Maintenance And General Information -- Repair (G42)

• 00 00 General Maintenance
  • Symbols used and information in repair instructions
  • Care measures for vehicles in stock (new and used vehicles) (new and used vehicles) (new and used vehicles)
  • When driving on a race track
  • Work instruction for removing the protective film
  • 00 00 009 Free pre-delivery check
    • Resetting transport mode and the performing pre-delivery check with the diagnostic system
    • Enabling the navigation map and checking the version
    • Programming wheel electronics (only while using Tire Pressure Monitor SA2VB)
    • Checking tire inflation pressure (only while using tire pressure monitor SA2VB)
    • Checking the tire pressure and resetting the Tire Pressure Monitor
    • Activating the automatic headlight control
    • Top off the washer fluid for the washer system
  • 00 00 105 Standard scope of service
    • Checking the function of the parking brake without roller test stand
    • Check the indicator lights and warning lights
    • Checking Check Control messages
    • For sliding/tilting sunroof or panorama glass roof: Check the guide rails and water drain channels for contamination
    • Recommendation: Check tires
  • 00 00 252 BMW engine oil service without supplementary service (230i, 230i xDrive)
    • Removing the oil filler cap
    • Removing the oil filter element
    • Releasing the oil drain plug
    • Tightening the oil drain plug
    • Replace oil filter element
    • Installing the oil filter element
    • Topping up the motor oil
    • Installing the oil filler cap
    • Recommendation: Carrying out an electronic oil measurement
  • 00 00 602 Service air filter insert (230i, 230i xDrive)
    • Remove air filter insert
    • Installing the air filter insert
  • 00 00 606 Servicing particulate filter (230i, 230i xDrive)
    • Removing the gasoline particulate filter
    • Installing gasoline particulate filter
  • 00 00 610 Engine oil service (230i, 230i xDrive)
    • Removing the oil filler cap
    • Removing the oil filter element
    • Releasing the oil drain plug
    • Tightening the oil drain plug
    • Replace oil filter element
    • Installing the oil filter element
    • Topping up the motor oil
    • Installing the oil filler cap
    • Recommendation: Carrying out an electronic oil measurement
  • 00 00 612 Service - front brakes
    • Removing the front brake pads
    • Measuring the minimum brake disc thickness (front brake)
    • Grease the brake pads, brake anchor plate and brake caliper using brake pad paste (17 inch brake)
    • Installing front brake pads
  • 00 00 614 Rear brakes service
    • Remove rear brake pads
    • Measure minimum brake disc thickness (rear brake)
    • Greasing the brake pads, the brake anchor plate and the brake caliper with brake pad paste
    • Installing rear brake pads
  • (00 00 616 Service - micro-filter)
    • (Remove microfilter)
    • (Installing the micro-filter)
  • 00 00 618 Brake fluid service
    • Flush and vent the rear axle brake circuit
    • Flushing and bleeding the front axle brake circuit
  • 00 00 622 Spark plugs service (230i, 230i xDrive)
    • Removing all spark plugs
    • Installing all spark plugs
  • 00 00 624 Vehicle check service
    • Check tires (if available, emergency wheel also)
    • Checking the underbody and all visible components
    • Check brake lines and the brake line connections
    • Check the components of the steering
  • 00 00 687 Checking gas pressure springs for hood
    • Checking the expiry of the gas pressure springs for hood and, if necessary, replacing them
  • 00 00 741 Suspension block pre-delivery check
    • Removing the spring blocker
  • 00 00 742 Pre-delivery check of service and parking brakes with transport and immobilization periods of 3-6 weeks
    • Checking the service and parking brake for function
  • 00 00 744 Pre-delivery check, service brake and electromechanical parking brake for transport and immobilization periods over 6 weeks
    • Bedding in (brake) the service and electromechanical parking brake
  • 00 00 252 BMW engine oil service without supplementary service (M240i, M240i xDrive)
    • Removing the oil filler cap
    • Removing the oil filter element
    • Opening the service flap in the center underbody protection
    • Releasing the oil drain plug
    • Tightening the oil drain plug
    • Closing the service flap in the center underbody protection
    • Replace oil filter element
    • Installing the oil filter element
    • Filling engine oil
    • Opening the oil filler cap
    • Recommendation: Carrying out an electronic oil measurement
  • 00 00 602 Service air filter insert (M240i, M240i xDrive)
    • Remove air filter insert
    • Installing the air filter insert
  • 00 00 606 Servicing particulate filter (M240i, M240i xDrive)
    • Removing the gasoline particulate filter
    • Installing gasoline particulate filter
  • 00 00 610 Engine oil service (M240i, M240i xDrive)
    • Removing the oil filter element
    • Removing the oil filler cap
    • Opening the service flap in the center underbody protection
    • Releasing the oil drain plug
    • Tightening the oil drain plug
    • Closing the service flap in the center underbody protection
    • Replace oil filter element
    • Installing the oil filter element
    • Filling engine oil
    • Opening the oil filler cap
    • Recommendation: Carrying out an electronic oil measurement
  • 00 00 622 Spark plugs service (M240i, M240i xDrive)
    • Removing all spark plugs
    • Installing all spark plugs
• 00 02 Vehicle Lifting
  • 00 02 000 Raising vehicle with floor jack
    • Raising the vehicle with the side floor jack
    • Raising the vehicle with the front floor jack
    • If installed: Raising the vehicle using the front floor jack (for equipment specification with skid plate)
    • Raising the vehicle with the rear floor jack
  • 00 02 001 Raising the vehicle with a vehicle lift
    • Overview
    • Lifting the vehicle using a vehicle lift with running rails
    • Lift vehicle using a vehicle lift with swivel arms
• 00 10 Transmission Service, Differential Service
  • 00 11 237 Checking/topping up the oil level in the automatic transmission
    • Checking/topping up the oil level in the automatic transmission
  • 00 11 259 Oil change in the rear differential
    • Drawing off oil in the rear differential
    • Check/top up oil level in the rear differential
  • 00 11 265 Oil change in front differential (230i xDrive, M240i xDrive)
    • Topping up/checking front differential oil