Section 567 (Body Panel System - Body System - Exterior)
WARNING: This page is about a different car, the 2004 Mercury Mountaineer and 2004 Ford Explorer. However, it is still accessible from the selected car via links, so may be relevant.
- Specifications
- Description And Operation
- Diagnosis And Testing
- Body System
- Rear View Mirrors
- Notes
- Special Tool(s)
- Inspection and Verification
- Symptom Chart - Rear View Mirrors
- Connector Circuit Reference
- Pinpoint Test A: The Mirrors Are Inoperative
- Pinpoint Test B: A Single Mirror Is Inoperative
- Pinpoint Test C: A Single Mirror Does Not Function With Switch Logic
- Pinpoint Test D: The Auto Dimming Mirror Does Not Operate Correctly
- Pinpoint Test E: The Heated Exterior Mirror Does Not Defrost - Both Heated Exterior Mirrors
- Pinpoint Test F: The Heated Exterior Mirror Does Not Defrost - Left Heated Exterior Mirror
- Pinpoint Test G: The Heated Exterior Mirror Does Not Defrost - Right Heated Exterior Mirror Inoperative
- Glass, Frames and Mechanisms
- Notes
- Special Tool(s)
- Inspection and Verification
- Symptom Chart - Glass, Frames and Mechanisms
- Connector Circuit Reference
- Instrument Cluster Module (ICM) C220a
- DATC Module C228a (if equipped)
- Function Selector Switch C294b - Manual Climate Control (if equipped)
- Heated Backlight Power C402a
- Heated Backlight Ground C402b
- Driver Window Control Switch C504a
- Driver Window Control Switch C504b
- Driver Power Window Motor C524
- Passenger Front Window Control Switch C604
- Passenger Front Power Window Motor C608
- Driver Rear Window Control Switch C701
- Driver Rear Power Window Motor C703
- Passenger Rear Window Control Switch C801
- Passenger Rear Power Window Motor C803
- Pinpoint Test H: All Power Windows Are Inoperative
- Pinpoint Test I: Single Power Window Is Inoperative - Driver Front Window
- Pinpoint Test J: Single Power Window Is Inoperative - Passenger Front Window
- Pinpoint Test K: Single Power Window Is Inoperative - Driver Rear Window
- Pinpoint Test L: Single Power Window Is Inoperative - Passenger Rear Window
- Pinpoint Test M: The Defrost System Is Inoperative
- Pinpoint Test N: The Defrost System Will Not Shut Off Automatically - ON At All Times
- Wipers and Washers
- Notes
- Special Tool(s)
- Inspection and Verification
- Symptom Chart - Wipers and Washers
- Connector Circuit Reference
- Pinpoint Test O: The Wipers Are Inoperative
- Pinpoint Test P: The Rear Wiper Is Inoperative
- Pinpoint Test Q: The Wipers Stay On Continuously
- Pinpoint Test R: The Rear Wiper Stays On Continuously
- Pinpoint Test S: The High/Low Wiper Speeds Do Not Operate Correctly (intermittent wiper mode OK)
- Pinpoint Test T: The Low Rear Wiper Speed Does Not Operate Correctly
- Pinpoint Test U: The Intermittent Wiper Speed Does Not Operate Correctly (high/low speeds OK)
- Pinpoint Test V: THE INTERMITTENT REAR WIPER SPEED DOES NOT OPERATE CORRECTLY
- Pinpoint Test W: The Wipers Do Not Operate Correctly In The MIST Position
- Pinpoint Test X: The Rear Wiper Wash and Wipe Function Does Not Operate
- Pinpoint Test Y: The Washer Pump Is Inoperative
- Pinpoint Test Z: The Speed Dependent Interval Mode Does Not Operate Correctly
- Component Test - Windshield Wiper Motor
- Component Test - Rear Window Wiper Motor
- General Procedures
- Removal And Installation
- Windshield Glass
- Window Control Switch
- Door Window Glass - Front
- Door Window Glass - Rear
- Windshield Wiper
- Rear Window Wiper
- Fender
- Liftgate
- Windshield Washer Pump and Reservoir
- Running Board
- Exterior Mirror
- Interior Mirror
- Exterior Mirror Control Switch
- Rear Quarter Window Glass
- Liftgate Window Glass
- Front Bumper
- Rear Bumper - Explorer
- Rear Bumper - Mountaineer
- Mouldings
- Notes
- Item 2: Front Fender Moulding Removal Note
- Item 3: Front Door Moulding Removal Note
- Item 5: Rear Door Moulding Removal Note
- Item 7: Rear Quarter Panel Trim Moulding Removal Note
- Item 7: Rear Quarter Panel Trim Moulding, Item 5: Rear Door Moulding, Item 3: Front Door Moulding, Item 2: Front Fender Moulding Installation Note
- Radiator Grille Opening Panel
- Radiator Grille