Rear Axle - Repair (R60) -- Cooper Countryman

• Safety And General Information
  • 00..... Safety instructions for handling oil
    • Notes
    • 00 Risk of injury if oil comes into contact with eyes and skin
    • 00..... Danger of poisoning if oil is ingested/absorbed through the skin
  • 00..... Raising vehicle with trolley jack
  • 31 00... Notes on wheel bearing replacement following accident damage
  • 33 00... Information on replacing shock absorbers
  • 33..... Overview of rear axle (all-wheel drive vehicle)
  • 33..... Overview of rear axle final drive/output shafts
  • 33..... Rear axle layout
  • 33 00... Rear axle: perform wheel alignment after the following repair work
• 3310 final drive
  • 00 11... Checking/topping up oil level in rear axle final drive
  • 33 10... Rear axle final drive: Assignment to model series
  • 33 10 016 Removing and installing (replacing) rear axle differential
  • 33 10 700 Replacing clutch of rear axle final drive
  • 33 10 023 Replacing radial shaft seal for output shaft at rear axle, left or right
• 3311 final drive with cover
  • 33 11 021 Replacing radial shaft seal for drive flange on rear axle final drive
• 3317 final drive mounting
  • 33 17 008 Replacing rear left or right rubber mount for cross brace
  • 33 17 502 Replacing rubber mount for rear axle final drive/rear axle support (rear axle final drive removed)
• 3321 output shafts
  • 33 21 001 Removing and installing/replacing left and right output shaft
  • 33 21 551 Replacing both gaiters on left and right of output shaft
• Rear Sub-Frame
  • 33 31 000 Completely remove and install the rear axle support (all-wheel drive)
  • 33 31 000 Removing and installing complete rear axle support
  • 33 31 011 Replacing rear axle support
  • 33 31 503 Lowering/raising rear axle support
  • 33 31 503 Lowering/raising rear axle support (AWD)
  • 33 31 012 Removing and installing/replacing rear cross member
  • 33 31 020 Removing and installing/replacing strut
• Control Arms And Struts
  • 33 32 000 Removing and installing complete left or right trailing arm
  • 33 32 000 Removing and installing complete front left or right trailing arms (all-wheel drive vehicles)
  • 33 32 086 Removing and installing/replacing bottom left and right wishbone
  • 33 32 076 Removing and installing/replacing top left and right wishbone
  • 33 32 042 Replacing a rubber mount in trailing arm, front
  • 33 32 021 Replacing left or right trailing arm
  • 33 32... Replacing left or right trailing arm holder
• Wheel Bearings
  • 33 41 180 Replacing bearing for rear wheel
  • 33 41 180 Replacing bearing for rear wheel (all-wheel drive vehicles)
• Shock Absorber
  • 33 52 000 Removing and installing/replacing rear left or right shock absorber
  • 33 52 100 Removing and installing rear left or right spring strut shock absorber
  • 33 52 161 Replacing rear left or right support bearing for spring strut/shock absorber
• Springs With Suspension
  • 33 53... Measuring vehicle ride height
  • 33 53 000 Removing and installing/replacing rear left or right coil spring
• Stabilizer Bar
  • 33 55 000 Removing and installing/replacing rear stabilizer bar
  • 33 55 041 Replacing anti-roll bar link for anti-roll bar on left or right
  • 33 55 021 Replacing both rubber mounts for anti-roll bar mounting