Section 120 (Seat Belts & SRS Components - Removal & Installation (644 Body))
WARNING: This page is about a different car, the 2004 Volvo S40, 2003 Volvo S40, 2002 Volvo S40, 2001 Volvo S40, and 2000 Volvo S40. However, it is still accessible from the selected car via links, so may be relevant.
- Restraints
- IC (inflatable curtain), replacing
- Igniter wire connector, SRS
- Passenger airbag module, replacing
- Seat belts, front, replacing
- Preparations
- Disassembly
- Handling replaced SRS airbags / seat belt tensioners
- Reassembly
- Conclusion
- Replacing the SRS module
- Power windows switch rear tunnel panel, Convertible, replacement
- Airbag steering wheel module, steering wheel and contact reel replacement
- Disassembly
- Notes
- Preparations
- Ignition in position I
- Slacken off steering wheel screws
- Removing airbag steering wheel module
- Positioning the steering wheel module
- Connecting special tool
- Slacken off center screw
- Reconnect the battery negative lead
- Align the front wheels
- Disconnect the battery negative lead
- Remove special tool
- Secure the contact reel
- Remove the steering wheel center screw
- Removing steering wheel, steering wheel cover and switch
- Removing contact reel / SRS
- Reassembly
- Resetting contact reel
- Installing contact reel / SRS
- Install switch, steering wheel covers and steering wheel
- Installing center screw
- Unlocking the contact reel
- Connect special tool
- Reconnect the battery negative lead
- Adjusting the front wheels
- Tightening center screw
- Installing airbag steering wheel module
- SRS Airbag date decal
- Final check
- Disassembly
- Seat belts, rear, replacing (5-door)
- Seat belt tensioner, checking
- SRS connector
- SRS control module, replacing