Body Equipment - Repair (F56) -- Cooper, F56
- Safety And General Information
- (00 Safety information for working on vehicles with automatic engine start-stop function (MSA))
- (Safety at work)
- 51 00... Safety instructions for working on vehicles with airbag systems
- Information on vehicle protection
- Notes on component bonding with adhesive tape
- Notes
- Repair Notes For Bonded Seals
- Handling Rubber Seal Profiles
- REPAIR PART 1 OF 3 - Clean faulty areas
- REPAIR PART 2 OF 3 - Apply adhesive
- REPAIR PART 3 OF 3 - Press in rubber seal
- REPLACEMENT PART 1 OF 6 - Peeling off the faulty rubber seal
- REPLACEMENT PART 2 OF 6 - Clean bonding surface
- REPLACEMENT PART 3 OF 6 - Detach protective film of the bonding surface
- REPLACEMENT PART 4 OF 6 - Apply rubber seal
- REPLACEMENT PART 5 OF 6 - Establish sealing joint
- REPLACEMENT PART 6 OF 6 - Press gasket
- Checking The Rubber Seal
- Notes on film bonding
- Notes on installation of rubber window seals
- Touching up paintwork damage
- Overview of consumables
- 41 00... Replace bolts
- 41 00... Replacing blind rivets
- Bumper, Front
- General notes for labelling with adhesive films
- 51 11... Installing/replacing license plate (without number plate baseplate)
- 51 11 Removing and installing/replacing the air inlet frame for the left or right brake ventilation duct (Cooper S)
- 51 11... Removing and installing/replacing ornamental grille on bumper cover front left or right (Cooper JCW)
- 51 11.. Removing and installing/replacing mounting for fog light on front left or right (Cooper JCW)
- 51 11 Removing and mounting/exchanging side cover of front bumper (Cooper S and JCW)
- 51 11 050 Removing and installing/replacing support for front bumper
- 51 11 060 Removing and installing/replacing support for front lower bumper panel
- 51 11 152 Remove and install/replace the center spoiler on bumper panel (Cooper & Cooper S)
- 51 11 152 Remove and install/replace the center spoiler on bumper panel (Cooper JCW)
- 51 11 156 Removing and installing front bumper panel
- 51 11 157 Replacing bumper panel, front (Cooper S)
- 51 11 157 Replacing bumper panel, front (Cooper JCW)
- 51 11 158 Replacing base plate for number/license plate
- 51 11 180 Removing and installing/replacing ornamental grille in bumper panel (Cooper and Cooper S)
- 51 11 180 Removing and installing/replacing ornamental grille in bumper panel (Cooper JCW)
- 51 11 300 Removing and installing/replacing center trim (Cooper JCW)
- 51 11 760 Remove and install/replace deformation element for front left bumper
- 51 11 761 Remove and install/replace deformation element for front right bumper
- 51 11 780 Replacing the front deformation element on the bottom left
- 51 11 781 Replacing the front deformation element on the bottom right
- Bumper, Rear
- 51 12 050 Removing and installing/replacing support for rear bumper panel
- 51 12 070 Replacing the center spoiler on rear bumper panel
- 51 12 090 Removing and installing/replacing ornamental grille in bumper trim (Cooper S)
- 51 12 090 Removing and installing/replacing side ornamental grille in bumper panel (Cooper JCW)
- 51 12 156 Removing and installing rear bumper panel
- 51 12... Removing and installing/replacing insert in bumper cover (JCW)
- 51 12 828 Removing and installing/replacing guide for bumper, rear left or right
- Exterior Trim / Covers
- 51 13 000 Removing and installing/replacing front grille center section (Cooper & Cooper S)
- 51 13 000 Remove and install/replace front ornamental grille center section (Cooper JCW)
- 51 13 005 Removing and installing/replacing ornamental grille frame (Cooper & Cooper S)
- 51 13 003 Remove and install/replace front ornamental grille frame (Cooper JCW)
- 51 13 015 Removing and installing/replacing trim ring for left or right headlight (Cooper JCW)
- 51 13 022 Removing and installing/replacing front compartment lid air duct (Cooper S & Cooper JCW)
- 51 13 085 Removing and installing/replacing trim strip on engine compartment lid (cowl panel)
- 51 13 091 Removing and installing/replacing front side panel trim strip, left or right
- 51 13 102 Removing and installing/replacing trim on front left or right wheel arch
- 51 13 105 Removing and installing/replacing trim on rear left or right wheel arch
- 51 13 123 Remove and fit/replace left cowl panel cover
- 51 13 124 Remove and fit/replace right cowl panel cover
