Section 1789 (Body Equipment - Repair - E61)
WARNING: This page is about a different car, the 2008 BMW 535xi. However, it is still accessible from the selected car via links, so may be relevant.
- 00 General
- 51 00 .. Overview of front door
- 51 00 .. Overview of rear door
- 51 00 ... Notes on bonding/attaching components with double-sided adhesive tape
- 51 00 ... Notes on fitting window guide seals
- 51 00 ... Safety instructions for working on cars with airbag systems
- 51 00 ... Service position of engine hood/bonnet
- 51 00 ... Servicing position of rear lid
- 11 Front Bumper
- 51 11 ... Overview of front bumper
- 51 11 ... Installing/replacing license plate (without base)
- 51 11 ... Removing and installing/replacing cover for headlight washer unit on left
- 51 11 ... Removing and installing/replacing front fog lamp trim (M aerodynamic kit)
- 51 11 050 Removing and installing/replacing carrier for front bumper trim
- 51 11 156 Removing and installing front bumper trim
- 51 11 157 Replacing front bumper trim
- 51 11 158 Replacing baseplate for license plate
- 51 11 160 Removing and installing/replacing trim for air duct on bumper trim (from 03/2007)
- 51 11 160 Removing and installing/replacing trim for air duct on bumper trim (up to 03/2007)
- 51 11 180 Removing and installing/replacing grille in bumper trim (M5 or M aerodynamic kit)
- 51 11 180 Removing and installing/replacing trim grille in bumper trim (from 03/2007)
- 51 11 180 Removing and installing/replacing trim grille in bumper trim (up to 03/2007)
- 51 11 181 Removing and installing/replacing finisher rod on trim grille for front bumper trim
- 51 11 701 Replacing left or right bracket for front bumper
- 12 Rear Bumper
- 51 12 ... Removing and installing/replacing diffuser on rear bumper trim (M Technic aerodynamic kit)
- 51 12 ... Survey of rear bumper
- 51 12 050 Removing and installing/replacing carrier for rear bumper trim
- 51 12 156 Removing and installing rear bumper trim
- 51 12 157 Replacing rear bumper trim
- 51 12 801 Replacing bracket for rear bumper at left or right
- 51 12 810 Removing and installing / replacing deformation element on bumper carrier on left or right
- 51 12 826 Removing and installing/replacing guide for rear bumper
- 51 12 827 Removing and installing / replacing guide for bottom rear bumper
- 13 Trim, Covers, Handle Trim
- 51 13 ... Replacing front radiator grille, middle left or right
- 51 13 001 Removing and installing/replacing front radiator grille, middle left or right
- 51 13 115 Removing and installing/replacing cowl panel cover
- 51 13 280 Removing and installing trim strip on roof frame at left or right
- 51 13 305 Removing and installing/replacing left or right rail
- 14 BMW Emblems, Model Emblems
- 16 Mirrors/Covers/Ashtrays/Shelves/Trays
- 51 16 .. Overview of storage compartment (centre console)
- 51 16 ... Cementing of mirror base
- 51 16 ... Removing and installing / replacing front insert (on storage compartment trim)
- 51 16 ... Removing and installing/replacing centre armrest
- 51 16 ... Removing and installing/replacing centre armrest adjustment unit
- 51 16 ... Removing and installing/replacing centre console cover
- 51 16 ... Removing and installing/replacing driver's side storage compartment
- 51 16 ... Removing and installing/replacing finisher for storage tray at rear
- 51 16 ... Removing and installing/replacing front inner cup holder carrier
- 51 16 ... Removing and installing/replacing front outer cup holder carrier
- 51 16 ... Removing and installing/replacing rear insert (in storage compartment)
- 51 16 000 Removing and installing/replacing mirror on left or right front door
- 51 16 026 Replacing mirror glass
- 51 16 040 Removing and installing/replacing housing on left or right door mirror
- 51 16 045 Removing and installing/replacing retaining ring on left or right door mirror
- 51 16 060 Removing and installing/replacing interior rearview mirror (overview)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with Autobeam)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with Japanese toll mirror)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with mirror arm end caps)
