Section 150 (Manual HVAC System)
WARNING: This page is about a different car, the 2003 Suzuki Vitara, 2003 Suzuki Grand Vitara, 2002 Suzuki Vitara, and 2002 Suzuki Grand Vitara. However, it is still accessible from the selected car via links, so may be relevant.
- Precautions
- General Description
- Schematic and Routing Diagram
- Components Location
- Diagnostic Information and Procedures
- A/C System Symptom Diagnosis
- Abnormal Noise Diagnosis
- Compressor System Diagnosis
- Performance Diagnosis of A/C System
- Notes
- Performance Diagnosis Table
- Detail Diagnosis Table (at Ambient Temperature within 30 -35°C (85 - 95°F))
- Inspection of A/C Controller and Its Circuits
- Voltage Check
- System Circuit
- Terminal Arrangement of A/C Controller
- Terminal Arrangement of ECM
- A/C Controller Voltage Values Table
- Inspection of Idle Speed with A/C ON
- Repair Instructions.
- Operation Procedure for Charging A/C with Refrigerant
- A/C Condenser Assembly On-Vehicle Inspection
- A/C Condenser Assembly Removal and Installation
- A/C Condenser Fan Assembly Inspection
- Desiccant (Receiver/Dryer) Removal & Installation
- A/C Filter Element Removal and Installation
- A/C Filter Element Cleaning
- Evaporator (Cooling Unit) Removal and Installation
- Evaporator (Cooling Unit) Disassembly & Assembly
- Evaporator (Cooling Unit) Inspection
- Expansion Valve Removal and Installation
- Expansion Valve Inspection
- A/C Evaporator Thermistor (Evaporator Temperature Sensor) Removal & Installation
- A/C Evaporator Thermistor (Evaporator Temperature Sensor) Inspection
- Refrigerant Pipes and Hoses On-Vehicle Inspection
- Refrigerant Pipes and Hoses Removal and Installation
- A/C Switch Removal and Installation
- A/C Switch Inspection
- A/C Controller Removal & Installation
- Dual (Refrigerant) Pressure Switch Inspection
- A/C Compressor Relay and Condenser Fan Motor Relay Inspection
- Compressor On-Vehicle Inspection
- Compressor Removal & Installation
- Magnet Clutch Components
- Magnet Clutch Inspection
- Magnet Clutch Removal and Installation
- Specifications
- Special Tools and Equipment