- 51 13 301 Removing and installing/replacing left or right roof trim strip
- 51 13 305 Removing and installing/replacing left or right roof railing
- 51 13 375 Removing and installing/replacing cover on left or right rear roof pillar (C-pillar)
- 51 13 402 Removing and installing/replacing the tailgate handle strip
- 51 13 425 Removing and installing/replacing cover on left or right rear light
- Emblems / Badges
- Interior Trim / Accessories
- 51 16... Calibrating the compass on the inside mirror
- 51 16 000 Removing and installing/replacing the left or right exterior mirror on the front door
- 51 16 026 Replacing mirror glass
- 51 16 041 Removing and installing/replacing protective cap on left or right exterior mirror
- 51 16 063 Removing and installing/replacing interior mirror (as of 07/2011)
- 51 16 063 Removing and installing/replacing interior mirror (overview)
- 51 16 080 Removing and installing or replacing sun visor and left or right counter support
- 51 16 085 Removing and installing/replacing sun visor and counter support on driver's side (side)
- 51 16 165 Removing and installing/replacing complete center console
- 51 16 204 Removing and installing/replacing rear cup holder
- 51 16 206 Removing and installing/replacing center armrest
- 51 16 365 Removing and installing/replacing glove box cover
- 51 16 366 Removing and installing/replacing right glove box with housing
- 51 16 383 Removing and installing/replacing damper for glove box
- 51 16 480 Removing and installing or replacing front grab handle
- 51 45 460 Removing and installing/replacing upper instrument panel storage compartment
- Fuel Filler Flap, Cover Bowl
- Front Door Locks, Handles, Fittings
- 51 21 003 Replacing front left or right lock striker
- 51 21 004 Adjusting front left or right lock striker
- 51 21 090 Removing and installing/replacing door lock in left or right front door
- 51 21 125 Removing and installing/replacing support for left or right outer door handle with lock barrel
- 51 21 125 Removing and installing/replacing support for left or right outer door handle without lock barrel
- 51 21 140 Removing and installing/replacing complete lock barrel in left or right front door
- 51 21 170 Removing and installing/replacing the outer door handle of front door on the left or right
- 51 21 225 Removing and installing or replacing inside door opener in left or right front door
- 51 21 233 Removing and installing/replacing Bowden cable for outer door handle on left or right front door
- 51 21 235 Remove and install/replace Bowden cable for inner door opener on left or right front door
- 51 21 280 Remove and install/replace door stop of the front left or front right door
- 51 21 300 Removing and installing/replacing weather strip on outside of front door
- 51 21 330 Removing and installing/replacing the weather strip on the inside of the front door
- 51 21... Removing window channel strip with special tools
- 51 21 370 Removing and installing/replacing the cover on the bottom left or right of the front door
- Hood Latch, Locks
- 51 23... Adjusting/replacing bump stops
- 51 23... Removing/installing ball sockets with clip
- 51 23 004 Adjusting engine compartment lid catch
- 51 23 100 Removing and installing/replacing right engine compartment lid lock
- 51 23 110 Removing and installing/replacing left engine compartment lid lock
- 51 23 131 Removing and installing/replacing striker on engine compartment lid
- 51 23 211 Removing and installing/replacing cable for front engine compartment locks (in engine compartment)
- 51 23 212 Removing and installing/replacing cable for engine compartment lock, front (in passenger compartment)
- 51 23 265 Removing and installing/replacing left or right gas pressure spring for engine compartment lid
- 51 23 400 Removing and installing/replacing left or right actuator (active pedestrian protection)
- Tailgate Latch, Locks
- 51 24 004 Adjusting rear lid lock
- 51 24 105 Removing and installing/replacing rear lid lock
- 51 24 130 Removing and installing/replacing striker for tailgate lock
- 51 24 146 Removing and installing/replacing button for rear lid actuation
- 51 24 300 Removing and installing or replacing left or right gas pressure spring for tailgate
- Windscreen And Rear Window
- General procedure for the disassembly and installation of bonded window glass
- 51 31 015 Repairing damage to windscreen caused by stone chips (clear and tinted laminated safety glass)