- 51 16 060 Removing and installing/replacing interior rearview mirror (with rain sensor)
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 155 Replacing locator for front ashtray insert (from 03/2007)
- 51 16 155 Replacing locator for front ashtray insert (up to 03/2007)
- 51 16 200 Removing and installing storage compartment
- 51 16 201 Replacing storage compartment
- 51 16 202 Removing and installing/replacing front (inner or outer) cup holder
- 51 16 204 Removing and installing/replacing cup holder in armrest for rear seat backrest
- 51 16 210 Removing and installing/replacing trim for preselector lever (from 03/2007)
- 51 16 210 Removing and installing/replacing trim for preselector lever (up to 03/2007)
- 51 16 211 Removing and installing/replacing finisher for storage tray
- 51 16 325 Removing and installing/replacing fastener for centre armrest
- 51 16 340 Removing and installing/replacing lock for right glovebox
- 51 16 342 Removing and installing/replacing lock cylinder for passenger airbag deactivation
- 51 16 360 Removing and installing/replacing right glovebox
- 51 16 366 Removing and installing right glovebox with housing
- 51 16 400 Removing and installing/replacing roller sun blind on fixed side window of left or right rear door
- 51 16 405 Removing and installing/replacing roller sun blind on side window of left or right rear door (up to 03/2007)
- 51 16 405 Removing and installing/replacing roller sun blind on side window of left or right rear door (long version or from 03/2007)
- 51 16 450 Removing and installing/replacing rear left/right grab handle
- 51 16 480 Removing and installing or replacing front grab handle
- 17 Lids
- 21 Front Door Locks, Handles, Fittings
- 51 21 ... Overview of front door locks
- 51 21 ... Removing window cavity cover strip with special tool 00 9 324 at front or rear
- 51 21 003 Replacing door detent (lock striker), front left or right
- 51 21 004 Adjusting front left or right door detent (lock wedge)
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 125 Removing and installing/replacing carrier for left or right outside door handle with lock cylinder
- 51 21 126 Removing and installing/replacing carrier for left or right outside door handle without lock cylinder
- 51 21 140 Removing and installing/replacing complete lock cylinder in left or right front door
- 51 21 150 Blocking, if necessary initializing, car key in immobilizer control module
- 51 21 170 Removing and installing or replacing outside handle from left or right front door
- 51 21 180 Removing and installing/replacing cover on outside handle
- 51 21 200 Removing and installing/replacing outside handle and lock actuation of left or right front door
- 51 21 225 Removing and installing/replacing inside door opener for left or right front door (up to 03/2007)
- 51 21 225 Removing and installing/replacing inside door opener for left or right front door (long version or from 03/2007)
- 51 21 233 Removing and installing/replacing Bowden cable for outside door handle on left or right front door
- 51 21 235 Removing and installing/replacing Bowden cable for inside door opener on left or right front door
- 51 21 280 Removing and installing or replacing door brake on left or right front door
- 51 21 300 Removing and installing or replacing window cavity cover strip on outside of left or right front door
- 51 21 330 Removing and installing/replacing window cavity cover strip on inner front door
- 51 21 360 Replacing seal for door seam/roof frame on left or right front door
- 51 21 370 Removing and installing/replacing cover (seal) on front door at bottom left or right
- 22 Rear Door Locks, Handles, Fittings
- 51 22 ... Overview of rear door locks
- 51 22 ... Removing and installing/replacing side impact protection in left or right rear door
- 51 22 001 Replacing door detent (lock striker), rear left or right
- 51 22 004 Adjusting rear left or right door detent (lock wedges)
- 51 22 090 Removing and installing/replacing door lock in left or right rear door
- 51 22 126 Removing and installing/replacing carrier for outside door handle on left or right rear door
- 51 22 170 Removing and installing / replacing outside handle on left or right back door
