Overview for service sheet - AP00.20-P-1228OC

MODEL 212 (Countries with high dust levels) 

MODIFICATION NOTES

15.12.14

New in Service B: Check the coolant level in the low temperature circuit coolant expansion reservoir.

Fig 1: Overview For Service Sheet (Countries With High Dust Levels)

Courtesy of MERCEDES-BENZ USA

A	B	Z		Input condition not OK:	ⓧ
Completed
			Service reception
□	□		The completely edited reception report for service on vehicle is available	----------	◦
						AP00.20-P-0009Z
					To be performed by the Service Advisor  (where market-specific conditions require). The service scope is only fully performed when all acceptance items and the maintenance items listed in the service sheet have been processed.
			Brake system
□	□		Perform brake test and enter the result in the table	----------	◦
						AP42.00-P-4290BA
			Vehicle front end, vehicle rear end
	□		Check exterior lights for proper operation	----------	◦
						AP82.10-P-8252EW
	□		Check operation of headlamp range adjustment	----------	◦
				Vehicles with active headlamps or headlamp range controller on exterior lights switch
						AP82.10-P-8250EW
	□		Check and correct the adjustment of the headlamps	----------	◦
				With xenon or LED headlamps: Correct the setting, subject to a separate repair order.
			Vehicle interior
	□		Check windshield wipers, windshield washer system and headlamp cleaning system for proper operation	----------	◦
						AP82.30-P-8252EW
□	□		Check starter	----------	◦
				Model 212.095/098/195/298		AP15.30-P-1550AA
□	□		Replace activated charcoal dust filter	----------
						AP83.00-P-8384EW
			Engine compartment
□	□		Clean water drain	----------
						AP82.35-P-8232A
□	□		Brake system: Check fluid level	----------	◦
						AP42.10-P-4210EW
	□		Check visible area of poly-V belt for wear	----------	◦
						AP13.22-P-1352EW
	□		Power steering: check fluid level	----------	◦
				Except CODE 211 (Direct-Steer system)		AP46.00-P-4612EW
	□		Check the coolant level in the low temperature circuit coolant expansion reservoir	----------	◦
	□		Check all visible parts in engine compartment for damage and leaks	----------	◦
						AP00.20-P-0055EW
			Underside of vehicle
	□		Check tires for damage and cracking and enter result in table	----------	◦
						AP40.10-P-4051EW
	□		Check front axle ball joint for play, check boots	----------	◦
						AP33.20-P-3353EW
	□		Check track rod and drag link linkage for play, check boots	----------	◦
						AP46.00-P-4653EW
	□		Check propeller shaft flex disks for signs of damage and deformation	----------	◦
						AP41.10-P-4152EW
	□		Check all visible parts of vehicle underside for damage and leakage	----------	◦
						AP00.20-P-0054EW
				The country-specific regulations for mobility and body shell complaints apply.
			Vehicle interior  Plus package
		□	Check lamps in instrument cluster and interior illumination	----------	◦
						AP54.30-P-5453EW
			Tires, brakes  Plus package
		□	Correct tire pressure and enter set tire pressure in the table	----------	◦
						AP40.15-P-4061A
			Trunk  Plus package
		□	Check spare wheel tire pressure, correct and enter set tire pressure in the table	----------	◦
				Vehicles with spare tire
						AP40.15-P-4061A
		□	Check TIREFIT tire sealant	----------	◦
				Vehicles fitted with TIREFIT
						AP40.10-P-4054R
				Enter TIREFIT expiration date here: _________________ When the TIREFIT expiration date is reached: ↓ Replace TIREFIT, invoice as additional operation.
		□	Check first aid kit	----------	◦
						AP68.00-P-6850EW
				Enter first aid kit expiration date here: _________________ When the expiration date of first-aid kit is reached: ↓ Replace first-aid kit, invoice as an additional operation.
		□	Check luggage compartment illumination for proper operation	----------	◦
			Engine compartment Plus package
		□	Windshield washer system: Check/correct fluid level	----------	◦
						AP82.35-P-8210EW
				Use summer/winter cleaner depending on season.
			Vehicle interior  For every service (equipment specific)
		□	Check ex factory driving aids	----------	◦
				Vehicles with ex factory driving aids
						AP86.20-P-8649U
			Trunk  For every service (equipment specific)
		□	AdBlue® tank: Correct fluid level	----------
				Engine 642, 651 with code U42 (BlueTEC (SCR) diesel exhaust treatment) or with code U77 (BLUETEC (SCR) diesel exhaust treatment) Fill AdBlue container, invoice as additional operation.		AP14.40-P-1410BT