- Materials for bonding window
- Notes on window bonding repair kit
- Overview, rain sensor (additional work when replacing the windshield/sensor replacement)
- Overview of additional work for the removal and installation or replacement of electronic components in the body area/windshield
- 51 31... Remove windshield with "Roll Out 2000"
- 51 31... Removing windows with a "Spider"
- 51 31... Removing windows with an oscillating knife
- 51 31... Window glass removal with wire pull handle
- Notes for bonding sound insulation (SI), doors
- 51 31 011 Replacing windscreen
- 51 31 021 Removing and installing/replacing rubber frame for windscreen (top)
- 51 31 045 Removing and installing/replacing trim for left or right A-pillar
- 51 31 200 Removing and installing/replacing rear window
- 51 31 284 Removing and installing/replacing lower cover on rear window
- Side Windows
- Power Window Regulator
- Hinged Side Window
- Front Door Interior Trim / Panels
- Interior Side Trim Panels
- 51 43 002 Removing and installing (replacing) rear left or right side trim panel
- 51 43 070 Removing and installing/replacing side trim panel, footwell, on A-pillar, left
- 51 43 075 Removing and installing/replacing side trim panel, footwell, on A-pillar, right
- 51 43 148 Removing and installing or replacing trim panel on left or right door post (top)
- 51 43 201 Removing and installing or replacing trim for roof pillar at front (A-pillar), left or right
- 51 43 251 Removing and installing or replacing trim panel for left or right rear roof pillar (C-pillar)
- Headlining
- Trim Panels, Dashboard / Instrument Panel
- 51 45... Removing and installing/replacing side panel on dashboard on left or right
- 51 45... Removing and installing (replacing) side center console trim panel
- 51 45 030 Removing and installing instrument panel trim
- 51 45 031 Replacing instrument panel trim
- 51 45 075 Removing and installing/replacing support for instrument panel (Version 1)
- 51 45 075 Removing and installing/replacing support for instrument panel (Version 2)
- 51 45 080 Replacing decorative strip of right storage compartment
- 51 45 106 Removing and installing (replacing) function support on instrument panel trim
- 51 45 180 Removing and installing/replacing lower left instrument panel trim
- 51 45 195 Removing and installing/replacing lower right instrument panel trim
- 51 45 370 Removing and installing (replacing) left decorative strip on dashboard
- 51 45 380 Removing and installing (replacing) right decorative strip on dashboard
- 51 45 435 Removing and installing/replacing cover for instruments
- 51 45 460 Removing and installing/replacing upper instrument panel storage compartment
- Trim Panels, Rear Interior
- Floor/Luggage Compartment/Engine Compartment Trim Panels, Floor Mats
- 51 47 000 Removing and installing/replacing front left or right door sill cover strip
- 51 47 101 Removing and installing/replacing luggage compartment floor trim panel
- 51 47 151 Removing and installing/replacing left luggage compartment wheel arch trim
- 51 47 161 Removing and installing/replacing right luggage compartment wheel arch panel
- 51 47 312 Replacing footrest for front vehicle interior
- 51 47 314 Removing and installing/replacing carpet for passenger compartment
- 51 47 490 Removing and installing/replacing underbody protection (front)
- 51 47 491 Removing refitting/replacing rear engine undercover
- 51 75 001 Removing and installing/replacing left or right underbody cover
- Sound Insulation
- Trim Panel, Rear Lid / Window Frame
- Exterior Body Trim
- 51 71 040 Removing and installing/replacing front left or right wheel arch cover
- 51 71 041 Removing and installing/replacing the rear left or right wheel arch cover
- 51 71... Remove and install/replace left or right lower front brake air duct (Cooper JCW)
- 51 71 096 Removing and installing/replacing the automatic air flap control
- 51 71 360 Remove and install/replace sealing for tailgate
- 51 71 412 Removing and installing/replacing rear spoiler (Cooper & Cooper S)
- 51 71 412 Removing and installing/replacing rear spoiler (Cooper JCW)
- 51 71 418 Replacing cover on trim panel for cover on side member, left or right
- 51 71 447 Detaching and attaching/replacing trim panel for left or right side sill
- Seals / Door Edge Protection
- Underbody Panels
- Roof Frame Seal