- 51 22 180 Removing and installing/replacing cover on outside handle
- 51 22 225 Removing and installing/replacing inside door opener of rear left or right door
- 51 22 233 Removing and installing/replacing Bowden cable for outside door handle on left or right rear door
- 51 22 235 Removing and installing/replacing Bowden cable for inside door opener on left or right rear door
- 51 22 280 Removing and installing/replacing door retainer on rear left or right door
- 51 22 300 Removing and installing/replacing window cavity cover strip on rear door on left or right
- 51 22 330 Removing and installing/replacing window cavity cover strip on inside rear door
- 51 22 360 Replacing seal for door seam/roof frame on left or right rear door
- 51 22 370 Removing and installing/replacing cover at bottom left or right on rear door
- 23 Hood Latch, Locks
- 51 23 ... Adjusting/replacing bump stops
- 51 23 004 Adjusting hood/bonnet lock
- 51 23 100 Removing and installing/replacing right engine hood/bonnet lock
- 51 23 110 Removing and installing/replacing left hood/bonnet lock
- 51 23 131 Adjusting left or right striker on engine hood
- 51 23 160 Removing and installing/replacing arrester hook on engine hood
- 51 23 211 Removing and installing/replacing cable for front engine hood locks (to passenger compartment)
- 51 23 212 Removing and installing/replacing cable for front hood/bonnet locks (to locks)
- 51 23 265 Removing and installing/replacing left or right gas strut for engine bonnet/hood
- 24 Trunk Latch, Locks
- 51 24 ... Adjusting rear window lock
- 51 24 ... Instructions for automatic rear lid actuation (electrohydraulic/fully automatic)
- 51 24 ... Removing and installing/replacing trim on shaft bearing for rear window wiper
- 51 24 004 Adjusting rear lid lock
- 51 24 100 Removing and installing/replacing rear lid lock (upper section)
- 51 24 140 Removing and installing/replacing rear window lock
- 51 24 145 Removing and installing/replacing button for rear lid actuation
- 51 24 150 Removing and installing/replacing hydraulic control unit for operating rear lid (electrohydraulic/fully automatic)
- 51 24 151 Removing and installing/replacing hydraulic cylinder for rear lid (electrohydraulic/fully automatic)
- 51 24 152 Removing and installing/replacing hydraulic cylinder for rear lid (with slide/tilt sunroof)
- 51 24 300 Removing and installing or replacing left or right gas strut for trunk lid
- 51 24 660 Correcting fluid level in hydraulic unit for rear lid actuation (electrohydraulic-fully automatic)
- 31 Front And Rear Window
- 51 31 ... Instructions on gluing windscreen
- 51 31 ... Removing windscreen with "Roll Out 2000"
- 51 31 000 Removing and installing/replacing windscreen
- 51 31 015 Repairing damage to windscreens caused by pitting (stone chips) (clear and tinted laminated safety glass)
- 51 31 021 Removing and installing / replacing rubber frame for windscreen (top)
- 51 31 030 Removing and installing or replacing left or right gutter strip along windscreen
- 51 31 200 Removing and installing/replacing rear window
- 51 31 201 Adjusting rear window
- 32 Front Manually Operated Windows
- 51 32 154 Adjusting left or right front door window
- 51 32 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 32 170 Removing and installing/replacing door window glass, front left or right
- 51 32 211 Replacing front left or right rubber guide for left or right door window
- 51 32 390 Removing and installing / replacing decorative strip on front left or right door
- 51 32 420 Removing and installing/replacing trim on front door window frame, left or right
- 33 Front Electrically Operated Windows
- 34 Rear Manually Operated Windows
- 51 34 ... Removing and installing/replacing trim for window guide of left or right rear door
- 51 34 160 Removing and installing/replacing housing cover on inner left or right door window frame
- 51 34 171 Replacing rear left or right door window
- 51 34 191 Replacing left or right fixed door window in rear window frame
- 51 34 211 Replacing rubber guide for rear left or right door window
- 51 34 380 Removing and installing/replacing decorative strip on rear door (top), left or right
- 51 34 420 Removing and installing/replacing trim on window frame of rear door (front), left or right
