11 36 125 Removing and installing/replacing intake VANOS central valve: Notes
WARNING:
Working on 12 V electrical system.
Risk of short circuits! Risk of fire!
Risk of short circuits! Risk of fire!
- Make sure that there is no charger connected to the jump start terminal in the engine compartment.
- Detach battery ground lead from battery.
- For auxiliary batteries: Detach battery minus cables from all auxiliary batteries.
WARNING:
Working on fuel system.
Risk of fire! Danger of explosion!
Risk of fire! Danger of explosion!
- When working on the fuel system, make sure that the workbay is sufficiently ventilated, e.g. using extraction unit.
- Tightly seal off open lines and connections; collect any leakage fuel directly at the point of exit.
- No fire, sparks, open flames or smoking.
CAUTION:
On releasing high pressure line, fuel may emerge at high speed.
Injury hazard!
Injury hazard!
- Wear suitable personal protective equipment.
- Before performing any installation work, allow cooling system to cool down to less than 40 °C.
- Note warnings on cylinder head cover.
NOTE:
RISK OF DAMAGE
Damage to battery terminal, the safety battery terminal or the intelligent battery sensor (IBS).
Damaged battery terminals can lead to malfunctions or vehicle electrical system faults.
Damage to battery terminal, the safety battery terminal or the intelligent battery sensor (IBS).
Damaged battery terminals can lead to malfunctions or vehicle electrical system faults.
- Detach battery terminal from battery pole by carefully shifting to and fro. Do not pry off using a tool.
NOTE:
TECHNICAL INFORMATION
After replacing one or more VANOS central valves or VANOS adjusters:
When removing, make note of the identification/part number of the VANOS central valve or VANOS adjuster and consider writing it down.
It must be replaced with a VANOS adjuster or VANOS central valve with the same part number. A mixed installation is not allowed.
Read out the vehicle I-level and proceed accordingly.
Be absolutely certain to pay attention to PuMA measure 64122020.
For further information, see the appropriate BMW Parts Catalogue.
After replacing one or more VANOS central valves or VANOS adjusters:
When removing, make note of the identification/part number of the VANOS central valve or VANOS adjuster and consider writing it down.
It must be replaced with a VANOS adjuster or VANOS central valve with the same part number. A mixed installation is not allowed.
Read out the vehicle I-level and proceed accordingly.
Be absolutely certain to pay attention to PuMA measure 64122020.
For further information, see the appropriate BMW Parts Catalogue.
Preliminary work:
- Disconnect all battery ground leads
- Bring engine compartment lid into service position
- Remove the cover in the left engine compartment
- Remove the right cover in the engine compartment
- Remove both wiper arms
- Remove cowl panel cover
- Refer to REMOVING TRAILING LINK AT SPRING STRUT DOME
- Remove the sound insulation on the bulkhead upper part center
- Remove ACOUSTIC COVER AT REAR
- Refer to REMOVING THE LOWER RIGHT ENGINE BULKHEAD
- Refer to REMOVING THE ACOUSTIC COVER
- Remove ignition coils. Refer to REPLACING IGNITION COILS .
- Remove all spark plugs. Refer to REMOVING/INSTALLING/REPLACING ALL SPARK PLUGS (B58) .
- Refer to REMOVING THE HIGH PRESSURE LINE BETWEEN THE RAIL AND THE HIGH PRESSURE PUMP
- Refer to REMOVING FUEL DELIVERY LINE
- Refer to REMOVING THE INJECTORS FOR CYLINDERS 1 TO 3
- Refer to REMOVING THE INJECTORS FOR CYLINDERS 4 TO 6
- Refer to REMOVING HIGH PRESSURE PUMP
- Refer to REMOVING BOTH ACTUATORS
- Refer to REMOVING INTAKE SILENCER HOUSING
- Refer to REMOVING CLEAN AIR PIPE
- Refer to REMOVING FAN COWL .
- Refer to REMOVING FRONT ENGINE ENCAPSULATION
- Refer to REMOVING THE FRONT UNDERBODY PROTECTION
- Refer to REMOVE/INSTALL/REPLACING REAR UNDERBODY PROTECTION
- Refer to REMOVING REINFORCEMENT PLATE
- Refer to REMOVING STARTER MOTOR
- Refer to REMOVING THE CYLINDER HEAD COVER
- Turn the engine on the vibration damper. Refer to the relevant instructions under the procedure for CHECKING CAMSHAFT TIMING (AUTOMATIC TRANSMISSION) or CHECKING CAMSHAFT TIMING (MANUAL TRANSMISSION) .
- Block the crankshaft in the TDC firing position of the 1st cylinder. Refer to the relevant instructions under the procedure for CHECKING CAMSHAFT TIMING (AUTOMATIC TRANSMISSION) or CHECKING CAMSHAFT TIMING (MANUAL TRANSMISSION) .
- Refer to the relevant instructions for blocking the camshafts under procedure for CHECKING CAMSHAFT TIMING (AUTOMATIC TRANSMISSION) or CHECKING CAMSHAFT TIMING (MANUAL TRANSMISSION) .
- Refer to REMOVING CHAIN TENSIONER
Follow-up work:
- Refer to CHECKING CAMSHAFT TIMING (AUTOMATIC TRANSMISSION) or CHECKING CAMSHAFT TIMING (MANUAL TRANSMISSION) .
- Disassemble all special tools
- Refer to INSTALLING CYLINDER HEAD COVER
- Refer to INSTALLING BOTH ACTUATORS
- Refer to PREPARING THE INJECTORS FOR INSTALLATION
- Refer to INSTALLING THE INJECTORS FOR THE CYLINDERS 1 TO 3
- Refer to INSTALLING THE INJECTORS FOR THE CYLINDERS 4 TO 6
- Refer to PREPARING FOR THE INSTALLATION OF THE HIGH PRESSURE PUMP
- Refer to INSTALLING HIGH PRESSURE PUMP
- Refer to INSTALLING FUEL DELIVERY LINE
- Refer to INSTALLING THE HIGH-PRESSURE LINE BETWEEN THE HIGH-PRESSURE RAIL AND THE HIGH-PRESSURE PUMP
- Refer to INSTALLING ALL SPARK PLUGS
- Refer to INSTALLING THE IGNITION COILS
- Refer to INSTALLING FRONT ENGINE ENCAPSULATION
- Refer to INSTALLING FAN COWL
- Refer to INSTALLING CLEAN AIR PIPE
- Refer to INSTALLING INTAKE SILENCER HOUSING
- Install the lower right engine bulkhead. Tightening torque: 19 Nm.
- Refer to INSTALLING ACOUSTIC COVER AT REAR
- Install tension strut on spring strut dome. Jointing torque: 56 Nm, angle of rotation: 90° NOTE: Replace screws.
- Install the sound insulation on the bulkhead upper part center
- Attach cowl panel cover
- Install both wiper arms
- Check the angle of attack of the wiper arms on the left and right
- Install the cover in the engine compartment on the left
- Install the cover in the engine compartment on the right
- Refer to INSTALLING STARTER MOTOR
- Disconnect all battery ground leads
- Connect the diagnostic system for possible integration level encoding and programming
- Refer to INSTALLING ACOUSTIC COVER
- Refer to INSTALLING REINFORCEMENT PLATE
- Install underbody protection at rear
- Install the front underbody protection
- Take hood out of the service position
- Check engine oil level and top up oil as necessary