diagnosis (LEA)
- Fuel Injector Circuit Diagnosis
- Fuel Injector Solenoid Coil Test
- Fuel Injector Balance Test
- Alcohol/Contaminants-in-Fuel Diagnosis
- Electronic Ignition System Diagnosis
- Evaporative Emission System Diagnosis
- Inspection/Maintenance System Check
- Inspection/Maintenance Complete System Set Procedure
- Inspection/Maintenance (I/M) System DTC Table (LUK)
- Inspection/Maintenance (I/M) System DTC Table (LEA)
- Poor Fuel Fill Quality
- DTC P0628: Fuel Pump Enable Circuit (LUK)