- 51 34 425 Removing and installing/replacing trim on window frame of rear door, rear left or right
- 36 Hinged Window
- 37 Electrical Power Windows, Body
- 41 Front Door Trim Panel With Arm Rest
- 51 41 ... Replacing door pocket on front left or right door trim panel
- 51 41 000 Removing and installing front left or right door trim panel (long version or from 03/2007)
- 51 41 000 Removing and installing front left or right door trim panel (up to 03/2007)
- 51 41 001 Replacing front left or right door trim panel (long version or from 03/2007)
- 51 41 001 Replacing front left or right door trim panel (up to 03/2007)
- 51 41 017 Removing and installing/replacing cover on door handle, front left or right
- 51 41 018 Replacing speaker trim on front left or right door trim panel (long version or from 03/2007)
- 51 41 019 Removing and installing/replacing door handle on front left or right door trim panel (up to 03/2007)
- 51 41 019 Removing and installing/replacing door handle on front left or right door trim panel (long version or from 03/2007)
- 51 41 025 Replacing handle recess on front left or right door trim panel (long version or from 03/2007)
- 51 41 030 Removing and installing/replacing decorative strip on front left or right door trim panel (long version or from 03/2007)
- 51 41 060 Removing and installing/replacing armrest on front left or right door trim panel (up to 03/2007)
- 51 41 081 Replacing armrest on front left or right door trim panel (long version or from 03/2007)
- 42 Rear Door Trim Panel With Arm Rest
- 51 42 ... Removing and installing/replacing door pocket on rear left or right door trim panel (up to 03/2007)
- 51 42 000 Removing and installing rear left or right door trim panel (long version or from 03/2007)
- 51 42 000 Removing and installing rear left or right door trim panel (up to 03/2007)
- 51 42 001 Replacing rear left or right door trim panel (long version or from 03/2007)
- 51 42 001 Replacing rear left or right door trim panel (up to 03/2007)
- 51 42 017 Removing and installing/replacing cover on door handle, rear left or right
- 51 42 018 Replacing speaker trim on rear left or right door trim panel (long version or from 03/2007)
- 51 42 019 Removing and installing/replacing door handle on rear left or right door trim panel (up to 03/2007)
- 51 42 019 Removing and installing/replacing door handle on rear left or right door trim panel (long version or from 03/2007)
- 51 42 030 Removing and installing/replacing decorative strip on rear left or right door trim panel (long version or from 03/2007)
- 51 42 060 Removing and installing/replacing armrest on rear left or right door trim panel (up to 03/2007)
- 51 42 081 Replacing armrest on rear left or right door trim panel (long version or from 03/2007)
- 43 Side Covering With Armrests
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing / replacing side trim panel, footwell, on A-pillar, right
- 51 43 148 Removing and installing or replacing trim on left or right door pillar (top)
- 51 43 150 Removing and installing or replacing trim for left or right door pillar (bottom)
- 51 43 201 Removing and installing/replacing panel for roof pillar at front (A-pillar), left or right
- 51 43 251 Removing and installing/replacing trim panel for rear left or right roof pillar (C-pillar, rear)
- 51 43 255 Removing and installing/replacing trim panel for rear left or right roof pillar (C-pillar, front)
- 51 43 259 Removing and installing/replacing trim panel for rear left or right roof pillar (D-pillar)
- 51 43 259 Removing and installing/replacing trim panel for rear roof pillar (D-pillar with option SA316 from 03/2006), left or right (automatic rear lid actuation)
- 51 43 280 Removing and installing/replacing auto-remote opener for luggage compartment cover on left or right (from 03/2006 with option SA316) (automatic rear lid actuation)
- 51 43 290 Removing and installing/replacing read contact for comfort operation
- 51 43 291 Removing and installing/replacing drive unit for comfort operation
- 51 43 292 Removing and installing/replacing comfort operating unit
- 44 Roof Trim Panel
- 45 Instrument Cluster Trim Panel
- 51 45 ... Overview of instrument panel