			Engine compartment  Service 3 At every service
		□	Engine: Change oil and filter	----------
				Engine 156		AP18.00-P-0101TMG
				Engine 157		AP18.00-P-0101EWG
				Engine 271		AP18.00-P-0101AB
				ENGINE 272.923/952/980/983		AP18.00-P-0101PIT
				ENGINE 272.977		AP18.00-P-0101VA
				Engine 273		AP18.00-P-0101SX
				Engine 274.910		AP18.00-P-0101CWF
				Engine 274.920		AP18.00-P-0101CWH
				Engine 276		AP18.00-P-0101CWZ
				Engine 278		AP18.00-P-0101EW
				Engine 642		AP18.00-P-0101EWO
				Engine 651		AP18.00-P-0101CWA
			Vehicle front end, vehicle rear end  Service 15 at every Service B
		□	Check condition and operation of trailer hitch	----------
				with CODE (550) Trailer hitch		AP31.11-P-3152EW
			Engine compartment  Service 4 Every 2 years
		□	Brake system: Replace brake fluid	----------
						AP42.00-P-4280EW
			Underside of vehicle  Once at 3, 000 km (1, 850 mi)
		□	Rear axle: Perform oil change	----------
				With code 471 (Mechanical locking differential) or with code P30 (AMG Performance Package)		AP35.00-P-3501CMG
			Underside of vehicle  Service 20 Once every 50, 000_km (31, 000_mi)/3 years
		□	Automatic transmission: Carry out oil and filter change	----------
				Engine 271.860 with transmission 722.6 (NAG1)		AP27.00-P-2702EW
				Engine 156, 272, 273, 642 transmission 722.9 (NAG2)		AP27.00-P-2702W
				Engine 157 with transmission 722.9 (NAG2-V Sport)		AP27.00-P-2702W
			Engine compartment  Service 8 Every 50, 000 km (31, 000 mi)/3 years
		□	Replace air filter element	----------
				Engine 156		AP09.10-P-0980CMG
				Engine 157		AP09.10-P-0980AB
			Underside of vehicle  Service 8 Every 50, 000 km (31, 000 mi)/3 years
		□	Rear axle: Perform oil change	----------
				With code 471 (Mechanical locking differential) or with code P30 (AMG Performance Package)		AP35.00-P-3501CMG
			Vehicle interior  Service 10 every 50, 000 km (31, 000 miles)/3 years
		□	Panoramic sliding roof: clean and lubricate guide mechanism	----------
				With CODE 413 (Panoramic sliding sunroof)		AP77.20-P-7732EW
			Engine compartment  Service 12 every 50, 000 km (31, 000 miles)/3 years
		□	Replace spark plugs	----------
				Engine 271.9 with code 924 (Bivalent natural gas drive)		AP15.10-P-1580CW
				Engine 274 with code 924 (Bivalent natural gas drive)		AP15.10-P-1580CWF
			Engine compartment  Service 8 every 75, 000 km (46, 500 miles)/4 years
		□	Replace air filter element	----------
				Engine 271.8		AP09.10-P-0980CWT
				Engine 271.9		AP09.10-P-0980CW
				Engine 272, 273		AP09.10-P-0980EW
				Engine 274 with code 924 (Bivalent natural gas drive)		AP09.10-P-0980CWG
				ENGINE 274 except CODE 924 (Bivalent natural gas drive)		AP09.10-P-0980CWF
				ENGINE 276.8		AP09.10-P-0980E
				ENGINE 276.9		AP09.10-P-0980MM
				Engine 278		AP09.10-P-0980AB
				Engine 642		AP09.10-P-0980NEU
				Engine 651		AP09.10-P-0980EWD
			Engine compartment  Service 11 Every 75, 000 km (46, 500 mi)/4 years
		□	Replace fuel filter	----------
				Engine 642		AP47.20-P-0780EWO
				Engine 651		AP47.20-P-0780EWD
			Engine compartment  Service 12 Every 75, 000 km (46, 500 miles)/4 years
		□	Replace spark plugs	----------
				Engine 156		AP15.10-P-1580CMG
				Engine 157, 272, 273, 276, 278		AP15.10-P-1580EW
				Engine 271.8		AP15.10-P-1580CW
				ENGINE 274 except CODE 924 (Bivalent natural gas drive)		AP15.10-P-1580CWF
			Underside of vehicle  Service 20 Every 100, 000 km (62, 000 mi)/5 years
		□	Automatic transmission: Carry out oil and filter change	----------
				ENGINE 276, 651 with TRANSMISSION 724.2		AP27.00-P-2702A
			Underside of vehicle  Service 20 every 125, 000 km (77, 500 miles)/5 years
		□	Automatic transmission: Carry out oil and filter change	----------
				ENGINE 271, 274, 276, 278, 642, 651 with TRANSMISSION 722.9 (NAG2-FE+)		AP27.00-P-2702W
				Engine 278, 642, 651 with transmission 725.0 (NAT 3)		AP27.00-P-2702B
			Vehicle interior  Service 11 every 250, 000 km (155, 000 mi)/15 years
		□	Replace fuel filter	----------
				ENGINE 156, 157, 271, 272, 273, 274, 276, 278		AP47.20-P-0780EW
			Underside of vehicle  Service 13 Every 250, 000 km (155, 000 mi)/15 years
		□	Refill with new coolant	----------
						AP20.00-P-2080EW

BRAKE VALUES

	Left	Right
Front
Rear
Parking brake

TIRE CONDITION

	Right front Left front	Right rear	Left rear
Condition OK
Condition NOT OK

SET TIRE PRESSURE IN BAR OR PSI

	Front axle	Rear axle	Spare wheel
bar/psi