Section 199 (Gearbox Aw55-50 - Installation)
WARNING: This page does not describe the selected car, but rather 8 other vehicles, including the 2006 Volvo S80, 2005 Volvo S80, 2004 Volvo S80, 2003 Volvo S80, and 2002 Volvo S80. However, it is still accessible from the selected car via links, so may be relevant.
- Transmission
- Installing the gearbox
- Notes
- Installation
- Notes
- Installing the gearbox
- Installing and tightening the screws to the gearbox
- Fitting the torque converter screws.
- Lifting the engine/gearbox
- Installing the rear engine mounting
- Installing the angle gear
- Installing the lower oil pipe to the gearbox
- Installing the left-hand drive shaft to the gearbox and the wheel spindle
- Fitting the subframe to the body
- Installing the right-hand drive shaft to the gearbox, wheel spindle and link arm
- Tightening the subframe screws (both sides)
- Fitting the screws for engine pads and the torque rod bracket in the gearbox
- Installing the steering wheel shaft joint
- Installing the collision protection system over the steering gear
- Installing the crossmembers
- Installing and tightening the front suspension components
- Installing the cable conduit
- Removing the lifting beam
- Installing the water hose
- Fitting the remaining screws to the gearbox/starter motor
- Installing the gear selector cables and oil line
- Installing service clips
- Installing engine compartment components
- Finishing
- Installing the gearbox