- 51 45 ... Removing and installing/replacing trim on ashtray
- 51 45 030 Removing and installing instrument panel trim
- 51 45 031 Replacing instrument panel trim
- 51 45 115 Removing and installing speaker frame on panel for instrument panel at top
- 51 45 181 Removing and installing/replacing bottom right trim for instrument panel
- 51 45 185 Removing and installing/replacing panel for pedals
- 51 45 310 Removing and installing (replacing) centre instrument panel trim (from 03/2007)
- 51 45 310 Removing and installing (replacing) centre instrument panel trim (up to 03/2007)
- 51 45 314 Removing and installing/replacing centre (bottom) instrument panel trim
- 51 45 370 Removing and installing (replacing) left decorative strip on instrument panel
- 51 45 380 Removing and installing (replacing) right decorative strip on instrument panel
- 46 Parcel Shelf Trim Panel
- 47 Floor/Luggage/Engine Compartment Trim Panel
- 51 47 ... Overview of luggage compartment trim panels
- 51 47 ... Removing and installing/replacing floor panel underlay in luggage compartment on left or right
- 51 47 ... Removing and installing/replacing left or right underbody panelling
- 51 47 ... Removing and installing/replacing luggage compartment floor storage tub
- 51 47 ... Removing and installing/replacing luggage compartment floor trim panel (with stowage pack)
- 51 47 ... Removing and installing/replacing storage tray in luggage compartment on left
- 51 47 000 Removing and installing/replacing front (inside) left or right entrance cover strip
- 51 47 030 Removing and installing/replacing rear (inside) left or right entrance cover strip
- 51 47 065 Removing and installing / replacing finishing strip at front left or right entrance
- 51 47 072 Removing and installing/replacing finishing strip at rear left or right entrance
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 126 Replacing handle on panel for luggage compartment floor
- 51 47 127 Replacing lock cylinder on panel for luggage compartment floor
- 51 47 131 Replacing front panel for luggage compartment floor
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 47 156 Removing and installing/replacing left or right capping in luggage compartment
- 51 47 157 Removing and installing/replacing cover for left or right capping in luggage compartment
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch trim
- 51 47 172 Removing and installing / replacing flap in luggage compartment trim, left or right
- 51 47 305 Removing and installing/replacing stowage net in front footwell
- 51 47 312 Replacing footrest for front passenger compartment
- 51 47 315 Removing and installing / replacing front carpet for passenger compartment
- 51 47 440 Removing and installing/replacing rear carpet on seat pan
- 51 47 490 Removing and installing / replacing front underbody protection
- 51 47 491 Removing and installing/replacing rear underbody protection
- 48 Front Lid Insulation Lining
- 49 Rear Lid Trim Panel
- 51 49 000 Removing and installing or replacing trim for rear lid
- 51 49 003 Removing and installing/replacing trim for rear window frame on left or right
- 51 49 013 Removing and installing/replacing trim for rear window frame at top
- 51 49 020 Removing and installing/replacing (inner) panel for rear window frame
- 51 49 022 Removing and installing/replacing side (inner) panel for rear lid
- 71 Gaskets/Seals, Loose Body Parts
- 51 71 ... Removing and installing/replacing front (bottom) right wheel arch trim
- 51 71 ... Replacing rear roof seal
- 51 71 000 Removing and installing/replacing seal on front door, left or right
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing rear left or right wheel arch cover
- 51 71 200 Removing and installing/replacing seal on rear door, left or right
- 51 71 373 Removing and installing/replacing tension strut on spring strut dome
- 51 71 407 Replacing rear spoiler
- 51 71 412 Removing and installing rear spoiler
- 51 71 447 Removing and installing or replacing panel for cover on left or right side member
- 51 71 482 Removing and installing/replacing left or right tension strut (on rear axle)
- 51 71 484 Removing and installing/replacing cross strut/rear end